HOW TO USE THIS MANUALHOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
CONTENTS OF TROUBLESHOOTING DIAGNOSIS FUNCTION HOW TO USE THE INSPECTION PROCEDURES CONNECTOR MEASUREMENT SERVICE POINTS CONNECTOR INSPECTION SERVICE POINTS INSPECTION SERVICE POINTS FOR A BLOWN FUSE HOW TO COPE WITH INTERMITTENT MALFUNCTIONS
HOW TO TREAT PAST TROUBLEVEHICLE IDENTIFICATIONGENERAL DATA AND SPECIFICATIONSPRECAUTIONS BEFORE SERVICE HOW TO PERFORM VARIANT CODING VEHICLES WITH AUTOMATED MANUAL TRANSMISSION SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AND SEAT BELT PRE-TENSIONER INITIALIZATION PROCEDURE FOR LEARNING VALUE IN MPI ENGINE<134,135, 4G1> LEARNING PROCEDURE FOR IDLING IN MPI ENGINE<134,135, 4G1> INJECTOR IDENTIFICATION CODE WRITING<639> SERVICING ELECTRICAL SYSTEM VEHICLES WITH AIR CONDITIONER APPLICATION OF ANTI-CORROSION AGENTS AND UNDERCOATS VEHICLE WASHING PRE-INSPECTION CONDITION MULTI USE TESTER (M.U.T.-III) SUB ASSEMBLY IN ORDER TO PREVENT VEHICLES FROM FIRE ENGINE OILS SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SRS SERVICE PRECAUTIONSSUPPORT LOCATIONS FOR LIFTING AND JACKING SUPPORT LOCATIONS FOR LIFTING AND JACKING<COLT> SUPPORT LOCATIONS FOR LIFTING AND JACKING<COLT CZ3/CZT> TOWING AND HOISTING TIGHTENING TORQUEHOW TO READ WIRING DIAGRAMS GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) AND ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECKCRANKSHAFT PULLEYCAMSHAFTOIL PANCRANKSHAFT OIL SEALCYLINDER HEAD GASKETTIMING CHAINENGINE ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) AND ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECKCRANKSHAFT PULLEYCAMSHAFTOIL PANCRANKSHAFT OIL SEALENGINE ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATOR AND IGNITION SYSTEMFUEL AND EMISSION PARTSINLET MANIFOLDEXHAUST MANIFOLDOIL PAN AND TIMING CHAIN CASETIMING CHAINCAMSHAFTCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) AND ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECK LASH ADJUSTER CHECKCRANKSHAFT PULLEYCAMSHAFT AND VALVE STEM SEALOIL PANCRANKSHAFT OIL SEALCYLINDER HEAD GASKETTIMING BELTENGINE ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS SEALANTS SPECIAL TOOLS TORQUE SPECIFICATIONSALTERNATOR AND IGNITION SYSTEMTIMING BELTFUEL AND EMISSION PARTSWATER PUMP AND WATER HOSEINLET MANIFOLDEXHAUST MANIFOLDROCKER ARMS AND CAMSHAFTCYLINDER HEAD AND VALVESOIL PAN AND OIL PUMPPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK11H-ENGINE OVERHAUL<639>
GENERAL INFORMATION GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSALTERNATORINTAKE MANIFOLDWATER PUMP AND WATER HOSEFUEL AND EMISSION PARTSEXHAUST MANIFOLDCYLENDER HEAD COVEROIL PAN AND TIMING CHAIN CASETIMING CHAINROCKER ARMS AND CAMSHAFTBALANCER CHAINCYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE ENGINE OIL CHECK ENGINE OIL REPLACEMENT<134, 135, 639> ENGINE OIL REPLACEMENT<4G1> ENGINE OIL FILTER REPLACEMENT<134, 135, 4G1> OIL PRESSURE CHECK<134, 135, 4G1> OIL PRESSURE CHECK<639>ENGINE OIL COOLER<4G1> GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION INSPECTION CHART FOR DIAGNOSIS CODEINSPECTION PROCEDURE FOR DIAGNOSIS CODES CODE NO. P0105 MANIFOLD ABSOLUTE PRESSURE SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1961 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P1962 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P1963 TRUSTFUL CHECK MANIFOLD ABSOLUTE PRESSURE SENSOR CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1966 MANIFOLD ABSOLUTE PRESSURE SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1977 COMMUNICATION ERROR CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT INSPECTION CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT) THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING. BATTERY RUNDOWN OVERHEATING POOR A/C PERFORMANCE ENIGINE-ECU <M/T> OR ENGINE-A/T-ECU <A/T> POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM. FUEL PUMP SYSTEM A/C COMPRESSOR SYSTEM IGNITION CIRCUIT SYSTEM OIL PRESSURE SWITCH SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION INSPECTION CHART FOR DIAGNOSIS CODEINSPECTION PROCEDURE FOR DIAGNOSIS CODES CODE NO. P0011 MITSUBISHI INNOVATIVE VALVE TIMING ELECTRONIC CONTROL (MIVEC) SYSTEM CODE NO. P0105 MANIFOLD ABSOLUTE PRESSURE SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0204 NO.4 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU OR ENGINE-A/T-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1021 OIL CONTROL VALVE CIRCUIT CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1961 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P1962 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P1963 TRUSTFUL CHECK MANIFOLD ABSOLUTE PRESSURE SENSOR CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1966 MANIFOLD ABSOLUTE PRESSURE SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1968 TRUSTFUL CHECK AUTOMATED MANUAL TRANSMISSION <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1975 CYCLIC RAM TEST (GEAR) <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1976 CYCLIC RAM TEST (CLUTCH) <VEHICLE WITH AUTOMATED MANUAL TRANSMISSION> CODE NO. P1977 COMMUNICATION ERROR CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT INSPECTION CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU OR ENGINE-A-M/T-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT) THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING. BATTERY RUNDOWN OVERHEATING POOR A/C PERFORMANCE ENIGINE-ECU <M/T> OR ENGINE-A/T-ECU <A/T> POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM. FUEL PUMP SYSTEM A/C COMPRESSOR SYSTEM IGNITION CIRCUIT SYSTEM OIL PRESSURE SWITCH SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECK OIL CONTROL VALVE CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU, ENGINE-A-M/T-ECU GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION INSPECTION CHART FOR DIAGNOSIS CODEINSPECTION PROCEDURE FOR DIAGNOSIS CODES CODE NO. P0011 MITSUBISHI INNOVATIVE VALVE TIMING ELECTRONIC CONTROL (MIVEC) SYSTEM CODE NO. P0090 FUEL PRESSURE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0100 AIR FLOW SENSOR SYSTEM CODE NO. P0110 INTAKE AIR TEMPERATURE SENSOR SYSTEM CODE NO. P0115 ENGINE COOLANT TEMPERATURE SENSOR SYSTEM CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P0125 FEEDBACK SYSTEM MONITOR CODE NO. P0130 OXYGEN SENSOR (FRONT) SYSTEM CODE NO. P0135 OXYGEN SENSOR (FRONT) HEATER SYSTEM CODE NO. P0136 OXYGEN SENSOR (REAR) SYSTEM CODE NO. P0141 OXYGEN SENSOR (REAR) HEATER SYSTEM CODE NO. P0170 ABNORMAL FUEL SYSTEM CODE NO. P0201 NO.1 INJECTOR SYSTEM CODE NO. P0202 NO.2 INJECTOR SYSTEM CODE NO. P0203 NO.3 INJECTOR SYSTEM CODE NO. P0204 NO.4 INJECTOR SYSTEM CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0243 WASTE GATE SOLENOID VALVE SYSTEM CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0325 DETONATION SENSOR SYSTEM CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0420 CATALYST MALFUNCTION CODE NO. P0443 PURGE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1021 OIL CONTROL VALVE CIRCUIT CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1232 