HOW TO USE THIS MANUALHOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
CONTENTS OF TROUBLESHOOTING DIAGNOSIS FUNCTION HOW TO USE THE INSPECTION PROCEDURES CONNECTOR MEASUREMENT SERVICE POINTS INSPECTION SERVICE POINTS FOR A BLOWN FUSE HOW TO COPE WITH INTERMITTENT MALFUNCTIONS
HOW TO TREAT PAST TROUBLEVEHICLE IDENTIFICATION MODELS VEHICLE IDENTIFICATION NUMBER (CHASSIS NUMBER) VEHICLE INFORMATION CODE PLATE MANUFACTURER PLATE MOTOR MODEL STAMPING GENERAL DATA AND SPECIFICATIONSPRECAUTIONS BEFORE SERVICE PRECAUTIONS ON DISASSEMBLY PRECAUTIONS ON HOW TO USE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET SERVICING ELECTRICAL SYSTEM<AUXILIARY BATTERY> PRECAUTIONS AT CHARGING PRECAUTIONS WHEN NOT IN USE FOR LONG PERIOD ACTIONS TO BE TAKEN DURING BODY PAINTING PROCEDURE FOR TRACTION BATTERY ACCEPTANCE JUDGMENT ACTIONS TO BE TAKEN AT TRACTION BATTERY WATER INTRUSION SUPPLEMENTAL RESTRAINT SYSTEM (SRS) PROCEDURES FOR WRITING BMU LEARNING VALUE CMU EEPROM FAILURE INFORMATION RESET RESET ESTIMATED INFORMATION AND CONTROL INFORMATION OF TRACTION BATTERY CAPACITY MULTI USE TESTER (M.U.T.-III) SUB ASSEMBLY HOW TO PERFORM CHASSIS NUMBER (Chassis No.) WRITING CODING LIST VEHICLE WASHING PRECAUTIONS FOR INSTALLATION OF ON-VEHICLE RADIO TRANSMISSION EQUIPMENT FORM-IN-PLACE GASKET (FIPG) ACTIONS TO BE TAKEN WHEN DRIVEN ON FLOODED ROAD SUPPORT LOCATIONS FOR LIFTING AND JACKING TOWING AND HOISTING NOTICE BOARDHOW TO READ WIRING DIAGRAMS SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE COOLANT LEVEL CHECK COOLANT CONCENTRATION CHECK COOLANT CHANGE COOLANT LEAK CHECK RADIATOR CAP OPENING PRESSURE CHECK WATER PUMP RELAY CONTINUITY CHECK FAN CONTROL RELAY CONTINUITY CHECK COOLING FAN MOTOR CHECK COOLING FAN RESISTOR CHECK WATER TEMPERATURE SENSOR CHECK AND REPLACEMENTWATER PUMPWATER HOSE AND WATER PIPECOOLING MODULE ASSEMBLYCOOLING FAN RESISTOR22A-TRANSMISSION
LUBRICANTS SPECIAL TOOLSON-VEHICLE SERVICE TRANSMISSION OIL LEVEL CHECK TRANSMISSION OIL CHANGE SELECTOR LEVER OPERATION CHECK KEY INTERLOCK MECHANISM CHECK SHIFT LOCK MECHANISM CHECK SHIFT POSITION SENSOR CONTINUITY CHECKTRANSMISSION CONTROL TRANSMISSION CONTROL REMOVAL AND INSTALLATION KEY INTERLOCK AND SHIFT LOCK MECHANISM REMOVAL AND INSTALLATIONSHIFT POSITION SWITCHTRANSMISSION ASSEMBLY GENERAL INFORMATION GENERAL SPECIFICATION SERVICE SPECIFICATIONS LUBRICANTS SEALANTS SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT TORQUE SPECIFICATION SPECIAL TOOLSTRANSMISSIONINPUT SHAFTOUTPUT GEARDIFFERENTIAL27 -REAR AXLE
SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEREAR AXLE HUB ASSEMBLYDRIVESHAFT ASSEMBLY SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTINGTYRE PRESSURE MONITORING SYSTEM (TPMS) DIAGNOSIS INTRODUCTION DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSTIC FUNCTION TPMS WARNING LAMP CHECK TPMS DIAGNOSIS CODE CHARTTPMS DIAGNOSIS CODE PROCEDURES CODE No.C1564 VEHICLE SPEED DATA INVALID CODE No.C1900 ID CODE FAILURE CODE No.C1901 TPMS ABNORMALITY (VEHICLE SPEED SENSOR INPUT ABNORMALITY) CODE No.C1902 RESET FAIL (WARNING THRESHOLD) CODE No.C1910, C1920, C1930, C1940 TRANSMITTER BATT. VOLTAGE TYRE1, 2, 3, 4/ C1911, C1921, C1931, C1941 TYRE ID RECEPTION FAIL TYRE1, 2, 3, 4 CODE No.C1912, C1922, C1932, C1942 TYRE AIR PRESSURE LOW TYRE1, 2, 3, 4 CODE No.C1913, C1923, C1933, C1943 ACCELERATION SENSOR TYRE1, 2, 3, 4/ C1914, C1924, C1934, C1944 TYRE AIR PRESSURE SENSOR TYRE1, 2, 3, 4 CODE No.C1915, C1925, C1935, C1945 TRANSMITTER OFF MODE TYRE1, 2, 3, 4 TPMS SYMPTOM CHARTTPMS SYMPTOM PROCEDURES TPMS SERVICE DATA LIST CHECK AT TPMS RECEIVERON-VEHICLE SERVICE TYRE INFLATION PRESSURE CHECK TYRE WEAR CHECK WHEEL RUNOUT CHECK WIPING OFF OF THE FLAT TYRE TEMPORARY REPAIR AGENT DISPOSAL OF THE FLAT TYRE TEMPORARY REPAIR AGENT TPMS TRANSMITTER CHECK OR REPLACETPMS SPECIAL FUNCTIONWHEEL AND TYRETYRE PRESSURE MONITORING SYSTEM (TPMS)
TPMS RECEIVERTPMS TRANSMITTER33 -FRONT SUSPENSION
SERVICE SPECIFICATIONS LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE FRONT WHEEL ALIGNMENT CHECK AND ADJUSTMENT LOWER ARM BALL JOINT AXIAL PLAY CHECK BALL JOINT DUST COVER CHECKSTRUT ASSEMBLYLOWER ARMSTABILIZER BARFRONT AXLE No.1 CROSSMEMBER SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICESHOCK ABSORBER AND COIL SPRINGLOWER ARM AND LATERAL ROD ASSEMBLYAXLE ASSEMBLY SERVICE SPECIFICATIONS LUBRICANTS SPECIAL TOOLSON-VEHICLE SERVICE BRAKE PEDAL CHECK AND ADJUSTMENT BRAKE BOOSTER OPERATING CHECK CHECK VALVE OPERATION CHECK BRAKE ELECTRIC VACUUM PUMP RELAY CONTINUITY CHECK BRAKE VACUUM LINE CHECK BRAKE ELECTRIC VACUUM PUMP CHECK BASIC BRAKE SYSTEM BLEEDING BRAKE FLUID LEVEL SWITCH CHECK BRAKE PAD CHECK BRAKE PAD REPLACEMENT BRAKE DISC CHECK BRAKE DRAG FORCE CHECK BRAKE LINING THICKNESS CHECK BRAKE DRUM INSIDE DIAMETER CHECK BRAKE LINING AND BRAKE DRUM CONTACT CHECKBRAKE PEDALMASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<LHD> MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<RHD>BRAKE ELECTRIC VACUUM PUMPFRONT DISC BRAKE ASSEMBLY FRONT DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLYINSPECTIONREAR DRUM BRAKE SERVICE SPECIFICATIONS SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS ABS WARNING LAMP INSPECTION DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. C1200, C1205, C1210, C1215 ABS SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1201, C1206, C1211, C1216 ABS SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1225 ABS SENSOR SYSTEM (OUTPUT SIGNAL MALFUNCTION) CODE NO. C1226, C1231, C1236, C1241, C1246, C1251, C1256, C1261, C1300, C1305, C1310, C1315 CONTROL SOLENOID VALVE SYSTEM CODE NO. C1266, C1273, C1274 MOTOR SYSTEM CODE NO. C1276, C1278, C1279 VALVE RELAY SYSTEM CODE NO. C1340 STOP LAMP SWITCH CODE NO. C1364 BRAKE FLUID PRESSURE SENSOR MALFUNCTION CODE NO. C1366 ABNORMALITY