FAIL-SAFE CONTROL SYSTEM CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1630 VARIANT CODING ERRORS CODE NO. P1964 AD CONVERTER CODE NO. P1965 TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P1967 TRUSTFUL CHECK ENGINE SPEED CODE NO. P1969 TRUSTFUL CHECK IGNITION ANGLE <VEHICLE WITH ASC> CODE NO. P1970 TORQUE MONITORING CODE NO. P1971 FAIL-SAFE CONTROL MONITORING CODE NO. P1972 INQUIRY/RESPONSE ERROR CODE NO. P1973 RAM TEST FOR ALL AREA CODE NO. P1974 CYCLIC RAM TEST (ENGINE) CODE NO. P1977 COMMUNICATION ERROR CODE NO. P1978 THROTTLE VALVE CONTROL SERVO MALFUNCTION CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. U1073 BUS OFF CODE NO. U1102 ABS-ECU TIME-OUT CODE NO. U1106 EPS TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1109 ETACS TIME-OUT CODE NO. U1110 A/C-ECU TIME-OUT CODE NO. U1112 SRS TIME-OUT INSPECTION CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (STARTER INOPERATIVE) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT) THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING OFFSET RUN ON (DIESELING) ODOR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION CO/HC DURING IDLING. BATTERY RUNDOWN OVERHEATING POOR A/C PERFORMANCE ENIGINE-ECU POWER SUPPLY, ENGINE CONTROL RELAY, IGUNITION SWITCH-IG1 SYSTEM. FUEL PUMP SYSTEM A/C COMPRESSOR SYSTEM IGNITION CIRCUIT SYSTEM OIL PRESSURE SWITCH SYSTEM CLUTCH PEDAL POSITION SWITCH SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECK OIL CONTROL VALVE CHECK FUEL PRESSURE CONTROL SOLENOID VALVE CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION INSPECTION CHART FOR DIAGNOSIS CODE PROBLEM SYMPTOM TABLESYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU OR ENGINE-A-M/T-ECU IS NOT POSSIBLE STARTER SYSTEM ENGINE-ECU OR ENGINE-A-M/T-ECU POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM BOOST PRESSURE SENSOR SYSTEM MASS AIR FLOW SENSOR SYSTEM ENGINE COOLANT TEMPERATURE SENSOR SYSTEM FUEL TEMPERATURE SENSOR SYSTEM BOOST AIR TEMPERATURE SENSOR SYSTEM BROADBAND LAMBDA OXYGEN SENSOR SYSTEM RAIL PRESSURE SENSOR SYSTEM CRANK ANGLE SENSOR SYSTEM ACCELERATOR PEDAL POSITION SENSOR (MAIN) SYSTEM ACCELERATOR PEDAL POSITION SENSOR (SUB) SYSTEM NO. 1 INJECTOR SYSTEM NO. 2 INJECTOR SYSTEM NO. 3 INJECTOR SYSTEM WASTE GATE SOLENOID VALVE SYSTEM EGR CONTROL SOLENOID VALVE SYSTEM RAIL PRESSURE CONTROL VALVE SYSTEM INTAKE DUCT OFF MOTOR SYSTEM FUEL QUANTITY CONTROL VALVE SYSTEM ALTERNATOR SYSTEM FUEL PUMP SYSTEM GLOW SYSTEM CLUTCH SWITCH SYSTEM<M/T> A/C VARIABLE COMPRESSOR SYSTEM OIL PRESSURE SWITCH SYSTEM PTC HEATER REQUEST SIGNAL SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU TERMINALS INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK FUEL TEMPERATURE SENSOR CHECK BOOST AIR TEMPERATURE SENSOR CHECK ACCELERATOR PEDAL POSITION SENSOR CHECK INJECTOR CHECK CRANK ANGLE SENSOR CHECK RAIL PRESSURE CONTROL VALVE CHECK FUEL QUANTITY CONTROL VALVE CHECK BROADBAND LAMBDA OXYGEN SENSOR CHECKENGINE-ECU, ENGINE-A-M/T-ECU GENERAL INFORMATION SPECIAL TOOL(S)ON-VEHICLE SERVICE FUEL PUMP OPERATION CHECK FUEL GAUGE UNIT CHECK FUEL PUMP (MODULE) REPLACEMENT FUEL LEAK CHECK OF FUEL TANKFUEL TANKFUEL FILTER<639> GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S)<4G1> SPECIAL TOOL(S)TROUBLESHOOTINGON-VEHICLE SERVICE ENGINE COOLANT LEAK CHECK RADIATOR CAP OPENING PRESSURE CHECK ENGINE COOLANT CHANGE<134, 135> ENGINE COOLANT CHANGE<4G1> ENGINE COOLANT CHANGE<639> ENGINE COOLANT CONCENTRATION TEST FAN CONTROL RELAY CONTINUITY CHECK RADIATOR FAN MOTOR CHECKTHERMOSTAT THERMOSTAT REMOVAL AND INSTALLATION<134, 135> THERMOSTAT REMOVAL AND INSTALLATION<4G1> THERMOSTAT INSPECTION<134, 135, 4G1>WATER PUMPWATER HOSE AND WATER PIPE WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<134, 135> WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<4G1> WATER HOSE AND WATER PIPE INSPECTION<134, 135, 4G1>RADIATOR GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE TURBOCHARGER SUPERCHARGING PRESSURE CHECK<4G1> TURBOCHARGER SUPERCHARGING PRESSURE CHECK<639> SUPERCHARGING PRESSURE CONTROL SYSTEM CHECK<4G1> TURBOCHARGER WASTE GATE ACTUATOR CHECK<4G1> TURBOCHARGER WASTE GATE ACTUATOR CHECK<639> TURBOCHARGER WASTE GATE SOLENOID CHECK<4G1> TURBOCHARGER WASTE GATE SOLENOID CHECK<639> AIR BY-PASS VALVE CHECK<4G1> INTAKE MANIFOLD VACUUM CHECK<134, 135, 4G1>AIR CLEANER AIR CLEANER REMOVAL AND INSTALLATION<134, 135> AIR CLEANER REMOVAL AND INSTALLATION<4G1> AIR CLEANER REMOVAL AND INSTALLATION<639>INTERCOOLERINLET MANIFOLD INLET MANIFOLD REMOVAL AND INSTALLATION<134> INLET MANIFOLD REMOVAL AND INSTALLATION<135> INLET MANIFOLD REMOVAL AND INSTALLATION<4G1> INLET MANIFOLD INSPECTION<134, 135, 4G1>EXHAUST MANIFOLD EXHAUST MANIFOLD REMOVAL AND INSTALLATION<134> EXHAUST MANIFOLD REMOVAL AND INSTALLATION<135> EXHAUST MANIFOLD INSPECTION<134, 135>EXHAUST MANIFOLD AND TURBOCHARGER EXHAUST MANIFOLD AND TURBOCHARGER REMOVAL AND INSTALLATION<4G1> EXHAUST MANIFOLD AND TURBOCHARGER INSPECTION<4G1>EXHAUST PIPE AND MAIN MUFFLERCHARGING SYSTEM GENERAL INFORMATION<134, 135, 4G1> SERVICE SPECIFICATION(S)<134, 135, 4G1> SPECIAL TOOL(S)<134, 135, 4G1>ON-VEHICLE SERVICE ALTERNATOR OUTPUT LINE VOLTAGE DROP TEST<134, 135, 4G1> OUTPUT CURRENT TEST<134, 135, 4G1> REGULATED VOLTAGE TEST<134, 135, 4G1> WAVE PATTERN CHECK USING AN OSCILLOSCOPE<134, 135, 4G1>ALTERNATOR ASSEMBLYSTARTING SYSTEMIGNITION SYSTEM GENERAL INFORMATION<134, 135, 4G1> SERVICE SPECIFICATION(S)<134, 135, 4G1> SEALANT(S) OR ADHESIVE(S)<134, 135>ON-VEHICLE SERVICE IGNITION COIL CHECK<134, 135, 4G1> SPARK PLUG CHECK AND CLEANING<134, 135> SPARK PLUG CHECK AND CLEANING<4G1> CAMSHAFT POSITION SENSOR CHECK<134, 135, 4G1> CRANKANGLE SENSOR CHECK<134, 135, 4G1> DETONATION SENSOR CHECK<134, 135, 4G1>IGNITION COILCAMSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<134, 135> CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<4G1>CRANK ANGLE SENSOR CRANK ANGLE SENSOR REMOVAL AND INSTALLATION<134, 135> CRANK ANGLE SENSOR REMOVAL AND INSTALLATION<4G1>DETONATION SENSORGLOW SYSTEMENGINE CONTROLEMISSION CONTROL <MPI><134, 135, 4G1> GENERAL INFORMATION EMISSION CONTROL DEVICE REFERENCE TABLE SERVICE SPECIFICATION(S)VACUUM HOSECRANKCASE EMISSION CONTROL SYSTEM GENERAL INFORMATION (CRANKCASE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (CRANKCASE EMISSION CONTROL SYSTEM) POSITIVE CRANKCASE VENTILATION SYSTEM CHECK POSITIVE CRANKCASE VENTILATION (PCV) VALVE CHECKEVAPORATIVE EMISSION CONTROL SYSTEM GENERAL INFORMATION (EVAPORATIVE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (EVAPORATIVE EMISSION CONTROL SYSTEM) PURGE CONTROL SYSTEM CHECK PURGE PORT VACUUM CHECK PURGE CONTROL SOLENOID VALVE CHECK CANISTER REMOVAL AND INSTALLATIONCATALYTIC CONVERTEREMISSION CONTROL <DIESEL><639>
GENERAL INFORMATION EMISSION CONTROL DEVICE REFERENCE TABLE SERVICE SPECIFICATION(S) SPECIAL TOOL(S)VACUUM HOSEEXHAUST GAS RECIRCULATION (EGR) SYSTEM GENERAL INFORMATION (EGR SYSTEM) COMPONENT LOCATION (EGR SYSTEM) EGR SYSTEM CHECK EGR VALVE CHECK EGR VACUUM CHECK EGR CONTROL SOLENOID VALVE CHECK MASS AIR FLOW SENSOR CHECK CRANK ANGLE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK BOOST AIR TEMPERATURE SENSOR CHECK BROADBAND LAMBDA OXYGEN SENSOR CHECK CHECK AT THE ENGINE ECU TERMINALSCATALYTIC CONVERTER GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S)ON-VEHICLE SERVICECLUTCH PEDALCLUTCH CONTROL22A-MANUAL TRANSMISSION (FF)
GENERAL INFORMATION LUBRICANT SPECIAL TOOLSON-VEHICLE SERVICETRANSMISSION CONTROLTRANSMISSION ASSEMBLY22C-AUTOMATED MANUAL TRANSMISSION
GENERAL INFORMATION LUBRICANT SEALANT AND ADHESIVE SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS FUNCTIONSPECIAL FUNCTION CLUTCH AND GEAR SPECIAL FUNCTION TEACH-IN CLUTCH END POSITION TEACH IN CLUTCH TOUCH POSITION INITIALIZATION OF CLUTCH PROTECTION DATA INITIALIZATION OF EEPROM START GEARBOX ADAPTION POSITIONIN OF SHIFTDRUMS FOR SENSOR - CHANGE DTC PROCEDURE CHART FOR DIAGNOSIS CODES SYMPTOM CHARTSYMPTOM PROCEDURES Malfunction of Automated Manual Transmission Control Relay System Clutch Actuator System Malfunction Shift Actuator 1, 2 System Malfunction Input Speed Sensor System Malfunction Drum Position Sensor System Malfunction Allshift Lever System Malfunction DATA LIST REFERENCE TABLE CHECK AT ENGINE-A-M/T-ECU TERMINALSON-VEHICLE SERVICE TRANSMISSION OIL LEVEL CHECK TRANSMISSION OIL CHANGE AUTOMATED MANUAL TRANSMISSION CONTROL RELAY CHECKALLSHIFT LEVER ASSEMBLYACTUATORS AND SENSORSTRANSMISSION ASSEMBLY26 -FRONT AXLE
GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEFRONT AXLE HUB ASSEMBLYDRIVESHAFT ASSEMBLY GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEREAR AXLE HUB ASSEMBLY GENERAL INFORMATION<COLT> GENERAL INFORMATION<COLT CZ3/CZT> SERVICE SPECIFICATION(S)TROUBLESHOOTINGON-VEHICLE SERVICE TYRE INFLATION PRESSURE CHECK TYRE WEAR CHECK WHEEL RUNOUT CHECK REMOVING TYREWELD FROM TYRES TREATMENT OF RECOVERY BOTTLE AFTER OLD TYREWELD IS REMOVEDWHEEL AND TYRE GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ENGINE MOUNTING ENGINE MOUNTING REMOVAL AND INSTALLATION<134, 135> ENGINE MOUNTING REMOVAL AND INSTALLATION<4G1> ENGINE MOUNTING REMOVAL AND INSTALLATION<639>TRANSMISSION MOUNTING TRANSMISSION MOUNTING REMOVAL AND INSTALLATION<134, 135, 639> TRANSMISSION MOUNTING REMOVAL AND INSTALLATION<4G1>ENGINE ROLL STOPPER RODCROSSMEMBER GENERAL INFORMATION SERVICE SPECIFICATIONS LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE FRONT WHEEL ALIGNMENT CHECK AND ADJUSTMENT LOWER ARM BALL JOINT AXIAL PLAY CHECK LOWER ARM BALL JOINT DUST COVER CHECKSTRUT ASSEMBLY STRUT ASSEMBLY REMOVAL AND INSTALLATION STRUT ASSEMBLY INSPECTION STRUT ASSEMBLY DISASSEMBLY AND REASSEMBLY STRUT ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)LOWER ARM LOWER ARM REMOVAL AND INSTALLATION<Except 4G1> LOWER ARM REMOVAL AND INSTALLATION<4G1> LOWER ARM INSPECTIONSTABILIZER BAR GENERAL INFORMATION SERVICE SPECIFICATION(S)ON-VEHICLE SERVICESHOCK ABSORBER AND COIL SPRINGTORSION AXLE ARM ASSEMBLY GENERAL INFORMATION SERVICE SPECIFICATIONS LUBRICANTS SPECIAL TOOL(S)ON-VEHICLE SERVICE BRAKE PEDAL CHECK AND ADJUSTMENT BRAKE BOOSTER OPERATING CHECK CHECK VALVE OPERATION CHECK BASIC BRAKE SYSTEM BLEEDING BRAKE FLUID LEVEL SENSOR CHECK DISC BRAKE PAD CHECK AND REPLACEMENT DISC BRAKE ROTOR CHECK BRAKE LINING THICKNESS CHECK BRAKE DRUM INSIDE DIAMETER CHECK BRAKE LINING AND BRAKE DRUM CONTACT CHECKBRAKE PEDALMASTER CYLINDER ASSEMBLY AND BRAKE BOOSTERFRONT DISC BRAKE ASSEMBLY FRONT DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION FRONT DISC BRAKE ASSEMBLY INSPECTION FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY FRONT DISC BRAKE ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)REAR DISC BRAKE ASSEMBLY REAR DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION REAR DISC BRAKE ASSEMBLY INSPECTION REAR DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLYREAR DRUM BRAKE GENERAL INFORMATION SERVICE SPECIFICATIONS SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS ABS WARNING LAMP INSPECTION DIAGNOSIS FUNCTION CHECK CHART FOR DIAGNOSIS CODESDIAGNOSIS TROUBLE CODE PROCEDURES C1200 FRONT RIGHT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) C1201 FRONT RIGHT WHEEL SPEED SENSOR C1205 FRONT LEFT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) C1206 FRONT LEFT WHEEL SPEED SENSOR C1210 REAR RIGHT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) C1211 REAR RIGHT WHEEL SPEED SENSOR C1215 REAR LEFT WHEEL SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) C1216 REAR LEFT WHEEL SPEED SENSOR C1266 MOTOR SYSTEM C1273 MOTOR RELAY STUCK OFF C1274 MOTOR RELAY STUCK ON C1276 VALVE RELAY C1278 VALVE RELAY STUCK OFF C1279 VALVE RELAY STUCK ON C1345 BRAKE FLUID LEVEL FAILURE Code No.C1640: Variant coding value invalid Code No.C1641: Variant coding values (old and new) mismatch C1860 ABS-ECU POWER SUPPLY HIGH VOLTAGE C1861 ABS-ECU POWER SUPPLY LOW VOLTAGE U1073 Bus off Code No.C1100: Engine CAN Timeout INSPECTION CHART FOR TROUBLE SYMPTOMSINSPECTION PROCEDURE FOR TROUBLE SYMPTOMS M.U.T.-III cannot communicate with ABS-ECU ABS WARNING LAMP DOES NOT ILLUMINATE WHEN THE IGNITION SWITCH IS ON. ABS WARNING LAMP DOES NOT EXTINGUISH AFTER THE ENGINE IS STARTED. BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE PARKING BRAKE IS OPERATED. BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE BRAKE FLUID LEVEL IS LOW. BRAKE WARNING LAMP DOES NOT EXTINGUISH WHEN THE IGNITION SWITCH IS ON. THE ABS OPERATES TOO FREQUENTLY (NO DIAGNOSIS CODE IS SET). DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICEHYDRAULIC UNITABS SENSOR GENERAL INFORMATION SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS TCL/ACTIVE STABILITY CONTROL SYSTEM INDICATOR LAMP, TCL-OFF INDICATOR LAMP, BRAKE WARNING LAMP INSPECTION DIAGNOSIS FUNCTION CHECK CHART FOR DIAGNOSIS CODESDIAGNOSIS CODE PROCEDURES Code No. C1200 Code No. C1201 ABS SENSOR SYSTEM Code No. C1205 Wheel speed sensor (FL) system (open or short circuit) Code No. C1206 ABS sensor system Code No. 1210 Wheel speed sensor (RR) system (open or short circuit) Code No. C1211 ABS sensor system Code No. C1215 Wheel speed sensor (RL) system (open or short circuit) Code No. C1216 ABS sensor system Code No. C1225 Code No. C1226/C1231/C1236/C1241/C1246/C1251/C1256/C1261/C1300/C1305/C1310/C1315 CONTROL SOLENOID VALVE SYSTEM Code No. C1266 Code No. C1273 Code No. C1274 Code No. C1276 Code No. C1278 Code No. C1279 Code No. C1340 Code No. C1345 Code No. C1364 Code No. C1366 Code No. C1371 Code No. C1385 Code No. C1387 Code No. C1388 Code No. C1394 Code No. C1396 Code No. C1398 Code No. C1505 Code No. C1555 Code No. C1607 Code No. C1640 Code No. C1641 Code No. C1860 Code No. C1861 Code No. C1862 Code No. C1863 Code No. U1073 Code No. U1100/U1406/U1426/U1427/U1428/U1429/U1430 Code No. U1101 Code No. U1104/U1200/U1204 Code No. U1105/U1201/U1205 Code No.U1106: EPS CAN time out Code No. U1413/U1431 SYMPTOM CHARTSYMPTOM PROCEDURES THE SCAN TOOL CAN NOT COMMUNICATE WITH TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU POWER SUPPLY CIRCUIT SYSTEM The TCL/ACTIVE STABILITY CONTROL SYSTEM indicator lamp does not illuminate when the ignition switch is on (but does not start the engine). The TCL/ACTIVE STABILITY CONTROL SYSTEM indicator lamp does not illuminate after the engine is started. BRAKE WARNING LAMP DOES NOT ILLUMINATE AT ALL. BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE PARKING BRAKE IS OPERATED (BUT ILLUMINATES NORMALLY WHEN CHECKING FOR BLOWN BULB). THE BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE BRAKE FLUID LEVEL IS LOW (BUT ILLUMINATES WHEN THE PARKING BRAKE IS APPLIED). BRAKE WARNING LAMP DOES NOT EXTINGUISH WHEN THE IGNITION SWITCH IS ON (REMAINS ILLUMINATED). ACTIVE STABILITY CONTROL SYSTEM OPERATES FREQUENTLY (NO DIAGNOSIS CODE IS SET). STEERING WHEEL SENSOR POWER SUPPLY CIRCUIT G AND YAW RATE SENSOR POWER SUPPLY CIRCUIT DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICEHYDRAULIC UNITWHEEL SPEED SENSORG AND YAW RATE SENSORSTEERING WHEEL SENSOR37 -POWER STEERING
GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION CHECK OF ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP CHECK CHART FOR DIAGNOSIS CODESDIAGNOSTIC TROUBLE CODE PROCEDURES C1511/C1512 TORQUE SENSOR ABNORMALITY C1513 LARGE DIFFERENCE BETWEEN MAIN TORQUE SENSOR AND SUB TORQUE SENSOR C1514 TORQUE SENSOR POWER SUPPLY ABNORMALITY C1521 VEHICLE SPEED SENSOR INPUT MALFUNCTION C1522 ENGINE SPEED INPUT MALFUNCTION C1531 MOTOR TERMINAL VOLTAGE ABNORMALITY C1532 OVER REAL CURRENT OF MOTOR C1534 UNDER REAL CURRENT OF MOTOR C1542 FAIL-SAFE RELAY STUCK OFF C1860 POWER SUPPLY VOLTAGE ABNORMALITY (HIGH VOLTAGE) C1861 POWER SUPPLY VOLTAGE ABNORMALITY (LOW VOLTAGE) U1073 BUS OFF U1100 ENGINE-RELATED TIME-OUT U1102 ABS-ECU TIME-OUT U1120 ENGINE-RELATED FAIL INFORMATION U1122 ABS-ECU FAIL INFORMATION CHECK CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <CAN COMMUNICATION SYSTEM CHECK> M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <ECU POWER SUPPLY CIRCUIT SYSTEM CHECK> ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP ILLUMINATES BUT DIAGNOSIS CODE IS NOT STORED. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE STEERING WHEEL FREE PLAY CHECK STEERING ANGLE CHECK TIE ROD END BALL JOINT STARTING TORQUE CHECK STATIONARY STEERING EFFORT CHECK BALL JOINT DUST COVER INSPECTION STEERING COLUMN SHAFT ASSEMBLY SHOCK ABSORBING MECHANISM CHECKSTEERING WHEELSTEERING SHAFTPOWER STEERING GEAR BOX AND LINKAGEELECTRIC POWER STEERING CONTROL UNITHOODON-VEHICLE SERVICE ADJUSTMENT OF CLEARANCE AROUND HOOD ADJUSTMENT OF ALIGNMENT OF HOOD STEPPED PORTION AND HOOD STRIKER ADJUSTMENT OF HOOD HEIGHTHOODFENDERFUEL FILLER LID FUEL FILLER LID REMOVAL AND INSTALLATION<COLT> FUEL FILLER LID REMOVAL AND INSTALLATION<COLT CZ3/CZT>STRUT TOWER BAR<COLT CZ3/CZT (1500 MPI-T/C)>PROTECTOR FILM PROTECTOR FILM REMOVAL AND INSTALLATION<COLT> PROTECTOR FILM REMOVAL AND INSTALLATION<COLT CZ3/CZT (Vehicles without side air dam)>WINDOW GLASS SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S) GENERAL INFORMATIONWINDSHIELDDELTA WINDOW GLASS DELTA WINDOW GLASS REMOVAL AND INSTALLATION<COLT> DELTA WINDOW GLASS REMOVAL AND INSTALLATION<COLT CZ3/CZT>QUARTER WINDOW GLASS QUARTER WINDOW GLASS REMOVAL AND INSTALLATION<COLT> QUARTER WINDOW GLASS REMOVAL AND INSTALLATION<COLT CZ3/CZT>TAILGATE WINDOW GLASSDOOR SERVICE SPECIFICATION(S)<COLT> SERVICE SPECIFICATION(S)<COLT CZ3/CZT> SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW CHECK CHART FOR TROUBLE SYMPTOMS<CENTRAL DOOR LOCKING SYSTEM> CHECK CHART FOR TROUBLE SYMPTOMS<POWER WINDOWS> CHECK CHART FOR TROUBLE SYMPTOMS<DEAD LOCK SYSTEM>SYMPTOM PROCEDURES<CENTRAL DOOR LOCKING SYSTEM> CENTRAL DOOR LOCKING SYSTEM DOES NOT OPERATE SOME DOORS DO NOT LOCK OR UNLOCK<LH drive vehicles> SOME DOORS DO NOT LOCK OR UNLOCK<RH drive vehicles>SYMPTOM PROCEDURES<POWER WINDOWS> POWER WINDOWS DO NOT WORK AT ALL POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW<LH drive vehicles> POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW<RH drive vehicles> POWER WINDOW SUB SWITCH CANNOT OPERATE PASSENGER''S OR REAR WINDOWS. POWER WINDOW MAIN SWITCH CANNOT OPERATE EITHER OF PASSENGER''S OR REAR POWER WINDOWS POWER WINDOW TIMER FUNCTION DOES NOT WORK NORMALLY WHEN THE GLASS IS RAISED, THEN IT LOWERS AUTOMATICALLYSYMPTOM PROCEDURES<DEAD LOCK SYSTEM> DEAD LOCK SYSTEM DOES NOT WORK AT ALL<COLT> DEAD LOCK SYSTEM DOES NOT WORK AT ALL<COLT CZ3/CZT> A DOOR DOES NOT WORK EVEN IF THE DEAD LOCK IS OPERATED<COLT> A DOOR DOES NOT WORK EVEN IF THE DEAD LOCK IS OPERATED<COLT CZ3/CZT> HAZARD LAMP ANSWERBACK OF DEAD LOCK SYSTEM DOES NOT WORK DEAD LOCK TIMER FUNCTION DOES NOT WORKON-VEHICLE SERVICE<COLT> FRONT AND REAR DOOR FIT ADJUSTMENT ADJUSTMENT OF DOOR HEIGHT DOOR WINDOW GLASS ADJUSTMENT GLASS SLIDING MECHANISM CHECK AND ADJUSTMENT POWER WINDOW TIMER FUNCTION CHECK POWER WINDOW OPERATING CURRENT CHECK POWER WINDOW RELAY CHECK POWER WINDOW CHECK CENTRAL DOOR LOCKING SYSTEM INSPECTION CHECK OF KEY LOCK PREVENTION FUNCTION DEAD LOCK SYSTEM INSPECTION DEAD LOCK TIMER FUNCTION INSPECTION DOOR OUTSIDE HANDLE PLAY CHECK DOOR INSIDE HANDLE PLAY ADJUSTMENTON-VEHICLE SERVICE<COLT CZ3/CZT> FRONT DOOR FIT ADJUSTMENT ADJUSTMENT OF DOOR HEIGHT DOOR WINDOW GLASS ADJUSTMENT GLASS SLIDING MECHANISM CHECK AND ADJUSTMENT POWER WINDOW TIMER FUNCTION CHECK POWER WINDOW OPERATING CURRENT CHECK POWER WINDOW RELAY CHECK POWER WINDOW CHECK CENTRAL DOOR LOCKING SYSTEM INSPECTION CHECK OF KEY LOCK PREVENTION FUNCTION DEAD LOCK SYSTEM INSPECTION DEAD LOCK TIMER FUNCTION INSPECTION DOOR OUTSIDE HANDLE PLAY CHECK DOOR INSIDE HANDLE PLAY ADJUSTMENTDOOR ASSEMBLY DOOR ASSEMBLY REMOVAL AND INSTALLATION<COLT> DOOR ASSEMBLY REMOVAL AND INSTALLATION<COLT CZ3/CZT> DOOR SWITCH CHECKDOOR GLASS AND REGULATOR DOOR GLASS AND REGULATOR REMOVAL AND INSTALLATION<COLT> DOOR GLASS AND REGULATOR REMOVAL AND INSTALLATION<COLT CZ3/CZT> DOOR GLASS AND REGULATOR INSPECTION<COLT> DOOR GLASS AND REGULATOR INSPECTION<COLT CZ3/CZT>DOOR HANDLE AND LATCH DOOR HANDLE AND LATCH REMOVAL AND INSTALLATION<COLT> DOOR HANDLE AND LATCH REMOVAL AND INSTALLATION<COLT CZ3/CZT> DOOR HANDLE AND LATCH INSPECTION<COLT> DOOR HANDLE AND LATCH INSPECTION<COLT CZ3/CZT>WINDOW GLASS RUNCHANNEL AND DOOR OPENING WEATHERSTRIPTAILGATE SERVICE SPECIFICATION(S)<COLT> SERVICE SPECIFICATION(S)<COLT CZ3/CZT> SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S) TROUBLESHOOTINGON-VEHICLE SERVICE<COLT>ON-VEHICLE SERVICE<COLT CZ3/CZT>TAILGATETAILGATE HANDLE AND LATCHKEYLESS ENTRY SYSTEM SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW CHECK CHART FOR DIAGNOSIS CODES CHECK CHART FOR TROUBLE SYMPTOMS INPUT SIGNAL CHARTDIAGNOSTIC TROUBLE CODE PROCEDURESSYMPTOM PROCEDURES KEYLESS ENTRY SYSTEM DOES NOT OPERATE THE DOME LAMP, THE HAZARD WARNING LAMPS AND THE HORN DO NOT OPERATE THROUGH THE ANSWERBACK FUNCTION. AFTER THE DOORS ARE UNLOCKED BY USING THE KEYLESS ENTRY SYSTEM, THE TIMER LOCK FUNCTION DOES NOT WORK.INPUT SIGNAL PROCEDURESON-VEHICLE SERVICE KEYLESS ENTRY SYSTEM INSPECTION KEYLESS ENTRY SYSTEM TIMER LOCK FUNCTION INSPECTION