IN G AND YAW RATE SENSOR (LATERAL G AND YAW RATE SENSOR) CODE NO. C1371 YAW RATE SENSOR SIGNAL MALFUNCTION CODE NO. C1385 YAW RATE SENSOR FUNCTION DECREASE, NO. C1621 G AND YAW RATE SENSOR INCORRECT ATTACHMENT CODE NO. C1387 LATERAL G SENSOR FUNCTION DECREASE CODE NO. C1394 STEERING WHEEL SENSOR NEUTRAL POINT NOT LEARNED CODE NO. C1396 TORQUE INPUT REFUSAL CODE NO. C139A MOTOR TORQUE FAIL CODE NO. C1505 STEERING WHEEL SENSOR MALFUNCTION CODE NO. C1555 OUTPUT ERROR IN STEERING WHEEL SENSOR CODE NO. C1607 TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU CODE NO. C1860, C1861 POWER SUPPLY SYSTEM CODE NO. C1864 ABNORMALITY IN G AND YAW RATE SENSOR OPERATION VOLTAGE CODE NO. U1073 BUS OFF CODE NO. U1100 EV-ECU CAN TIME-OUT CODE NO. U1104 STEERING WHEEL SENSOR TIME OUT CODE NO. U1105 G AND YAW LATE SENSOR TIME-OUT ERROR CODE NO. U1108 COMBINATION METER TIME-OUT ERROR CODE NO. U1109: ETACS CAN TIME-OUT CODE NO. U111B MCU CAN TIME-OUT CODE No. U1128 METER (CAN MESSAGE) CODE No. U1190 NO RECEIVE FAULT DETECT SIGNAL CODE No. U1200 SAS PARITY ERROR, U1204 SAS MESSAGE COUNTER ERROR CODE No. U1201 YAW RATE SENSOR PARITY ERROR, U1205 G AND YAW RATE MESSAGE COUNTER ERROR CODE No. U1207 INVALID DATA RECEIVED FROM EV ECU CODE NO. U1406 THROTTLE POSITION SIGNAL ERROR CODE NO. U1426 ENGINE SPEED SIGNAL ERROR SYMPTOM CHARTSYMPTOM PROCEDURES THE M.U.T.-III CANNOT COMMUNICATE WITH TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE ELECTRIC MOTOR SWITCH IS TURNED TO ON POSITION. ABS WARNING LAMP DOES NOT ILLUMINATE WHEN THE ELECTRIC MOTOR SWITCH IS TURNED TO ON POSITION. ABS WARNING LAMP STAYS ON AFTER THE ELECTRIC MOTOR UNIT IS STARTED. ASC INDICATOR LAMP STAYS ON AFTER THE ELECTRIC MOTOR UNIT IS STARTED. ASC OFF INDICATOR LAMP STAYS ON AFTER THE ELECTRIC MOTOR UNIT IS STARTED. WHEN THE TCL SWITCH IS PUSHED, TCL SYSTEM CANNOT BE DISABLED. ABNORMALITY IN BRAKE OPERATION ABNORMAL ACTIVE STABILITY CONTROL SYSTEM OPERATION TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU POWER SUPPLY CIRCUIT SYSTEM ABS/STABILITY CONTROL/TCL OPERATES TOO FREQUENTLY. THE INITIAL CHECK SOUND OF HYDRAULIC UNIT LOUD DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICEASC OFF SWITCHHYDRAULIC UNITWHEEL SPEED SENSORG AND YAW RATE SENSORSTEERING WHEEL SENSOR37 -POWER STEERING
SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION CHECK OF ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES C1511/C1512 TORQUE SENSOR ABNORMALITY C1513 LARGE DIFFERENCE BETWEEN MAIN TORQUE SENSOR AND SUB TORQUE SENSOR C1514 TORQUE SENSOR POWER SUPPLY ABNORMALITY C1521 VEHICLE SPEED SENSOR INPUT MALFUNCTION CODE No. C1522 CRANK ANGLE SENSOR C1531 MOTOR TERMINAL VOLTAGE ABNORMALITY C1532 OVER REAL CURRENT OF MOTOR C1534 UNDER REAL CURRENT OF MOTOR C1541 LOCKING FAIL-SAFE RELAY ON C1542 FAIL-SAFE RELAY STUCK OFF C1607 CONTROL UNIT MALFUNCTION C1860 POWER SUPPLY VOLTAGE ABNORMALITY (HIGH VOLTAGE) C1861 POWER SUPPLY VOLTAGE ABNORMALITY (LOW VOLTAGE) U1073 BUS OFF CODE No. U1100 EV ECU CAN timeout(1) U1102 ABS-ECU TIME-OUT CODE No. U1108 METER CAN TIMEOUT/NOT EQUIPPED CODE No. U1109 ETACS CAN TIMEOUT/NOT EQUIPPED CODE No. U1120 EV ECU (CAN MESSAGE) U1122 ABS-ECU FAIL INFORMATION U1128 COMBINATION METER-RELATED CAN COMMUNICATION FAILURE INFORMATION U1190 NO RECEIVE FAULT DETECT SIGNAL CODE No. U1432 DYNAMIC RANGE ERROR SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <CAN COMMUNICATION SYSTEM CHECK> M.U.T.-III CANNOT COMMUNICATE WITH ELECTRIC POWER STEERING SYSTEM (EPS) <ECU POWER SUPPLY CIRCUIT SYSTEM CHECK> ELECTRIC POWER STEERING SYSTEM (EPS) WARNING LAMP ILLUMINATES BUT DIAGNOSIS CODE IS NOT STORED. DATA LIST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE STEERING WHEEL FREE PLAY CHECK STEERING ANGLE CHECK TIE ROD END BALL JOINT STARTING TORQUE CHECK STATIONARY STEERING EFFORT CHECK STEERING WHEEL RETURN TO CENTRE CHECK BALL JOINT DUST COVER INSPECTION STEERING COLUMN SHAFT ASSEMBLY SHOCK ABSORBING MECHANISM CHECKSTEERING WHEELSTEERING SHAFTPOWER STEERING GEAR BOX AND LINKAGE POWER STEERING GEAR BOX AND LINKAGE REMOVAL AND INSTALLATION INSPECTION POWER STEERING GEAR BOX AND LINKAGE DISASSEMBLY AND REASSEMBLY TIE ROD END BALL JOINT DUST COVER REPLACEMENTELECTRIC POWER STEERING CONTROL UNIT (EPS-ECU)HOODON-VEHICLE SERVICE ADJUSTMENT OF CLEARANCE AROUND HOOD ADJUSTMENT OF ALIGNMENT OF HOOD STEPPED PORTION AND HOOD STRIKER ADJUSTMENT OF HOOD HEIGHTHOODFENDERSPLASH SHIELDCHARGING LIDWINDOW GLASS SEALANT(S) OR ADHESIVE(S) LUBRICANT(S) SPECIAL TOOL(S) GENERAL INFORMATIONWINDSHIELDDELTA WINDOW GLASSTAILGATE WINDOW GLASSDOOR SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHART<CENTRAL DOOR LOCKING SYSTEM>SYMPTOM PROCEDURES<CENTRAL DOOR LOCKING SYSTEM> CENTRAL DOOR LOCKING SYSTEM DOES NOT OPERATE SOME DOORS DO NOT LOCK OR UNLOCK SELECTOR "P" POSITION-LINKED DOOR UNLOCK FUNCTION DOES NOT OPERATE. SYMPTOM CHART<POWER WINDOWS>SYMPTOM PROCEDURES<POWER WINDOWS> POWER WINDOWS DO NOT WORK AT ALL POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER'S WINDOW POWER WINDOW SUB SWITCH CANNOT OPERATE PASSENGER'S OR REAR WINDOWS. POWER WINDOW MAIN SWITCH CANNOT OPERATE EITHER OF PASSENGER'S OR REAR POWER WINDOWS POWER WINDOW TIMER FUNCTION DOES NOT WORK NORMALLYON-VEHICLE SERVICE DOOR FIT ADJUSTMENT DOOR WINDOW GLASS ADJUSTMENT POWER WINDOW CHECK ADJUSTMENT AND REPLACEMENT WHEN POWER WINDOWS FAIL POWER WINDOW TIMER FUNCTION CHECK POWER WINDOW OPERATING CURRENT CHECK POWER WINDOW RELAY CHECK CENTRAL DOOR LOCKING SYSTEM INSPECTION CHECK OF KEY LOCK PREVENTION FUNCTION SHIFT "P" INTERLINK DOOR UNLOCK FUNCTION CHECK DOOR OUTSIDE HANDLE PLAY CHECK DOOR INSIDE HANDLE PLAY ADJUSTMENT CUSTOMISATION FUNCTIONDOOR ASSEMBLYDOOR GLASS AND REGULATORDOOR HANDLE AND LATCHWINDOW GLASS RUNCHANNEL AND DOOR OPENING WEATHERSTRIPTAILGATE SEALANT(S) OR