METHOD OF REGISTERING A SECRET CODETRANSMITTERSUNROOF ASSEMBLY SERVICE SPECIFICATION(S)TROUBLESHOOTINGSYMPTOM PROCEDURES SUNROOF DOES NOT OPERATE ANY OF THE SUNROOF SWITCH POSITION IS DEFECTIVE SUNROOF ANTI-TRAP FUNCTION DOES NOT WORKON-VEHICLE SERVICE WATER TEST SUNROOF FIT ADJUSTMENT SUNROOF OPERATION CHECK SUNROOF SAFETY FUNCTION CHECK ROOF LID GLASS OPERATION CURRENT CHECK SUNROOF INITIALIZED ADJUSTMENTSUNROOF ASSEMBLYLOOSE PANELFRONT BUMPER ASSEMBLY SEALANT(S) OR ADHESIVE(S) FRONT BUMPER ASSEMBLY REMOVAL AND INSTALLATION FRONT BUMPER ASSEMBLY DISASSEMBLY AND REASSEMBLY<COLT> FRONT BUMPER ASSEMBLY DISASSEMBLY AND REASSEMBLY<COLT CZ3/CZT>REAR BUMPER ASSEMBLY REAR BUMPER ASSEMBLY REMOVAL AND INSTALLATION<COLT> REAR BUMPER ASSEMBLY REMOVAL AND INSTALLATION<COLT CZ3/CZT>RADIATOR GRILLEMOULDINGSSIDE AIR DAM<1500 MPI-T/C>DOOR SASH TAPE<1500 MPI-T/C>TAILGATE SPOILER<1500 MPI-T/C>WINDSHIELD WIPER AND WASHER SERVICE SPECIFICATION(S) TROUBLESHOOTINGON-VEHICLE SERVICEWINDSHIELD WIPER WINDSHIELD WIPER REMOVAL AND INSTALLATION INSPECTION<LH drive vehicles> INSPECTION<RH drive vehicles>WINDSHIELD WASHERRAIN SENSORREAR WIPER AND WASHERMARKDOOR MIRROR SPECIAL TOOLSINSTRUMENT PANEL ASSEMBLYGLOVE BOXFLOOR CONSOLE ASSEMBLYTRIMSINTERIOR TRIMDOOR TRIMTAILGATE TRIMHEADLININGFRONT SEAT ASSEMBLY SERVICE SPECIFICATION(S) FRONT SEAT ASSEMBLY REMOVAL AND INSTALLATION INSPECTION FRONT SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLYREAR SEAT ASSEMBLY REAR SEAT ASSEMBLY REMOVAL AND INSTALLATION<COLT> REAR SEAT ASSEMBLY REMOVAL AND INSTALLATION<COLT CZ3/CZT> REAR SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLY<COLT> REAR SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLY<COLT CZ3/CZT>FRONT SEAT BELT FRONT SEAT BELT REMOVAL AND INSTALLATION<COLT> INSPECTION<COLT> FRONT SEAT BELT REMOVAL AND INSTALLATION<COLT CZ3/CZT> INSPECTION<COLT CZ3/CZT>REAR SEAT BELT GENERAL DESCRIPTION SERVICE PRECAUTIONS SPECIAL TOOL(S) TEST EQUIPMENTSTROUBLESHOOTING<COLT> DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION SRS WARNING LAMP CHECK CHECK CHART FOR DIAGNOSIS CODESDIAGNOSTIC TROUBLE CODE PROCEDURES DTC B1400 DRIVER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1401 DRIVER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1402 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1403 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1405 SYSTEM INSIDE SRS-ECU DTC B1406 G-SENSOR OF FRONT IMPACT SENSOR (RH) FAILURE DTC B1407 FRONT IMPACT SENSOR (RH) VOTAGE ERROR DTC B1408 FRONT IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1410 FRONT PASSENGER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1411 FRONT PASSENGER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1412 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1413 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1417 FRONT IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1418 FRONT IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1420 SIDE-AIRBAG SQUIB (RH) SHORT-CIRCUITED DTC B1421 SIDE-AIRBAG SQUIB (RH) OPEN-CIRCUITED DTC B1422 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1423 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1426 G-SENSOR OF SIDE IMPACT SENSOR (RH)FAILURE DTC B1427 SIDE IMPACT SENSOER (RH) VOLTAGE ERROR DTC B1428 SIDE IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1430 SIDE-AIRBAG SQUIB (LH) SHORT-CIRCUITED DTC B1431 SIDE-AIRBAG SQUIB (LH) OPEN-CIRCUITED DTC B1432 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (GROUND SIDE) SHORTED DTC B1433 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1437 SIDE IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1438 SIDE IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1440 CURTAIN AIR BAG SQUIB (RH) SHORT-CIRCUITED DTC B1441 CURTAIN AIR BAG SQUIB (RH) OPEN-CIRCUITED DTC B1442 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1443 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1450 CURTAIN AIR BAG SQUIB (LH) SHORT-CIRCUITED DTC B1451 CURTAIN AIR BAG SQUIB (LH) OPEN-CIRCUITED DTC B1452 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1453 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1460 SEAT BELT PRE-TENSIONER (RH) SQUIB SHORT-CIRCUITED DTC B1461 SEAT BELT PRE-TENSIONER (RH) SQUIB OPEN-CIRCUITED DTC B1462 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1463 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1470 SEAT BELT PRE-TENSIONER (LH) SQUIB SHORT-CIRCUITED DTC B1471 SEAT BELT PRE-TENSIONER (LH) SQUIB OPEN-CIRCUITED DTC B1472 SEAT BELT PRE-TENSIONER (LH) SQUIB (EARTH SIDE) SHORT-CIRCUITED DTC B1473 SEAT BELT PRE-TENSIONER (LH) SQUIB (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1476 POWER SUPPLY VOLTAGE [IG1 (A) VOLTAGE] DROPS ABNORMALLY DTC B1499 IGNITION OF THE AIR BAG COMPLETED DTC B1509 INCORRECT SRS-ECU DTC B1593 SRS-ECU NOISE FAULT DTC U1073 BUS-OFF CHECK CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES THE M.U.T.-III CANNOT COMMUNICATE WITH THE SRS-ECU. POWER SUPPLY CIRCUIT SYSTEM WHEN THE IGNITION SWITCH IS TURNED TO "ON", THE SRS WARNING LAMP DOES NOT ILLUMINATE. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLETROUBLESHOOTING<COLT CZ3/CZT> DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION SRS WARNING LAMP CHECK CHECK CHART FOR DIAGNOSIS CODESDIAGNOSTIC TROUBLE CODE PROCEDURES DTC B1400 DRIVER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1401 DRIVER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1402 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1403 DRIVER''S AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1405 SYSTEM INSIDE SRS-ECU DTC B1406 G-SENSOR OF FRONT IMPACT SENSOR (RH) FAILURE DTC B1407 FRONT IMPACT SENSOR (RH) VOTAGE ERROR DTC B1408 FRONT IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1410 FRONT PASSENGER''S AIR BAG SQUIB SHORT-CIRCUITED DTC B1411 FRONT PASSENGER''S AIR BAG SQUIB OPEN-CIRCUITED DTC B1412 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1413 FRONT PASSENGER''S SIDE AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1417 FRONT IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1418 FRONT IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1420 SIDE-AIRBAG SQUIB (RH) SHORT-CIRCUITED DTC B1421 SIDE-AIRBAG SQUIB (RH) OPEN-CIRCUITED DTC B1422 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1423 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1426 G-SENSOR OF SIDE IMPACT SENSOR (RH)FAILURE DTC B1427 SIDE IMPACT SENSOER (RH) VOLTAGE ERROR DTC B1428 SIDE IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1430 SIDE-AIRBAG SQUIB (LH) SHORT-CIRCUITED DTC B1431 SIDE-AIRBAG SQUIB (LH) OPEN-CIRCUITED DTC B1432 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (GROUND SIDE) SHORTED DTC B1433 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1437 SIDE IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1438 SIDE IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1440 CURTAIN AIR BAG SQUIB (RH) SHORT-CIRCUITED DTC B1441 CURTAIN AIR BAG SQUIB (RH) OPEN-CIRCUITED DTC B1442 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1443 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1450 CURTAIN AIR BAG SQUIB (LH) SHORT-CIRCUITED DTC B1451 CURTAIN AIR BAG SQUIB (LH) OPEN-CIRCUITED DTC B1452 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1453 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1460 SEAT BELT PRE-TENSIONER (RH) SQUIB SHORT-CIRCUITED DTC B1461 SEAT BELT PRE-TENSIONER (RH) SQUIB OPEN-CIRCUITED DTC B1462 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1463 SEAT BELT PRE-TENSIONER (RH) SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1470 SEAT BELT PRE-TENSIONER (LH) SQUIB SHORT-CIRCUITED DTC B1471 SEAT BELT PRE-TENSIONER (LH) SQUIB OPEN-CIRCUITED DTC B1472 SEAT BELT PRE-TENSIONER (LH) SQUIB (EARTH SIDE) SHORT-CIRCUITED DTC B1473 SEAT BELT PRE-TENSIONER (LH) SQUIB (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1476 POWER SUPPLY VOLTAGE [IG1 (A) VOLTAGE] DROPS ABNORMALLY DTC B1499 IGNITION OF THE AIR BAG COMPLETED DTC B1509 INCORRECT SRS-ECU DTC B1593 SRS-ECU NOISE FAULT DTC U1073 BUS-OFF CHECK CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES THE M.U.T.-III CANNOT COMMUNICATE WITH THE SRS-ECU. POWER SUPPLY CIRCUIT SYSTEM WHEN THE IGNITION SWITCH IS TURNED TO "ON", THE SRS WARNING LAMP DOES NOT ILLUMINATE. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE POST-COLLISION DIAGNOSIS INDIVIDUAL COMPONENT SERVICE WARNING/CAUTION LABELS<COLT> WARNING/CAUTION LABELS<CZ3/CZT>FRONT IMPACT SENSORSSRS CONTROL UNIT (SRS-ECU)DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING REMOVAL AND INSTALLATION DRIVER''S, FRONT PASSENGER''S AIR BAG MODULE(S) AND CLOCK SPRING INSPECTIONSIDE AND CURTAIN AIR BAG MODULE(S) SIDE AND CURTAIN AIR BAG MODULE(S) REMOVAL AND INSTALLATION SIDE AND CURTAIN AIR BAG MODULE(S) INSPECTIONSIDE IMPACT SENSORSEAT BELTS WITH PRE-TENSIONERPASSENGER''S AIR BAG CUT OFF SWITCH PASSENGER AIR BAG CUT OFF SWITCH REMOVAL AND INSTALLATION PASSENGER AIR BAG CUT OFF SWITCH INSPECTION AIR BAG MODULE AND SEAT BELT PRE-TENSIONER DISPOSAL PROCEDURESBATTERYIGNITION SWITCH SPECIAL TOOL(S)TROUBLESHOOTING ENCRYPTED CODE REGISTRATION CRITERIA TABLE CHECK CHART FOR DIAGNOSIS CODESDIAGNOSTIC TROUBLE CODE PROCEDURES B1721 TRANSPONDER BASESTATION FAILURE B1722 TRANSPONDER ANTENNA FAILURE B1723 TRANSPONDER COMMUNICATION FAILURE B1725 ENGINE-ECU OR ENGINE-TRANSMISSION-ECU MODE ERROR B1731 IMMOBILIZER COMMUNICATION FAILURE CHECK CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES Ignition Key cannot be Registered with M.U.T.-III ENGINE DOES NOT START (CRANKING BUT NO INITIAL COMBUSTION) DATA LIST REFERENCE TABLEON-VEHICLE SERVICEIGNITION SWITCHCOMBINATION METER SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING CHECK CHART FOR DIAGNOSIS CODES<COLT> CHECK CHART FOR DIAGNOSIS CODES<COLT CZ3/CZT>DIAGNOSTIC TROUBLE CODE PROCEDURES<COLT> B1011,B1012 AMBIENT TEMPERATURE SENSOR CIRCUIT LOW OR HIGH B1200 DEFECTIVE ODOMETER B1201 FUEL SYSTEM INFORMATION ERROR U1073 BUS OFF U1100, 1101 TIME-OUT DURING CAN COMMUNICATION WITH ENGINE-A/T-ECU U1102 TIME-OUT DURING CAN COMMUNICATION WITH ABS-ECU U1106 TIME-OUT DURING CAN COMMUNICATION WITH EPS-ECU U1109 TIME-OUT DURING CAN COMMUNICATION WITH ETACS-ECU U1112 TIME-OUT DURING CAN COMMUNICATION WITH SRS-ECU U1120 INFORMATION ON FAILURES IN ENGINE CONTROL SYSTEM VIA CAN COMMUNICATION U1121 INFORMATION ON FAILURES IN CVT CONTROL SYSTEM VIA CAN COMMUNICATION U1122 INFORMATION ON FAILURES IN ABS-ECU VIA CAN COMMUNICATION U1132 SRS-ECU CAN communication failure information U1206 INCONSISTENCY BETWEEN COMMUNICATION WAITING SIGNAL FLAGSDIAGNOSTIC TROUBLE CODE PROCEDURES<COLT CZ3/CZT> B1011,B1012 AMBIENT TEMPERATURE SENSOR CIRCUIT LOW OR HIGH B1200 DEFECTIVE ODOMETER B1201 FUEL SYSTEM INFORMATION ERROR U1073 BUS OFF U1100, 1101 TIME-OUT DURING CAN COMMUNICATION WITH ENGINE-A/T-ECU U1102 TIME-OUT DURING CAN COMMUNICATION WITH ABS-ECU U1106 TIME-OUT DURING CAN COMMUNICATION WITH EPS-ECU U1109 TIME-OUT DURING CAN COMMUNICATION WITH ETACS-ECU U1112 TIME-OUT DURING CAN COMMUNICATION WITH SRS-ECU U1120 INFORMATION ON FAILURES IN ENGINE CONTROL SYSTEM VIA CAN COMMUNICATION U1121 INFORMATION ON FAILURES IN CVT CONTROL SYSTEM VIA CAN COMMUNICATION U1122 INFORMATION ON FAILURES IN ABS-ECU VIA CAN COMMUNICATION U1132 SRS-ECU CAN communication failure information U1206 INCONSISTENCY BETWEEN COMMUNICATION WAITING SIGNAL FLAGS CHECK CHART FOR TROUBLE SYMPTOMS<COLT> CHECK CHART FOR TROUBLE SYMPTOMS<COLT CZ3/CZT>SYMPTOM PROCEDURES<COLT> COMMUNICATION WITH M.U.T.-III IS NOT POSSIBLE POWER SUPPLY CIRCUIT SPEEDOMETER DOES NOT WORK. TACHOMETER DOES NOT WORK. FUEL GAUGE DOES NOT WORK. WARNING BUZZER DOES NOT SOUNDSYMPTOM PROCEDURES<COLT CZ3/CZT> COMMUNICATION WITH M.U.T.-III IS NOT POSSIBLE POWER SUPPLY CIRCUIT SPEEDOMETER DOES NOT WORK. TACHOMETER DOES NOT WORK. FUEL GAUGE DOES NOT WORK. WARNING BUZZER DOES NOT SOUND DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICECOMBINATION METERHEADLAMPFRONT FOG LAMP SERVICE SPECIFICATION(S) SPECIAL TOOL(S) TROUBLESHOOTINGON-VEHICLE SERVICEFOG LAMPFOG LAMP SWITCHREAR FOG LAMPSIDE TURN-SIGNAL LAMPROOM LAMPREAR COMBINATION LAMPBACK-UP LAMP<COLT CZ3/CZT>HIGH-MOUNTED STOP LAMP HIGH-MOUNTED STOP LAMP REMOVAL AND INSTALLATION<COLT> HIGH-MOUNTED STOP LAMP REMOVAL AND INSTALLATION<COLT-CZ3/CZT>LICENCE PLATE LAMPHAZARD WARNING LAMP SWITCHCOLUMN SWITCHHORNRADIO AND CD PLAYER SPECIAL TOOL(S)TROUBLESHOOTINGSYMPTOM PROCEDURES WHEN POWER SWITCH IS TURNED "ON," NO POWER IS AVAILABLE NO SOUND FROM ONE SPEAKER.<COLT> NO SOUND FROM ONE SPEAKER.<COLT CZ3/CZT> NOISE APPEARS AT CERTAIN PLACES WHEN TRAVELING (AM). NOISE APPEARS AT CERTAIN PLACES WHEN TRAVELING (FM). MIXED WITH NOISE, ONLY AT NIGHT (AM) BROADCASTS CAN BE HEARD BUT BOTH AM AND FM ARE NOISY. THERE IS MORE NOISE ON EITHER AM OR FM. THERE IS NOISE WHEN STARTING THE ENGINE. SOME NOISE APPEARS WHEN THERE IS VIBRATION OR SHOCKS DURING TRAVELING NOISE SOMETIMES APPEARS ON FM DURING TRAVELING. EVER-PRESENT NOISE THERE IS NOISE BUT NO RECEPTION FOR BOTH AM AND FM POOR RECEPTION. DISTORTION ON AM OR ON BOTH AM AND FM. DISTORTION ON FM ONLY. USING THE AUTO SELECT FUNCTION, TOO FEW AUTOMATIC STATIONS ARE SELECTED PRESET STATIONS ARE ERASED. CD CANNOT BE INSERTED. NO SOUND (CD ONLY). CD SOUND SKIPS. SOUND QUALITY IS POOR. CD CANNOT BE EJECTED.ON-VEHICLE SERVICERADIO AND CD PLAYERSPEAKERANTENNASTEERING WHEEL AUDIO REMOTE CONTROL SWITCHTROUBLESHOOTINGSYMPTOM PROCEDURES THE SYSTEM DOES NOT ACCEPT REMOTE CONTROLLED RADIO SWITCHES (RH AND LH), BUT ACCEPTS RADIO AND CD PLAYER SWITCHES. THE SYSTEM DOES NOT ACCEPT THE REMOTE CONTROLLED RADIO SWITCH (RH) ONLY. THE SYSTEM DOES NOT ACCEPT THE REMOTE CONTROLLED RADIO SWITCH (LH) ONLY. STEERING WHEEL AUDIO REMOTE CONTROL SWITCH REMOVAL AND INSTALLATION INSPECTIONREAR WINDOW DEFOGGERMULTI-CENTRE DISPLAY SPECIAL TOOL(S)TROUBLESHOOTINGDIAGNOSTIC TROUBLE CODE PROCEDURES U1073 BUS OFF U1100 TIME-OUT DURING CAN COMMUNICATION WITH ENGINE-ECU <M/T> OR ENGINE-A/T-ECU <A/T> DIAGNOSIS CODE NO. U1102 ABS OR ASC-ECU TIME-OUT U1108 TIME-OUT DURING CAN COMMUNICATION WITH COMBINATON METER DIAGNOSIS CODE NO.U1109 ETACS TIME-OUT U1120 INFORMATION ON FAILURES IN ENGINE CONTROL SYSTEM VIA CAN COMMUNICATION DIAGNOSIS CODE NO. U1122 ABS OR ASC-ECU FAILURE INFORMATION U1128 INFORMATION ON FAILURES IN COMBINATION METER VIA CAN COMMUNICATION U1600, U1601 MBUSY OPEN, SHORT U1602, U1603 MDATA OPEN, SHORT U1604, U1605 MSCK OPEN, SHORT CHECK CHART FOR TROUBLE SYMPTOMSTROUBLESHOOTING THE M.U.T.