ADHESIVE(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES INPUT SIGNAL CHARTINPUT SIGNAL PROCEDURESON-VEHICLE SERVICETAILGATETAILGATE HANDLE AND LATCHKEYLESS ENTRY SYSTEM SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES KEYLESS ENTRY SYSTEM DOES NOT OPERATE THE DOME LAMP, THE HAZARD WARNING LAMPS AND THE HORN DO NOT OPERATE THROUGH THE ANSWERBACK FUNCTION. AFTER THE DOORS ARE UNLOCKED BY USING THE KEYLESS ENTRY SYSTEM, THE TIMER LOCK FUNCTION DOES NOT WORK. MULTIMODE KEYLESS ENTRY FUNCTION DOES NOT WORK AT ALL.ON-VEHICLE SERVICE KEYLESS ENTRY SYSTEM INSPECTION KEYLESS ENTRY SYSTEM TIMER LOCK FUNCTION INSPECTION MULTIMODE KEYLESS ENTRY FUNCTION CHECK METHOD OF REGISTERING A SECRET CODE CUSTOMISATION FUNCTIONTRANSMITTERLOOSE PANELFRONT BUMPER ASSEMBLY SEALANT(S) OR ADHESIVE(S) FRONT BUMPER ASSEMBLY REMOVAL AND INSTALLATION FRONT BUMPER ASSEMBLY DISASSEMBLY AND REASSEMBLYREAR BUMPER ASSEMBLYMOULDINGSGARNISHESSIDE AIR DAMUNDER COVERTAILGATE SPOILERWINDSHIELD WIPER AND WASHER SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART THE WINDSHIELD WIPERS DO NOT WORK AT ALL THE WINDSHIELD WIPERS DO NOT WORK WHEN THE WIPER SWITCH IS AT INT, WASHER OR MIST POSITION. THE WINDSHIELD WIPERS DO NOT STOP AT THE SPECIFIED PARK POSITION THE WINDSHIELD WIPERS DO NOT WORK NORMALLY THE INTERMITTENT WIPER INTERVAL CANNOT BE ADJUSTED BY OPERATING THE WINDSHIELD INTERMITTENT WIPER VOLUME CONTROL THE INTERMITTENT WIPER INTERVAL IS NOT CHANGED ACCORDING TO THE VEHICLES SPEED THE WINDSHIELD WASHER DOES NOT WORKON-VEHICLE SERVICEWINDSHIELD WIPERWINDSHIELD WASHERREAR WIPER AND WASHER SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART THE REAR WIPER DOES NOT WORK AT ALL THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION WHEN THE SELECTOR LEVER IS MOVED TO R POSITION DURING THE REAR WIPER OPERATION, THE REAR WIPER DOES NOT OPERATE AT THE CONTINUOUS MODE THE REAR WASHER DOES NOT WORKON-VEHICLE SERVICEREAR WIPER AND WASHERMARKOUTSIDE MIRROR SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR DOES NOT WORK AT ALL LEFT OR RIGHT SIDE ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR DOES NOT WORK ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR TIMER FUNCTION DOES NOT WORK VEHICLE SPEED-DEPENDENT UNFOLDING FUNCTION DOES NOT WORK NORMALLY INSPECTION OF IGNITION SWITCH POSITION-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS INSPECTION OF KEYLESS ENTRY SYSTEM-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS ALL HEATED DOOR MIRRORS DO NOT OPERATE RIGHT OR LEFT HEATED DOOR MIRROR DOES NOT OPERATEON-VEHICLE SERVICE INSPECTION OF IGNITION SWITCH POSITION-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS INSPECTION OF OUTSIDE MIRROR TIMER FUNCTION CUSTOMIZATION FUNCTIONOUTSIDE MIRROR SERVICE SPECIFICATIONS SPECIAL TOOLSINSTRUMENT PANEL ASSEMBLY INSTRUMENT PANEL ASSEMBLY REMOVAL AND INSTALLATION INSTRUMENT PANEL ASSEMBLY DISASSEMBLY AND ASSEMBLYFLOOR CONSOLE ASSEMBLYTRIMSINTERIOR TRIMTAILGATE TRIMDOOR TRIMHEADLININGSEAT ASSEMBLYTROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURESON-VEHICLE SERVICEFRONT SEAT ASSEMBLY FRONT SEAT ASSEMBLY REMOVAL AND INSTALLATION FRONT SEAT ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)<VEHICLES WITH HEATED SEAT> FRONT SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLYREAR SEAT ASSEMBLYSEAT BELTFRONT SEAT BELTREAR SEAT BELTTETHER ANCHOR GENERAL DESCRIPTION SERVICE PRECAUTIONS SPECIAL TOOL(S) TEST EQUIPMENTTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION SRS WARNING LAMP CHECK PASSENGER'S AIR BAG OFF INDICATOR LAMP CHECK DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES DTC B1400 DRIVER'S AIR BAG SQUIB SHORT-CIRCUITED DTC B1401 DRIVER'S AIR BAG SQUIB OPEN-CIRCUITED DTC B1402 DRIVER'S AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1403 DRIVER'S AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1404 SYSTEM INSIDE SRS-ECU DTC B1406 G-SENSOR OF FRONT IMPACT SENSOR (RH) FAILURE DTC B1407 FRONT IMPACT SENSOR (RH) VOLTAGE ERROR DTC B1408 FRONT IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1410 FRONT PASSENGER'S AIR BAG SQUIB SHORT-CIRCUITED DTC B1411 FRONT PASSENGER'S AIR BAG SQUIB OPEN-CIRCUITED DTC B1412 FRONT PASSENGER'S SIDE AIR BAG SQUIB DRIVE CIRCUIT (EARTH SIDE) SHORT-CIRCUITED DTC B1413 FRONT PASSENGER'S SIDE AIR BAG SQUIB DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORT-CIRCUITED DTC B1417 FRONT IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1418 FRONT IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1420 SIDE-AIRBAG SQUIB (RH) SHORT-CIRCUITED DTC B1421 SIDE-AIRBAG SQUIB (RH) OPEN-CIRCUITED DTC B1422 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1423 SIDE-AIRBAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1426 G-SENSOR OF SIDE IMPACT SENSOR (RH)FAILURE DTC B1427 SIDE IMPACT SENSOR (RH) VOLTAGE ERROR DTC B1428 SIDE IMPACT SENSOR (RH) COMMUNICATION ERROR DTC B1430 SIDE-AIRBAG SQUIB (LH) SHORT-CIRCUITED DTC B1431 SIDE-AIRBAG SQUIB (LH) OPEN-CIRCUITED DTC B1432 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (GROUND SIDE) SHORTED DTC B1433 SIDE-AIRBAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1437 SIDE IMPACT SENSOR (LH) VOLTAGE ERROR DTC B1438 SIDE IMPACT SENSOR (LH) COMMUNICATION ERROR DTC B1440 CURTAIN AIR BAG SQUIB (RH) SHORT-CIRCUITED DTC B1441 CURTAIN AIR BAG SQUIB (RH) OPEN-CIRCUITED DTC B1442 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1443 CURTAIN AIR BAG SQUIB (RH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1450 CURTAIN AIR BAG SQUIB (LH) SHORT-CIRCUITED DTC B1451 CURTAIN AIR BAG SQUIB (LH) OPEN-CIRCUITED DTC B1452 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (EARTH SIDE) SHORTED DTC B1453 CURTAIN AIR BAG SQUIB (LH) DRIVE CIRCUIT (POWER SUPPLY SIDE) SHORTED DTC B1476 POWER SUPPLY VOLTAGE [IG1 (A) VOLTAGE] DROPS ABNORMALLY DTC B1488 AIR BAG OFF INDICATOR LAMP CIRCUIT MALFUNCTION DTC B1489 AIR BAG OFF INDICATOR LAMP OPEN-CIRCUITED DTC B1489 AIR BAG OFF INDICATOR LAMP OPEN-CIRCUITED DTC B1499 IGNITION OF THE AIR BAG COMPLETED DTC B1509 INCORRECT SRS-ECU DTC B1519 SRS-ECU CONNECTOR LOCK OUT OF ORDER DTC B1547 CUT OFF FOR PASSENGER'S FRONT AIR BAG DTC B1551 SRS WARNING LAMP CIRCUIT OPEN-CIRCUITED DTC B1551 SRS WARNING LAMP CIRCUIT OPEN-CIRCUITED DTC B1574 PASSENGER'S AIR BAG CUT OFF SWITCH CIRCUIT OPEN DTC B1581 PASSENGER'S AIR BAG CUT OFF SWITCH WRONG INSTALLATION DTC B1603 DRIVER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1604 DRIVER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1605 DRIVER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1606 DRIVER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1609 FRONT PASSENGER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1610 FRONT PASSENGER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1611 FRONT PASSENGER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1612 FRONT PASSENGER'S SIDE SEAT BELT PRE-TENSIONER (SQUIB) SYSTEM DTC B1698 SRS-ECU COLLISION DECISION (HIGH VOLTAGE SHUTDOWN) DTC B1699 SRS collective deployment DTC U1100 EV ECU CAN timeout(1) DTC U1102 ASC/TCL/ABS timeout/Not equipped DTC U1108 Meter CAN timeout/Not equipped DTC U1109 ETACS CAN timeout/Not equipped DTC U111B MCU CAN timeout DTC U1190 No receive fault detect signal DTC U1195 Coding not completed DTC U1199 Chassis No. not programmed DTC U119A Chassis No. mismatch SYMPTOM CHARTSYMPTOM PROCEDURES DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE POST-COLLISION DIAGNOSIS INDIVIDUAL COMPONENT SERVICE WARNING/CAUTION LABELSFRONT IMPACT SENSORSSRS CONTROL UNIT (SRS-ECU)DRIVER'S AIR BAG MODULE AND CLOCK SPRING DRIVER'S AIR BAG MODULE AND CLOCK SPRING REMOVAL AND INSTALLATION DRIVER'S AIR BAG MODULE INSPECTIONPASSENGER'S (FRONT) AIR BAG MODULE PASSENGER'S (FRONT) AIR BAG MODULE REMOVAL AND INSTALLATION PASSENGER'S (FRONT) AIR BAG MODULE INSPECTIONSIDE-AIRBAG MODULE(S)CURTAIN AIR BAG MODULE(S)SIDE IMPACT SENSORSEAT BELTS WITH PRE-TENSIONERPASSENGER'S AIR BAG CUT OFF SWITCH PASSENGER AIR BAG CUT OFF SWITCH REMOVAL AND INSTALLATION PASSENGER AIR BAG CUT OFF SWITCH INSPECTIONPASSENGER'S AIR BAG OFF INDICATOR LAMP PASSENGER'S AIR BAG OFF INDICATOR LAMP REMOVAL AND INSTALLATION PASSENGER'S AIR BAG OFF INDICATOR LAMP CHECK AIR BAG MODULE AND SEAT BELT PRE-TENSIONER DISPOSAL PROCEDURES PRE-TENSIONER FITTED SEATBELT DISPOSAL PROCEDUREAUXILIARY BATTERYELECTRIC MOTOR SWITCH SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURESON-VEHICLE SERVICE ELECTRIC MOTOR SWITCH REMOVAL AND INSTALLATIONINSPECTIONIMMOBILIZER SYSTEM SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES B1702 RECEPTION ERROR OF TRANSPONDER DATA B1703 TRANSPONDER DATA INCONSISTENT B1722 TRANSPONDER ANTENNA FAILURE B1731 IMMOBILIZER COMMUNICATION FAILURE B1761 VIN NOT RECORDED B1766 TRANSPONDER REGISTERED FOR OTHER VEHICLE SYMPTOM CHARTSYMPTOM PROCEDURES DATA LIST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE IMMOBILIZER-ECU REMOVAL AND INSTALLATIONCOMBINATION METER GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO.B1200 ODOMETER FAILURE CODE NO.U1073 BUS-OFF CODE NO.U1100 EV ECU CAN TIMEOUT CODE NO.U1102 ASC/TCL/ABS TIMEOUT/NOT EQUIPPED CODE NO.U1106 EPS CAN TIMEOUT/NOT EQUIPPED CODE NO.U1109 COMMUNICATION TIME-OUT BETWEEN ETACS-ECU AND CAN CODE NO.U1121 T/M (CAN MESSAGE) CODE NO.U1122 BRAKE MODULE (CAN MESSAGE) CODE NO.U1190 NO RECEIVE FAULT DETECT SIGNAL CODE NO.U1206 INSTRUCTION TO SLEEP FLAG SYMPTOM CHARTSYMPTOM PROCEDURES POWER SUPPLY CIRCUIT SPEEDOMETER DOES NOT WORK. THE ENERGY USAGE INDICATOR DOES NOT WORK (THE OTHER METERS WORK). DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE SPEEDOMETER CHECK ENERGY USAGE INDICATOR INSPECTION METER BRIGHTNESS SETTING SETTING SERVICE REMINDER FUNCTIONCOMBINATION METER ASSEMBLYHEADLAMP SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES DIAGNOSIS CODE No.B1706 DETECTION OF TURN SIGNAL LAMP (FUSE BLOWOUT) DIAGNOSIS CODE No.B1707 DETECTION OF TURN SIGNAL LAMP (OPEN CIRCUIT) SYMPTOM CHARTSYMPTOM PROCEDURES HEADLAMPS (LOW-BEAM) DO NOT ILLUMINATE. HEADLAMPS (HIGH-BEAM) DO NOT ILLUMINATE. HEADLAMPS DO NOT ILLUMINATE WHEN THE PASSING SWITCH IS TURNED ON. THE RIGHT OR LEFT HEADLAMP DOES NOT ILLUMINATE. HIGH-BEAM INDICATOR LAMP DOES NOT ILLUMINATE NORMALLY. HEADLAMP AUTOMATIC SHUTDOWN FUNCTION DOES NOT WORK NORMALLY. THE POSITION LAMP DOES NOT ILLUMINATE. EITHER OF THE POSITION LAMPS DOES NOT ILLUMINATE. WHEN THE ELECTRIC MOTOR SWITCH IS TURNED TO THE ON POSITION WITH THE LIGHTING SWITCH AT THE OFF OR TAIL POSITION, THE HEADLAMPS WILL ILLUMINATE BRIEFLY. AUTOMATIC LIGHTING FUNCTION DOES NOT WORK NORMALLY The LED headlamp warning lamp illuminates. TURN-SIGNAL LAMPS DO NOT FLASH. THE COMFORT FLASHING FUNCTION DOES NOT WORK NORMALLY. TURN-SIGNAL LAMP INDICATOR DOES NOT ILLUMINATE/GO OUT NORMALLY.ON-VEHICLE SERVICE HEADLAMP AIMING LUMINOUS INTENSITY MEASUREMENT HEADLAMP AUTOMATIC-SHUTDOWN FUNCTION CHECK HEADLAMP AUTO LAMP FUNCTION CHECK ADJUSTMENT FUNCTION HEADLAMP REMOVAL AND INSTALLATION HEADLAMP DISASSEMBLY AND REASSEMBLY HEADLAMP LEVELLING SWITCH REMOVAL AND INSTALLATION LIGHTING CONTROL SENSOR REMOVAL AND INSTALLATIONINSPECTIONHEADLAMP AUTOMATIC LEVELLING SYSTEM SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES Code No. 11 Automatic levelling system initialisation not executed Code No. 12 Rear height sensor improperly assembled CODE NO.21 MALFUNCTION OF THE HEIGHT SENSOR (REAR) CODE NO.23 HEIGHT SENSOR POWER SUPPLY SHORT TO EARTH CODE NO.31 DEFECTIVE LEVELLING UNIT CODE NO.41 ECU INTERNAL ERROR SYMPTOM CHARTSYMPTOM PROCEDURES THE DIAGNOSIS CODE IS NOT SET. NEITHER RIGHT NOR LEFT AUTOMATIC LEVELLING