-III CANNOT COMMUNICATE WITH THE MULTI-CENTRE DISPLAY. Check the multi-centre display power supply circuit. THE CENTRE DISPLAY DOES NOT DISPLAY ANY SCREENS. ENVIRONMENTAL INFORMATION AND DRIVE INFORMATION ARE NOT DISPLAYED NORMALLY. THE DISPLAY SHOWS AN ERROR IN THE AUDIO COMMUNICATION SYSTEM. DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALMULTI-CENTRE DISPLAYETACS-ECUAMBIENT TEMPERATURE SENSOR GENERAL INFORMATION SPECIAL TOOLSTROUBLESHOOTING BEFORE COMMENCING TROUBLESHOOTING STANDARD FLOW OF DIAGNOSTIC TROUBLE SHOOTING DIAGNOSTIC FUNCTIONS SERVICE DATA REFERENCE TABLE ACTUATOR TEST TABLE DIAGNOSTIC TROUBLE CODE CHARTDIAGNOSIS TROUBLE CODE PROCEDURES DIAGNOSIS CODE No.B1709 ETACS-ECU (EEPROM) DIAGNOSIS CODE NO.B1728, B1729 MALFUNCTION OF THE POWER SUPPLY TO THE ETACS-ECU DIAGNOSIS CODE NO.B1740, B1741 BLOWN TURN-SIGNAL LAMP BULB<COLT> DIAGNOSIS CODE NO.B1740, B1741 BLOWN TURN-SIGNAL LAMP BULB<COLT CZ3/CZT> DIAGNOSIS CODE NO.B1742 MALFUNCTION OF THE TURN-SIGNAL LAMP SWITCH DIAGNOSIS CODE NO.B1743 BLOWN HAZARD WARNING LAMP FUSE DIAGNOSIS CODE NO.B1744 MALFUNCTION OF THE HAZARD WARNING LAMP SWITCH DIAGNOSIS CODE NO.B1760, B1761 VEHICLE INFORMATION NOT REGISTERED DIAGNOSIS CODE NO.U1073 BUS OFF DIAGNOSIS CODE NO.U1100, U1101 ENGINE-ECU TIME-OUT DIAGNOSIS CODE NO.U1102 ABS-ECU or ACTIVE STABILITY CONTROL SYSTEM-ECU TIME-OUT DIAGNOSIS CODE NO.U1108 COMBINATION METER TIME-OUT DIAGNOSIS CODE NO.U1111 CENTRE DISPLAY TIME-OUT DIAGNOSIS CODE NO.U1112 SRS-ECU TIME-OUT DIAGNOSIS CODE NO.U1121 FAILURE INFORMATION ON ENGINE-ECU DIAGNOSIS CODE NO.U1128 FAILURE INFORMATION ON COMBINATION METER DIAGNOSIS CODE NO.U1500 COLUMN SWITCH TIME-OUT DIAGNOSIS CODE No.U1504 RAIN LIGHT SENSOR TIME-OUT DIAGNOSIS CODE NO.U1507 ETACS-ECU TRANSMISSION ERROR DIAGNOSIS CODE No.U1550 AUTO LIGHT SENSOR FAIL TROUBLE SYMPTOM CHART INPUT SIGNAL CHARTSYMPTOM PROCEDURES CHECK THE CIRCUIT (POWER SUPPLY LINE) FROM BATTERYBUZZER LAMP REMINDER BUZZER FUNCTION DOES NOT WORK NORMALLY. TURN-SIGNAL LAMP OPERATION SOUND FUNCTION DOES NOT WORK NORMALLY. SEAT BELT REMINDER FUNCTION DOES NOT WORK NORMALLY.WINDSHIELD WIPER/WASHER THE WINDSHIELD WIPERS DO NOT WORK AT ALL. THE WINDSHIELD WIPERS DO NOT WORK NORMALLY. THE WINDSHIELD WIPERS DO NOT STOP AT THE SPECIFIED PARK POSITION. THE INTERMITTENT WIPER INTERVAL CANNOT BE ADJUSTED BY OPERATING THE WINDSHIELD INTERMITTENT WIPER VOLUME CONTROL. THE INTERMITTENT WIPER INTERVAL IS NOT CHANGED ACCORDING TO THE VEHICLE SPEED. THE WINDSHIELD WASHER DOES NOT WORK NORMALLY. THE WINDSHIELD WIPERS COMPATIBLE WITH THE RAIN LIGHT SENSOR DO NOT OPERATE NORMALLY.REAR WIPER/WASHER THE REAR WIPER DOES NOT WORK NORMALLY.<COLT> THE REAR WIPER DOES NOT WORK NORMALLY.<COLT CZ3/CZT> THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION.<COLT> THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION.<COLT CZ3/CZT> THE REAR WASHER DOES NOT WORK NORMALLY.HEADLAMP AND TAIL LAMP THE TAIL LAMPS DO NOT ILLUMINATE NORMALLY. THE LOW-BEAM HEADLAMPS DO NOT ILLUMINATE. THE HIGH-BEAM HEADLAMPS DO NOT ILLUMINATE. THE HIGH-BEAM AND LOW-BEAM HEADLAMPS DO NOT ILLUMINATE WHEN THE PASSING SWITCH IS OPERATED. ANY OF TAIL LAMPS DOES NOT ILLUMINATE.<COLT> ANY OF TAIL LAMPS DOES NOT ILLUMINATE.<COLT CZ3/CZT> ANY OF THE HEADLAMPS DOES NOT ILLUMINATE. THE HIGH-BEAM INDICATOR DOES NOT ILLUMINATE OR GO OUT NORMALLY. THE DAYTIME RUNNING LAMP DOES NOT WORK NORMALLY. THE TAIL LAMPS AND THE HEADLAMPS KEEP ILLUMINATING WHEN THE IGNITION SWITCH IS IN THE "ON" POSITION. AUTO LAMP FUNCTION DOES NOT WORK NORMALLY.TURN-SIGNAL LAMP THE TURN-SIGNAL LAMPS DO NOT ILLUMINATE NORMALLY. ANY OF THE TURN-SIGNAL LAMPS DOES NOT ILLUMINATE. THE TURN-SIGNAL LAMP INDICATOR DOES NOT ILLUMINATE OR GO OUT NORMALLY. THE COMFORT FLASHING FUNCTION DOES NOT WORK NORMALLY. THE HAZARD WARNING LAMPS DO NOT ILLUMINATE NORMALLY.FOG LAMP THE FRONT FOG LAMPS DO NOT ILLUMINATE NORMALLY. THE REAR FOG LAMPS DO NOT ILLUMINATE NORMALLY.<COLT> THE REAR FOG LAMPS DO NOT ILLUMINATE NORMALLY.<COLT CZ3/CZT> ANY OF THE FRONT FOG LAMPS DOES NOT ILLUMINATE. THE FRONT FOG LAMP INDICATOR DOES NOT ILLUMINATE. THE REAR FOG LAMP INDICATOR DOES NOT ILLUMINATE. ONLY SPECIFIC FUNCTION(S) WORKS (FAIL-SAFE STATE).INPUT SIGNAL PROCEDURES THE COLUMN SWITCH (LIGHTING AND WIPER SWITCH) SIGNAL IS NOT RECEIVED. THE IGNITION SWITCH (ACC) SIGNAL IS NOT RECEIVED. THE IGNITION SWITCH (IG1) SIGNAL IS NOT RECEIVED. THE HAZARD WARNING LAMP SWITCH SIGNAL IS NOT RECEIVED. THE FRONT FOG LAMP SWITCH SIGNAL IS NOT RECEIVED. THE REAR FOG LAMP SWITCH SIGNAL IS NOT RECEIVED. THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT (LH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT CZ3/CZT (LH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT (RH drive vehicles)> THE DRIVER''S DOOR SWITCH SIGNAL IS NOT RECEIVED.<COLT CZ3/CZT (RH drive vehicles)> CHECK AT ECU TERMINALON-VEHICLE SERVICE GENERAL INFORMATION SPECIAL TOOL(S) TEST EQUIPMENT SERVICE PRECAUTIONS PRECAUTIONS ON HOW TO REPAIR THE CAN BUS LINES EXPLANATION ABOUT THE M.U.T.-III CAN BUS DIAGNOSTICSTROUBLESHOOTING CAN BUS DIAGNOSIS TABLECAN BUS DIAGNOSIS DIAGNOSIS ITEM 1 DIAGNOSIS ITEM 2 DIAGNOSIS ITEM 3 DIAGNOSIS ITEM 4 DIAGNOSIS ITEM 5 DIAGNOSIS ITEM 6 DIAGNOSIS ITEM 7 DIAGNOSIS ITEM 8 DIAGNOSIS ITEM 9 DIAGNOSIS ITEM 10 DIAGNOSIS ITEM 11 DIAGNOSIS ITEM 12 DIAGNOSIS ITEM 13 DIAGNOSIS ITEM 14 DIAGNOSIS ITEM 15 DIAGNOSIS ITEM 16 DIAGNOSIS ITEM 17 DIAGNOSIS ITEM 18 DIAGNOSIS ITEM 19 DIAGNOSIS ITEM 20 DIAGNOSIS ITEM 21 DIAGNOSIS ITEM 22 DIAGNOSIS ITEM 23 DIAGNOSIS ITEM 24 DIAGNOSIS ITEM 25 DIAGNOSIS ITEM 26 DIAGNOSIS ITEM 27 DIAGNOSIS ITEM 28 DIAGNOSIS ITEM 29 DIAGNOSIS ITEM 30 DIAGNOSIS ITEM 31 DIAGNOSIS ITEM 32 DIAGNOSIS ITEM 33 DIAGNOSIS ITEM 34 DIAGNOSIS ITEM 35 DIAGNOSIS ITEM 36 DIAGNOSIS ITEM 37 DIAGNOSIS ITEM 38 DIAGNOSIS ITEM 39 DIAGNOSIS ITEM 40 DIAGNOSIS ITEM 41 DIAGNOSIS ITEM 42 DIAGNOSIS ITEM 43 DIAGNOSIS ITEM 44 DIAGNOSIS ITEM 45 DIAGNOSIS ITEM 46 DIAGNOSIS ITEM 47 DIAGNOSIS ITEM 48 DIAGNOSIS ITEM 49 CAN COMMUNICATION-RELATED DIAGNOSIS CODE TABLE GENERAL INFORMATION SERVICE SPECIFICATION(S) TROUBLESHOOTING CHECK AT ECU TERMINALON-VEHICLE SERVICEHEATER CONTROL ASSEMBLY HEATER CONTROL ASSEMBLY REMOVAL AND INSTALLATION INSPECTION HEATER CONTROL ASSEMBLY DISASSEMBLY AND REASSEMBLYHEATER UNIT AND AIR INTAKE BOX HEATER UNIT AND AIR INTAKE BOX REMOVAL AND INSTALLATION HEATER UNIT DISASSEMBLY AND ASSEMBLY AIR INTAKE BOX DISASSEMBLY AND REASSEMBLYBLOWER MOTOR, RESISTOR AND OUTSIDE/INSIDE AIR SELECTION DAMPER CONTROL MOTOR BLOWER MOTOR AND RESISTOR REMOVAL AND INSTALLATION<L.H. drive vehicles> BLOWER MOTOR AND RESISTOR REMOVAL AND INSTALLATION<R.H. drive vehicles> INSPECTIONPTC HEATER<Diesel powered vehicles>DUCTSVENTILATORS SERVICE PRECAUTIONS GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION CHECK CHART FOR DIAGNOSIS CODESDIAGNOSTIC TROUBLE CODE PROCEDURES B1001 INTERIOR TEMPERATURE SENSOR SYSTEM B1021 AIR THERMO SENSOR SYSTEM B1084 REAR WINDOW DEFOGGER OUTPUT SYSTEM B1086 MOTOR OUTPUT SYSTEM FOR AIR OUTSIDE/INSIDE AIR CIRCULATION SWITCHING DAMPER B1088 MOTOR POTENTIOMETER SYSTEM FOR AIR MIX DAMPER B1090 MOTOR DRIVE SYSTEM FOR AIR MIX DAMPER B1092 POOR RECEPTION OF ETACS SIGNAL U1073 BUS OFF ERROR U1100 ENGINE CAN COMMUNICATION TIME-OUT U1108 COMBINATION METER CAN COMMUNICATION TIME-OUT U1109 ETACS CAN COMMUNICATION TIME-OUT CHECK CHART FOR TROUBLE SYMPTOMS<Petrol powered vehicles except 4G1>SYMPTOM PROCEDURES<Petrol powered vehicles except 4G1> COMMUNICATION WITH THE SCAN TOOL IS NOT POSSIBLE.