OPERATES. EITHER AUTOMATIC LEVELLING DOES NOT OPERATE. THE HEADLAMP AUTOMATIC LEVELLING WARNING LAMP DOES NOT ILLUMINATE. THE HEADLAMP AUTOMATIC LEVELLING WARNING LAMP DOES NOT GO OUT. CHECK AT HEADLAMP AUTOMATIC LEVELLING-ECU TERMINALON-VEHICLE SERVICEHEADLAMP AUTOMATIC LEVELLING-ECUHEIGHT SENSORINSPECTIONREAR COMBINATION LAMP SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES TAIL LAMPS DO NOT ILLUMINATE. THE RIGHT OR LEFT TAIL LAMP DOES NOT ILLUMINATE. THE BACK-UP LAMPS DO NOT ILLUMINATE NORMALLY. EITHER OF THE BACK-UP LAMPS DOES NOT ILLUMINATE. REAR COMBINATION LAMP REMOVAL AND INSTALLATIONINSPECTIONFOG LAMP SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES FRONT FOG LAMPS DO NOT ILLUMINATE NORMALLY. THE RIGHT OR LEFT FOG LAMP DOES NOT ILLUMINATE. REAR FOG LAMPS DO NOT ILLUMINATE NORMALLY.ON-VEHICLE SERVICE FRONT FOG LAMP REMOVAL AND INSTALLATION REAR FOG LAMP REMOVAL AND INSTALLATIONINSPECTIONSIDE TURN-SIGNAL LAMPDAYTIME RUNNING LAMP SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES DAYTIME RUNNING LAMPS DO NOT ILLUMINATE NORMALLY. THE RIGHT OR LEFT DAYTIME RUNNING LAMP DOES NOT ILLUMINATE.ON-VEHICLE SERVICE DAYTIME RUNNING LAMP REMOVAL AND INSTALLATIONINSPECTIONINTERIOR LAMP SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES THE FRONT AND REAR ROOM LAMP DO NOT ILLUMINATE NORMALLY. ONE OF THE ROOM LAMPS DOES NOT ILLUMINATE. THE INTERIOR LAMP AUTO-CUT FUNCTION DOES NOT OPERATE CORRECTLY.ON-VEHICLE SERVICE ROOM LAMP REMOVAL AND INSTALLATIONHIGH-MOUNTED STOP LAMPLICENCE PLATE LAMP SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES LICENCE PLATE LAMP REMOVAL AND INSTALLATIONREGULAR CHARGE PORT LAMP GENERAL INFORMATIONTROUBLESHOOTINGSYMPTOM PROCEDURES REGULAR CHARGE PORT LAMP REMOVAL AND INSTALLATIONHAZARD WARNING LAMP SWITCH SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES HAZARD WARNING LAMP SWITCH REMOVAL AND INSTALLATION HAZARD WARNING LAMP SWITCH CHECKHORNCOLUMN SWITCH SPECIAL TOOL(S)TROUBLESHOOTINGDIAGNOSIS CODE PROCEDURES COLUMN SWITCH REMOVAL AND INSTALLATIONINSPECTIONACCESSORY SOCKETRADIO AND CD PLAYER SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES WHEN POWER SWITCH IS TURNED "ON," NO POWER IS AVAILABLE NO SOUND. POOR RECEPTION. AUDIO ILLUMINATION DOES NOT WORK NORMALLY. PRESET STATIONS ARE ERASED. RADIO WITH CD PLAYER REMOVAL AND INSTALLATIONSPEAKERANTENNAUSB ADAPTERMiEV REMOTE SYSTEMTROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE No. B1170 EV REMOTE ECU FAIL CODE No. B1176 RESERVE CHARGE SIGNAL OPEN CODE No. B1177 RESERVE CHARGE SIGNAL SHT TO BAT CODE No. B1178 RESERVE CHARGE SIGNAL SHT TO GND CODE No. B1179 STICK ID NOT REGISTERED CODE No. B117A ANTENNA PWR.CIRCUIT OPN/SHT TO BAT CODE No, B117C ANTENNA POWER CIRCUIT SHT TO GND CODE No. B117D ANTENNA COMM.LINE(TX) OPEN CODE No. B117E ANTENNA COMM.LINE(TX) SHT TO BAT CODE No. B117F ANTENNA COMM.LINE(TX) SHT TO GND CODE No. U1100 EV ECU CAN TIMEOUT(1) CODE No. U1108 METER CAN TIMEOUT/NOT EQUIPPED CODE No. U1109 ETACS CAN TIMEOUT/NOT EQUIPPED CODE No. U1190 NO RECEIVE FAULT DETECT SIGNAL SYMPTOM CHARTSYMPTOM PROCEDURES DEFECTIVE MiEV REMOTE SYSTEM (INCLUDING BATTERIES)<MUTE SETTING> DEFECTIVE MiEV REMOTE SYSTEM (INCLUDING BATTERIES)<DEFECTIVE MiEV REMOTE> DEFECTIVE MiEV REMOTE SYSTEM (INCLUDING BATTERIES)<FAULTY INDICATION> EXTERNAL NOISE CONDITIONS FOR TIMER CHARGING NOT SATISFIED CONDITIONS FOR REMOTE CLIMATE CONTROL NOT SATISFIED DEFECTIVE WIRELESS COMMUNICATION SYSTEM DEFECTIVE EV SYSTEM DEFECTIVE ON-BOARD CHARGER SYSTEM MALFUNCTION OF THE A/C SYSTEM DEFECTIVE TIMER CHARGING SIGNAL CIRCUIT SYSTEM DEFECTIVE REAR DEFOGGER SYSTEM POWER SUPPLY CIRCUIT ABNORMALITY DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE SPECIAL FUNCTION CHECK AT ECU TERMINALON-VEHICLE SERVICE EV REMOTE-ECU REMOVAL AND INSTALLATION EV REMOTE ANTENNA MODULE REMOVAL AND INSTALLATIONACOUSTIC VEHICLE ALERTING SYSTEM (AVAS) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES WHEN THE ELECTRIC MOTOR SWITCH IS MOVED TO THE ON POSITION, THE AVAS SWITCH INDICATOR DOES NOT ILLUMINATE (DOES NOT ILLUMINATE AS INITIAL CHECK). THE TONE ALARM DOES NOT SOUND. THE AVAS SWITCH INDICATOR FLASHES. THE TONE ALARM SOUNDS WHEN THE SELECTOR LEVER IS MOVED TO P POSITION WITH THE VEHICLE STATIONARY. THE TONE ALARM SOUNDS WHEN THE BRAKE PEDAL IS DEPRESSED WITH THE VEHICLE STATIONARY (WITH THE SELECTOR LEVER AT ANY POSITION OTHER THAN P). THE TONE ALARM DOES NOT SOUND WHEN THE BRAKE PEDAL IS RELEASED WITH THE VEHICLE STATIONARY (WITH THE SELECTOR LEVER AT ANY POSITION OTHER THAN P). WHEN THE AVAS IS PRESSED WITH THE TONE ALARM SOUNDING, THE TONE ALARM WILL CONTINUE SOUNDING. THE TONE ALARM IS SOUNDING ALTHOUGH THE AVAS SWITCH INDICATOR IS ILLUMINATING. THE TONE ALARM SOUND IS TOO SMALL OR DISTORTED. WHEN THE VEHICLE SPEED REACHES 30 km/h (COMBINATION METER INDICATION), THE TONE ALARM DOES NOT CEASE SOUNDING. CHECK AT ECU TERMINALON-VEHICLE SERVICE ACOUSTIC VEHICLE ALERTING-ECU REMOVAL AND INSTALLATION ACOUSTIC VEHICLE ALERTING SPEAKER REMOVAL AND INSTALLATION AVAS SWITCH REMOVAL AND INSTALLATIONINSPECTIONETACS SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES DIAGNOSIS CODE No.B1709 ETACS-ECU INTERNAL ERROR DIAGNOSIS CODE No.B1760 VARIANT CODING UNMATCHED CODE No. B1762 IGNITION OFF CURRENT DRAW (IOD) FUSE DISCONNECTED CODE No. U1073 BUS OFF DIAGNOSIS CODE NO.U1100, U1101 ENGINE-ECU TIME-OUT DIAGNOSIS CODE No.U1102 ABS-ECU TIME-OUT DIAGNOSIS CODE NO.U1108 METER CAN TIMEOUT/NOT EQUIPPED DIAGNOSIS CODE No.U1150 VEHICLE SPEED FAILURE INFORMATION DATA LIST REFERENCE TABLE SYMPTOM CHARTSYMPTOM PROCEDURES CHECK THE CIRCUIT (POWER SUPPLY LINE) FROM BATTERY THE SELECTOR LEVER REMINDER DOES NOT WORK NORMALLY. THE ELECTRIC MOTOR REMINDER DOES NOT WORK NORMALLY. SEAT BELT REMINDER DOES NOT WORK. DOOR AJAR TONE ALARM FUNCTION DOES NOT WORK NORMALLY LIGHT REMINDER TONE ALARM FUNCTION DOES NOT WORK NORMALLY TURN-SIGNAL LAMP OPERATION SOUND FUNCTION DOES NOT WORK NORMALLY. INPUT SIGNAL CHARTINPUT SIGNAL PROCEDURES THE IGNITION SWITCH (ACC) SIGNAL IS NOT SENT TO THE ETACS-ECU. THE IGNITION SWITCH (IG1) SIGNAL IS NOT SENT TO THE ETACS-ECU. THE KEY REMINDER SWITCH SIGNAL IS NOT SENT TO THE ETACS-ECU. THE DRIVER'S DOOR LOCK ACTUATOR SWITCH SIGNAL IS NOT SENT TO THE ETACS-ECU. THE FRONT DOOR SWITCH (RH) SIGNAL IS NOT SENT TO THE ETACS-ECU. THE FRONT DOOR SWITCH (LH) SIGNAL IS NOT SENT TO THE ETACS-ECU. THE DOOR SWITCHES SIGNALS IS NOT SENT TO THE ETACS-ECU. THE HAZARD WARNING LAMP SWITCH SIGNAL IS NOT SENT TO THE ETACS-ECU. THE COLUMN SWITCH SIGNAL IS NOT SENT TO THE ETACS-ECU. THE SEAT BELT SWITCH SIGNAL IS NOT SENT TO THE ETACS-ECU. CHECK AT ECU TERMINALON-VEHICLE SERVICE ETACS-ECU REMOVAL AND INSTALLATIONDEFOGGER SPECIAL TOOL(S)TROUBLESHOOTINGSYMPTOM PROCEDURESON-VEHICLE SERVICE DEFOGGER SWITCH REMOVAL AND INSTALLATION54C-CONTROLLER AREA NETWORK (CAN)
SPECIAL TOOL(S) TEST EQUIPMENT SERVICE PRECAUTIONS PRECAUTIONS ON HOW TO REPAIR THE CAN BUS LINES EXPLANATION ABOUT THE M.U.T.-III CAN BUS DIAGNOSTICSTROUBLESHOOTING CAN BUS DIAGNOSIS CHART CAN-RELATED CONNECTOR POSITIONCAN BUS DIAGNOSIS DIAGNOSIS ITEM 1 DIAGNOSIS ITEM 2 DIAGNOSIS ITEM 3 DIAGNOSIS ITEM 4 DIAGNOSIS ITEM 5 DIAGNOSIS ITEM 6 DIAGNOSIS ITEM 7 DIAGNOSIS ITEM 8 DIAGNOSIS ITEM 9 DIAGNOSIS ITEM 10 DIAGNOSIS ITEM 11 DIAGNOSIS ITEM 12 DIAGNOSIS ITEM 13 DIAGNOSIS ITEM 14 DIAGNOSIS ITEM 15 DIAGNOSIS ITEM 16 DIAGNOSIS ITEM 17 DIAGNOSIS ITEM 18 CAN COMMUNICATION-RELATED DIAGNOSIS CODE TABLE GENERAL INFORMATION PRECAUTIONS ON HOW TO USE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET SPECIAL TOOL(S) DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION WARNING LAMP AND INDICATOR CHECK DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE No. B1178 RESERVE CHARGE SIGNAL SHT TO GND CODE No. C2005 POWER SUPPLY LOW VOLTAGE 1 (VP), C2006 POWER SUPPLY LOW VOLTAGE 2 (VP) CODE No. C2007 POWER SUPPLY HIGH VOLTAGE (VP) CODE No. C200A FAIL SAFE RELAY COIL (VP) CODE No. C200E FAIL SAFE RELAY STUCK ON (VP), C200F FAIL SAFE RELAY STUCK OFF (VP) CODE No. C2010 CONTROL RELAY 1 COIL (VP), C2018 CONTROL RELAY 1 STUCK OFF (VP) CODE No. C2011 CONTROL RELAY 2 COIL (VP), C2019 CONTROL RELAY 2 STUCK OFF (VP) CODE No. C2016 CONTROL RELAY 1,2 STUCK ON (VP) CODE No. C201A PUMP MOTOR STUCK (VP) CODE No. C2020 VACUUM SENSOR POWER VOLTAGE (VP) CODE No. C2021 VACUUM SENSOR FAIL OUTPUT VOLTAGE (VP) CODE No. C2022 VACUUM SENSOR VALUE STUCK (VP) CODE No. C202A PUMP MOTOR DRIVE LONG TIME (VP) CODE No. C202B VACUUM PRESSURE ABNORMAL LOSS (VP) CODE No. C202C PRESSURE LONG TIME LOW (VP) CODE No. C202E PUMP OPERATION WATCH (VP) CODE No. P00B3 WATER TEMPERATURE SENSOR SHORT, P00B4 WATER TEMPERATURE SENSOR OPEN CODE No. P0513 INCORRECT IMMOBILIZER KEY CODE No. P0560 12V CONTROL VOLTAGE FAIL (MCU) CODE No. P0562 BATTERY VOLTAGE TOO LOW CODE No. P0604 RAM ERROR CODE No. P0605 ROM ERROR CODE No. P0606 ECU FAIL (MICROCOMPUTER) CODE No. P060B ECU (AD CONVERTER FAIL) CODE No. P060C ECU (PROCESSOR FAIL) CODE No. P062F ECU (EEPROM FAIL) CODE No. P0630 CHASSIS NO. NOT PROGRAMMED CODE No. P0646 A/C POWER SUPPLY RELAY LOW, P0647 A/C POWER SUPPLY RELAY HIGH CODE No. P0691 RADIATOR FAN 1 RELAY CIRCUIT LOW, P0692 RADIATOR FAN 1 RELAY CIRCUIT HIGH CODE No. P0693 RADIATOR FAN 2 RELAY CIRCUIT LOW, P0694 RADIATOR FAN 2 RELAY CIRCUIT HIGH CODE No. P0705 INHIBITOR SWITCH CODE No. P0A01 RADIATOR FAN 1,2 MALFUNCTION CODE No. P0A05 WATER PUMP (DRIVE SIGNAL LINE) CODE No. P0A09 DCDC CONVERTER FAIL (1) CODE No. P0A0A INTER LOCK SW CODE No. P0A10 DCDC CONVERTER FAIL (2) CODE No. P0A2A MOTOR COIL TEMPERATURE SENSOR (MCU) CODE No. P0A3D IGBT2 TEMPERATURE HIGH (MCU) CODE No. P0A51 CURRENT SENSOR (MCU) CODE No. P0A78 IGBT FAIL (MCU) CODE No. P0AA1 MAIN CONTACTOR P WELD CODE No. P0AA4 MAIN CONTACTOR N WELD CODE No. P0ABA MOTOR DRIVE VOLTAGE SENSOR (MCU) CODE No. P0ABF BATTERY CURRENT SENSOR (BMU) CODE No. P0ADB MAIN CONTACTOR P CIRCUIT LOW, P0ADF MAIN CONTACTOR N CIRCUIT LOW CODE No. P0AE2 PRE-CHARGE CONTACTOR WELD CODE No. P0AE6 PRE-CHARGE CONTACTOR CIRCUIT LOW, P0AE7 PRE-CHARGE CONTACTOR CIRCUIT HIGH CODE No. P0AED IGBT TEMPERATURE SENSOR (MCU) CODE No. P0C73 ABNORMAL COOLING SYSTEM CODE No. P0C74 ABNORMAL COOLING SYSTEM Code No. P1019 Quick CHG.contactor P drive RLY1 Code No. P101A Quick CHG.contactor P drive RLY2 Code No. P101B Quick CHG.contactor P weld Code No. P101C Quick CHG.contactor N weld Code No. P102E Quick CHG.contactor N drive RLY1 Code No. P102F Quick CHG.contactor N drive RLY2 CODE No. P10C1 ON BOARD CHARGE START SIGNAL LO CODE No. P1111 STOP LAMP RELAY INTERNAL FAIL CODE No. P1231 ASC DATA PLAUSIBILITY CODE No. P1602 SYSTEM LSI COMMUNICATION CODE No. P191A BMU TIME COUNTER CODE No. P191B BMU TEMPERATURE SENSOR CODE No. P1A00 APS (MAIN) POWER SUPPLY CIRCUIT CODE No. P1A01 APS (SUB) POWER SUPPLY CIRCUIT CODE No. P1A02 SHIFT POSITION SW: P CODE No. P1A08 INHIBITOR SW: P CODE No. P1A0E BACKLAMP RELAY CIRCUIT LOW, P1A0F BACKLAMP RELAY CIRCUIT HIGH CODE No. P1A10 OBC POWER SUPPLY CIRCUIT LOW, P1A11 OBC POWER SUPPLY CIRCUIT HIGH CODE No. P1A12 OBC ABNORMAL STOP CODE No. P1A15 HIGH VOLTAGE CIRCUIT (1) CODE No. P1A16 HIGH VOLTAGE CIRCUIT (2) CODE No. P1A17 HIGH VOLTAGE CIRCUIT (3) CODE No. P1A18 MCU SHUT DOWN CIRCUIT CODE No. P1A19 MCU SHUT DOWN CIRCUIT (INTERNAL) CODE No. P1A1A MCU PROCESSOR CODE No. P1A1B MOTOR DRIVE VOLTAGE LOW (MCU) CODE No. P1A1C MOTOR DRIVE VOLTAGE HIGH (MCU) CODE No. P1A1F MOTOR COIL TEMPERATURE HIGH (MCU) CODE No. P1A21 MOTOR RESOLVER VALUE (MCU) CODE No. P1A22 MOTOR DRIVE VOLTAGE ULTRA HI (MCU) CODE No. P1A28 EV ECU FAIL (MCU) CODE No. P1A29 MOTOR OVER CURRENT 1 (MCU) CODE