<Petrol powered vehicles except 4G1> BLOWER FAN AND MOTOR DOES NOT TURN. BLOWER FAN AND MOTOR DOES NOT STOP TURNING. DEFROSTER FUNCTION DOES NOT OPERATE. DEFOGGER TIMER FUNCTION DOES NOT OPERATE AIR CONDITIONING DOES NOT OPERATE.<Petrol powered vehicles except 4G1> A/C OUTLET AIR TEMPERATURE DOES NOT INCREASE THE A/C INDICATOR FLASHES. A/C PRESSURE SENSOR SYSTEM MALFUNCTION OF THE A/C-ECU POWER SUPPLY SYSTEM IN CAR SENSOR FAN MOTOR DOES NOT OPERATE CHECK CHART FOR TROUBLE SYMPTOMS<4G1>SYMPTOM PROCEDURES<4G1> CHECK CHART FOR TROUBLE SYMPTOMS<Diesel powered vehicles>SYMPTOM PROCEDURES<Diesel powered vehicles> COMMUNICATION WITH THE SCAN TOOL IS NOT POSSIBLE.<Diesel powered vehicles> AIR CONDITIONING DOES NOT OPERATE.<Diesel powered vehicles> THE PTC HEATER DOES NOT WORK DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE SIGHT GLASS REFRIGERANT LEVEL TEST COMPRESSOR DRIVE BELT ADJUSTMENT SIMPLE INSPECTION OF THE A/C PRESSURE SENSOR CHARGING <VEHICLES USING R-134a REFRIGERANT> DISCHARGING SYSTEM REFILLING OF OIL IN THE A/C SYSTEM PERFORMANCE TEST <VEHICLES USING R-134a REFRIGERANT> REFRIGERANT LEAK REPAIR PROCEDURE POWER RELAY CHECK IDLE-UP OPERATION CHECK CLEAN AIR FILTER REPLACEMENT PROCEDURESEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY SEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY REMOVAL AND INSTALLATION INSPECTION SEMI AUTOMATIC AIR CONDITIONER CONTROL PANEL ASSEMBLY DISASSEMBLY AND REASSEMBLYHEATER UNIT AND AIR INTAKE BOX HEATER UNIT AND AIR INTAKE BOX REMOVAL AND INSTALLATION HEATER UNIT DISASSEMBLY AND REASSEMBLY AIR INTAKE BOX DISASSEMBLY AND REASSEMBLYAIR MIXING DAMPER CONTROL MOTORSENSORSCOMPRESSOR ASSEMBLY COMPRESSOR ASSEMBLY REMOVAL AND INSTALLATION<Petrol powered vehicles except 4G1> COMPRESSOR ASSEMBLY REMOVAL AND INSTALLATION<4G1> COMPRESSOR ASSEMBLY REMOVAL AND INSTALLATION<Diesel powered vehicles> INSPECTIONCONDENSER ASSEMBLYREFRIGERANT LINEOTHER PARTS RELAY ECU SENSOR SOLENOID AND SOLENOID VALVE INSPECTION CONNECTOR AND SPARE CONNECTOR FUSIBLE LINK AND FUSE EARTH CABLE EARTHOVERALL CONFIGURATION DIAGRAM OVERALL CONFIGURATION DIAGRAM<COLT (LH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT (RH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT CZ3/CZT (LH drive vehicles)> OVERALL CONFIGURATION DIAGRAM<COLT CZ3/CZT (RH drive vehicles)>ENGINE COMPARTMENT ENGINE COMPARTMENT<134 (LH drive vehicles)> ENGINE COMPARTMENT<134 (RH drive vehicles)> ENGINE COMPARTMENT<135 (LH drive vehicles)> ENGINE COMPARTMENT<135 (RH drive vehicles)> ENGINE COMPARTMENT<4G1 (LH drive vehicles)> ENGINE COMPARTMENT<4G1 (RH drive vehicles)> ENGINE COMPARTMENT<639 (LH drive vehicles)> ENGINE COMPARTMENT<639 (RH drive vehicles)>INSTRUMENT PANELFLOOR AND ROOFDOOR DOOR<COLT (LH drive vehicles)> DOOR<COLT (RH drive vehicles)> DOOR<COLT CZ3/CZT (LH drive vehicles)> DOOR<COLT CZ3/CZT (RH drive vehicles)>TAILGATEJ/B J/CCENTRALIZED JUNCTIONPOWER DISTRIBUTION SYSTEM POWER DISTRIBUTION SYSTEM<PETROL-POWERED VEHICLES> POWER DISTRIBUTION SYSTEM<DIESEL-POWERED VEHICLES>STARTING SYSTEMIGNITION SYSTEM GLOW SYSTEM<639>CHARGING SYSTEMENGINE CONTROL SYSTEM ENGINE CONTROL SYSTEM<134> ENGINE CONTROL SYSTEM<135> ENGINE CONTROL SYSTEM<4G1> ENGINE CONTROL SYSTEM<639>COOLING SYSTEMAUTOMATED MANUAL TRANSMISSION SYSTEM AUTOMATED MANUAL TRANSMISSION SYSTEM<PETROL-POWERED VEHICLES> AUTOMATED MANUAL TRANSMISSION SYSTEM<DIESEL-POWERED VEHICLES> HEADLAMPTAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<COLT> TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<COLT CZ3/CZT> FRONT FOG LAMPREAR FOG LAMPROOM LAMP AND LUGGAGE COMPARTMENT LAMP ROOM LAMP AND LUGGAGE COMPARTMENT LAMP<LH DRIVE VEHICLES> ROOM LAMP AND LUGGAGE COMPARTMENT LAMP<RH DRIVE VEHICLES> HEADLAMP LEVELLING SYSTEM FLOOR CONSOLE ILLUMINATION LAMP TURN-SIGNAL LAMP AND HAZARD WARNING LAMP STOP LAMPBACK-UP LAMP BACK-UP LAMP<COLT (M/T)> BACK-UP LAMP<COLT CZ3/CZT (M/T)> BACK-UP LAMP<COLT (AUTOMATED MANUAL TRANSMISSION)> BACK-UP LAMP<COLT CZ3/CZT (AUTOMATED MANUAL TRANSMISSION)> HORNMETER AND GAUGEFUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP FUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP<134, 135> FUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP<4G1> FUEL WARNING LAMP, OIL PRESSURE WARNING LAMP AND BRAKE WARNING LAMP<639>POWER WINDOWSCENTRAL DOOR LOCKING SYSTEM CENTRAL DOOR LOCKING SYSTEM<COLT (LH DRIVE VEHICLES)> CENTRAL DOOR LOCKING SYSTEM<COLT (RHD WITHOUT DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT (RHD WITH DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3/CZT (LH DRIVE VEHICLES)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3/CZT (RHD WITHOUT DEADLOCK SYSTEM)> CENTRAL DOOR LOCKING SYSTEM<COLT CZ3/CZT (RHD WITH DEADLOCK SYSTEM)> HEATERSEMI-AUTOMATIC AIR CONDITIONER SEMI-AUTOMATIC AIR CONDITIONER<134, 135> SEMI-AUTOMATIC AIR CONDITIONER<4G1> SEMI-AUTOMATIC AIR CONDITIONER<639> PTC HEATER<639>WINDSHIELD WIPER AND WASHER WINDSHIELD WIPER AND WASHER<134, 135> WINDSHIELD WIPER AND WASHER<4G1> WINDSHIELD WIPER AND WASHER<639> REAR WIPER AND WASHERREMOTE CONTROLLED MIRRORREAR WINDOW DEFOGGER AND DOOR MIRROR HEATER REAR WINDOW DEFOGGER AND DOOR MIRROR HEATER<LH DRIVE VEHICLES> REAR WINDOW DEFOGGER AND DOOR MIRROR HEATER<RH DRIVE VEHICLES>AUDIO SYSTEM AUDIO SYSTEM<COLT (LH DRIVE VEHICLES)> AUDIO SYSTEM<COLT (RH DRIVE VEHICLES)> AUDIO SYSTEM<COLT CZ3/CZT (LH DRIVE VEHICLES)> AUDIO SYSTEM<COLT CZ3/CZT (RH DRIVE VEHICLES)> ACCESSORY SOCKETMULTI-CENTRE DISPLAYABSABS AND ASCELECTRIC POWER STEERING SYSTEM ELECTRIC POWER STEERING SYSTEM<134, 135> ELECTRIC POWER STEERING SYSTEM<4G1> ELECTRIC POWER STEERING SYSTEM<639> SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SUNROOFIMMOBILIZER SYSTEM IMMOBILIZER SYSTEM<134, 135 (LH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<134, 135 (RH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<4G1 (LH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<4G1 (RH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<639 (LH DRIVE VEHICLES)> IMMOBILIZER SYSTEM<639 (RH DRIVE VEHICLES)> HEATED SEATCANSEAT BELT WARNING BUZZER