No. P1A2B THREE PHASE LINE (MCU) CODE No. P1A2D BATTERY COOLING FAN (BMU) CODE No. P1A2F CELL MALFUNCTION (BMU) CODE No. P1A30 CELL VOLTAGE LOW (BMU) CODE No. P1A31 CELL VOLTAGE HIGH (BMU) CODE No. P1A32 BATTERY TEMPERATURE (BMU) CODE No. P1A33 CELL VOLTAGE SENSOR (BMU) CODE No. P1A34 BATTERY TEMPERATURE SENSOR (BMU) CODE No. P1A35 BALANCER ERROR (BMU) CODE No. P1A38 CELL NUMBER ERROR (BMU) CODE No. P1A39 CHARGE STATE SIGNAL ERROR (BMU) CODE No. P1A3D A/D REFERENCE VOLTAGE (MCU) CODE No. P1A3E CPU ATMOSPHERE TEMPERATURE HIGH (MCU) CODE No. P1A3F CPU TEMPERATURE SENSOR1 (MCU), P1B43 CPU TEMPERATURE SENSOR2 (MCU) CODE No. P1A44 LEAK DETECTION (BMU) CODE No. P1A45 LEAK SENSOR DETECTION CIRCUIT (BMU) CODE No. P1AC5 MCU MESSAGE LOST (BMU) CODE No. P1AE5 RAM ARITHMETIC FAIL CODE No. P1AE6 EEPROM FAIL (BMU) CODE No. P1AE7 ASC SYSTEM FAIL CODE No. P1AE8 STOP LAMP RELAY CIRCUIT LOW CODE No. P1AE9 STOP LAMP RELAY CIRCUIT HIGH CODE No. P1AEA OBC COMMUNICATION FAIL/NOT EQUIPPED CODE No. P1AF1 MCU READY SIGNAL TIMEOUT CODE No. P1AF2 MCU DISCHARGE DIRECTION F/B CODE No. P1AF3 BMU READY TIMEOUT CODE No. P1AF4 CONTROL POWER SUPPLY VOLTAGE (BMU) CODE No. P1AF5 CMU ID AUTO NUMBERING ERROR (BMU) CODE No. P1AF8 OBC CHARGING STOP PROCESS TIMEOUT CODE No. P1AF9 QUICK CHARGER INITIAL CHECK TIMEOUT CODE No. P1AFA QUICK CHARGER READY TIMEOUT, P1AFE QUICK CHARGER MALFUNCTION, P1AFF QUICK CHARGER CONNECTOR LOCK, P1B00 QUICK CHARGER BATTERY ERROR CODE No. P1AFB QUICK CHARGING TIME OVER CODE No. P1AFC QUICK CHARGING CURRENT CODE No. P1AFD QUICK CHARGING VOLTAGE CODE No. P1AFE QUICK CHARGER ERROR CODE No. P1B01 QUICK CHARGER VEHICLE ERROR CODE No. P1B02 QUICK CHARGE CURRENT STOP TIMEOUT, P1B03 QUICK CHARGE STOP PROCESS TIMEOUT CODE No. P1B04 CHARGING CELL MAX VOLTAGE HIGH, P1B05 CHARGING CELL MIN VOLTAGE LOW, P1B07 CHARGING TOTAL BATTERY VOLTAGE CODE No. P1B06 CHARGING CELL MAX TEMPERATURE HIGH CODE No. P1B08 CHARGING CONDENSER VOLTAGE CODE No. P1B09 MCU CAN TIMEOUT/ NOT EQUIPPED CODE No. P1B0B ABS VEHICLE SPEED DATA, P1B22 FL WHEEL SPEED DATA, P1B23 FR WHEEL SPEED DATA, P1B24 RL WHEEL SPEED DATA, P1B25 RR WHEEL SPEED DATA CODE No. P1B0C ON BOARD CHARGING OVER CURRENT, P1B21 OBC OUTPUT CURRENT CODE No. P1B0D QUICK CHARGING OVER CURRENT CODE No. P1B19 BRAKE PEDAL STROKE SENSOR HIGH, P1B1A BRAKE PEDAL STROKE SENSOR LOW CODE No. P1B1B BRAKE PEDAL STROKE SENSOR POWER CIRCUIT CODE No. P1B1C ETACS MESSAGE LOST (MCU) CODE No. P1B1D METER MESSAGE LOST (MCU) CODE No. P1B1E ETACS MESSAGE LOST (BMU) CODE No. P1B1F METER MESSAGE LOST (BMU) CODE No. P1B26 FRONT/REAR TIRE DIAMETER DIFFERENCE (1), P1B27 FRONT/REAR TIRE DIAMETER DIFFERENCE (2) CODE No. P1B28 CRASH DETECTION CODE No. P1B29 ON BOARD CHARGE CONNECTOR HIGH CODE No. P1B2A ON BOARD CHARGE CONNECTOR LOW CODE No. P1B2B WATER PUMP POWER SUPPLY RELAY OPEN/SHORT CODE No. P1B2D CHASSIS NO. MISMATCH CODE No. P1B2E KEY CODE NOT PROGRAMMED CODE No. P1B2F BMU BATTERY PACK TYPE INAPPROPRIATE CODE No. P1B30 MISMATCH IN THE NUMBER OF CELLS EV-ECU AND BMU DETECT CODE No. P1B31 BRAKE FLUID PRESSURE SENSOR CODE No. P1B32 CHASSIS NO. VERIFICATION TIMEOUT CODE No. P1B33 BATTERY LOW TEMPERATURE (BMU) CODE No. P1B34 CMU SENSOR FAIL CODE No. P1B35 SAS DATA FAIL CODE No. P1B36 YAW RATE/G SENSOR DATA FAIL CODE No. P1B37 BRAKE PEDAL STROKE SENSOR FIXED CODE No. P1B40 CAPACITOR TEMPERATURE HIGH FAIL, P1B41 CAPACITOR TEMPERATURE SENSOR CIRCUIT LOW, P1B42 CAPACITOR TEMPERATURE SENSOR CIRCUIT HIGH CODE No. P1B72 QUICK CHARGER CHARGING CURRENT 1 CODE No. P1B73 QUICK CHARGER CHARGING CURRENT 2 CODE No. P1B74 QUICK CHARGER DIS-CHARGING CURRENT 1 CODE No. P1B75 QUICK CHARGER DIS-CHARGING CURRENT 2 CODE No. P1B76 QUICK CHARGER DIS-CHARGING CURRENT 3 CODE No. P1B77 QUICK CHARGER DIS-CHARGING CURRENT 4 CODE No. P1B78 QUICK CHARGER RECEIVED CURRENT CODE No. P2122 APS (MAIN) LOW, P2123 APS (MAIN) HIGH CODE No. P2127 APS (SUB) LOW, P2128 APS (SUB) HIGH CODE No. P2138 APS (MAIN/SUB) CORRELATION CODE No. P2805 SHIFT/INHIBITOR POSITION DIFFERENCE CODE No. U1073 BUS-OFF CODE No. U1081 V-CAN BUS-OFF (BMU) CODE No. U1090 BATTERY-CAN ERROR (BMU) CODE No. U1102 ASC/TCL/ABS TIMEOUT/ NOT EQUIPPED CODE No. U1104 SAS CAN TIMEOUT/NOT EQUIPPED CODE No. U1105 YR/G CAN TIMEOUT/NOT EQUIPPED CODE No. U1106 EPS CAN TIMEOUT CODE No. U1108 METER CAN TIMEOUT/ NOT EQUIPPED CODE No. U1109 ETACS CAN TIMEOUT/ NOT EQUIPPED CODE No. U1110 COMP-HTR CAN TIMEOUT CODE No. U1113 EV REMOTE CAN TIMEOUT/ NOT EQUIPPED CODE No. U1117 IMMOB. CAN TIMEOUT/NOT EQUIPPED CODE No. U111B MCU CAN TIMEOUT CODE No. U111C BMU CAN TIMEOUT CODE No. U111D OBC CAN TIMEOUT CODE No. U1160 EV ECU MESSAGE LOST (MCU) CODE No. U1161 EV ECU MESSAGE LOST (BMU) CODE No. U116A CHG-CAN BUS-OFF, U116B QUICK CHARGER CHG-CAN TIMEOUT CODE No. U1190 NO RECEIVE FAULT DETECT SIGNAL CODE No. U1801 AIRBAG COMMUNICATION LINE SHORT, U1802 AIRBAG COMMUNICATION LINE OPEN, U1803 AIRBAG SIGNAL FRAME ERROR, U1804 AIRBAG SIGNAL PARITY ERROR, U1805 AIRBAG SIGNAL RECEIVE CYCLE, U1806 AIRBAG SIGNAL DATA ERROR CODE No. U1900 LOSS OF MCU MESSAGE (K-LINE), U1910 RECEIVED ERROR FROM MCU (K-LINE) CODE No. U1901 LOSS OF BMU MESSAGE (K-LINE), U1911 RECEIVED ERROR FROM BMU (K-LINE) CODE No. U1920 K-LINE ERROR (MCU) CODE No. U1921 K-LINE ERROR (BMU) SYMPTOM CHARTSYMPTOM PROCEDURES EV-ECU POWER SUPPLY SYSTEM THE COMBINATION METER DOES NOT ILLUMINATE EVEN IF THE ELECTRIC MOTOR SWITCH IS TURNED ON. THE READY INDICATOR DOES NOT ILLUMINATE EVEN IF THE ELECTRIC MOTOR SWITCH IS TURNED TO THE START POSITION. THE CRUISING RANGE SHORTENED. BAD MILEAGE THE TRACTION BATTERY ENERGY LEVEL GAUGE DOES NOT DISPLAY "FULLY CHARGED" Normal charging connector connection signal fails DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT EV-ECU TERMINALON-VEHICLE SERVICESTOP LAMP RELAYEV-ECU PRECAUTIONS ON HOW TO HANDLE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET LUBRICANTS SEALANTS AND ADHESIVES SPECIAL TOOLS DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE No. P0562 BATTERY VOLTAGE TOO LOW CODE No. P0563 BATTERY VOLTAGE TOO HIGH CODE No. P0604 RAM ERROR CODE No. P0605 ROM ERROR CODE No. P062F ECU (EEPROM FAIL) CODE No. P0630 CHASSIS NO. NOT PROGRAMMED CODE No. P0A0D MOTOR DRIVE VOLTAGE HIGH (HW DETECT) CODE No. P0A3C IGBT TEMPERATURE HIGH (MCU) CODE No. P0A43 MOTOR RESOLVER OPEN/SHORT CODE No. P0A51 CURRENT SENSOR (MCU) CODE No. P0A78 IGBT FAIL (MCU) CODE No. P0A90 MOTOR OVER CURRENT 2 (MCU) CODE No. P0ABA MOTOR DRIVE VOLTAGE SENSOR (MCU) CODE No. P0AEF IGBT TEMPERATURE SENSOR CIRCUIT LOW, P0AF0 IGBT TEMPERATURE SENSOR CIRCUIT HIGH CODE No. P0C11 MOTOR COIL U PHASE TEMPERATURE (HIGH), P0C13 MOTOR COIL W PHASE TEMPERATURE (HIGH) CODE No. P1A1B MOTOR DRIVE VOLTAGE LOW (MCU) CODE No. P1A1C MOTOR DRIVE VOLTAGE HIGH (MCU) CODE No. P1A23 EV ECU MODE UNKNOWN (MCU) CODE No. P1A24 READY SIGNAL TIMEOUT (MCU) CODE No. P1A25 DISCHARGE ON TIMEOUT (MCU) CODE No. P1A26 DISCHARGE OFF TIMEOUT (MCU) CODE No. P1A27 EV TORQUE REQUEST ERROR (MCU) CODE No. P1A29 MOTOR OVER CURRENT 1 (MCU) CODE No. P1A2A IGBT OVER CURRENT (MCU) CODE No. P1A2B THREE PHASE LINE (MCU) CODE No. P1A3D A/D REFERENCE VOLTAGE (MCU) CODE No. P1A3E CPU ATMOSPHERE TEMPERATURE HIGH (MCU) CODE No. P1A3F CPU TEMPERATURE SENSOR (MCU) CODE No. P1B0E/12 MOTOR COIL TEMPERATURE U/W PHASE HIGH, P1B0F/13 MOTOR COIL TEMPERATURE U/W PHASE LOW CODE No. P1B14 EV-ECU FAIL 1 (TEMPERATURE) CODE No. P1B15 EV-ECU FAIL 2 (VOLTAGE) CODE No. P1B16 EV-ECU FAIL 3 (TORQUE REQUEST) CODE No. P1B17 EV-ECU FAIL 4 (IGBT HEAT) CODE No. P1B18 EV-ECU LOST CODE No. P1B40 CAPACITOR TEMPERATURE HIGH FAIL CODE No. P1B41 CAPACITOR TEMPERATURE SENSOR CIRCUIT LOW CODE No. P1B42 CAPACITOR TEMPERATURE SENSOR CIRCUIT HIGH CODE No. P1B43 CPU TEMPERATURE SENSOR 2 (EMCU) CODE No. U1100 EV ECU CAN TIMEOUT (1) CODE No. U1108 METER CAN TIMEOUT/NOT EQUIPPED CODE No. U1109 ETACS CAN TIMEOUT/NOT EQUIPPED CODE No. U1910 RECEIVED ERROR FROM MCU (K-LINE) CODE No. U1920 K-LINE ERROR (MCU) SYMPTOM CHARTSYMPTOM PROCEDURES DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT MCU TERMINALON-VEHICLE SERVICEINVERTERMOTOR (ELECTRIC MOTOR UNIT) PRECAUTIONS ON HOW TO USE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET SERVICE SPECIFICATIONS LUBRICANTS SPECIAL TOOLS RECOMMENDED TOOLS DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION INSPECTION CHART FOR DIAGNOSIS CODE SERVICE DATA ITEM LIST CORRESPONDING TO DIAGNOSIS CODE OF EACH MODULEDIAGNOSIS CODE PROCEDURES CODE NO. P1A40: MAIN BATTERY CURRENT SENSOR (HIGH) ABNORMAL CODE NO. P1A41: MAIN BATTERY CURRENT SENSOR (LOW) ABNORMAL CODE NO. P1A42: POWER SUPPLY CIRCUIT OF MAIN BATTERY CURRENT SENSOR ABNORMAL CODE NO. P1A43: DETECTION CIRCUIT OF MAIN BATTERY CURRENT SENSOR ABNORMAL CODE NO. P1A44: DETECTING GROUND FAULT CODE NO. P1A46: DETECTION CIRCUIT OF MAIN BATTERY GROUND FAULT DETECTOR ABNORMAL CODE NO. P1A48: OUTPUT CIRCUIT OF TRACTION BATTERY COOLING FAN ABNORMAL CODE NO. P1A4B: VOLTAGE OF EACH BATTERY CELL ABNORMAL CODE NO. P1A4C: BMU CONTROL POWER SUPPLY VOLTAGE ABNORMAL CODE NO. P1A4D: EV-ECU CONTROL POWER SUPPLY VOLTAGE ABNORMAL CODE NO. P1A4F: ROM ABNORMAL (BMU) CODE NO. P1A50: RAM ABNORMAL (BMU) CODE NO. P1A51: EEPROM ABNORMAL (BMU) CODE No. P1AXX: CMUXX BATTERY CELL LOW VOLTAGE ABNORMAL CODE NO. P1AXX: CMU01 BATTERY CELL HIGH VOLTAGE ABNORMAL CODE NO. P1AXX: CMU01 MODULE TEMPERATURE ABNORMAL (HIGH INPUT) CODE NO. P1AXX: CMU01 BATTERY CELL VOLTAGE SENSOR ABNORMAL CODE NO. P1AXX: CMU01 MODULE TEMPERATURE SENSOR ABNORMAL CODE NO. P1AXX: CMU01 BALANCER ABNORMAL CODE NO. P1A9A: CMU ID AUTO NUMBERING ERROR CODE NO. P1AXX: CHANGE ID (CMU XX) CODE NO. P1AA7: EV-ECU SIGNAL TIME-OUT CODE NO. P1AA8: LOCAL CAN (FOR MAIN BATTERY) SIGNAL TIME-OUT CODE NO. P1AA9: CELL NUMBER MISMATCH CODE NO. P1AAB: NUMBERS OF CELLS ABNORMAL CODE NO. P1AXX: CMU01 MODULE TEMPERATURE ABNORMAL (LOW INPUT) CODE NO. P1AC1: TRACTION BATTERY COOLING FAN FAILED (DRIVING ABNORMAL) CODE NO. P1AC2: TRACTION BATTERY COOLING FAN FAILED (SHORT CIRCUITS TO POWER SUPPLY SYSTEM) CODE NO. P1AC3: TRACTION BATTERY COOLING FAN FAILED (STOP ABNORMAL) CODE NO. P1AC4: CALCULATION ABNORMAL CODE NO. P1AC6: VOLTAGE OF EACH BATTERY CELL ABNORMAL (HI SIDE) CODE No. P1AXX: CMUXX BATTERY CELL RESISTANCE ABNORMAL CODE NO. P1ADF: +B LINE VOLTAGE CODE NO. P1AE0: CLOCK IC TIME COUNTER CODE NO. P1AE1: CLOCK IC ALARM CODE NO. P1AE3: BMU TEMP. SENSOR (OPEN/SHORT) CODE NO. P1AE4: BMU TEMP. SENSOR (RATIONALITY) CODE NO. U1073: BUS OFF CODE NO. U1082: LOCAL CAN (FOR MAIN BATTERY) BUS OFF CODE NO. U1100: EV-ECU TIME-OUT CODE NO. U1108: COMBINATION METER TIME-OUT CODE NO. U1109: ETACS-ECU TIME-OUT CODE NO. U111B: MCU TIME-OUT CODE NO. U11A0: CMU01 TIME-OUT CODE NO. U1922: K-LINE RECEIVING SIGNAL ERROR CODE NO. U1925: CMU ID NUMBERING RECEPTION ERROR CODE NO. U1926: EV-ECU CAN ABNORMAL INSPECTION CHART FOR TROUBLE SYMPTOMSSYMPTOM PROCEDURES BMU DATA LIST REFERENCE TABLE CMU DATA LIST REFERENCE TABLE BMU ACTUATOR TEST REFERENCE TABLE CHECK AT THE BMU TERMINALS INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE PROCEDURES FOR SMOOTHING CELL VOLTAGE MAIN BATTERY COOLING FAN RELAY CONTINUITY CHECK CHECK ON COIL RESISTANCE OF CONTACTOR CHECK ON SERVICE PLUG CHECK ON SERVICE PLUG SWITCH LOCAL CAN ( FOR MAIN BATTERY) TERMINATING RESISTANCE CHECK MAIN BATTERY CAPACITY MEASUREMENT CHECK ON MAIN BATTERY CAPACITY CHECK AND REPLACEMENT OF THE HIGH-VOLTAGE FUSE INSIDE THE TRACTION BATTERYBATTERY MANAGEMENT UNIT (BMU)TRACTION BATTERY TRACTION BATTERY REMOVAL AND INSTALLATIONTRACTION BATTERY DISASSEMBLY AND REASSEMBLY SERVICE PROCEDURE SERVICE PROCEDURE CHECK SHEET TRACTION BATTERY COVER REMOVAL AND INSTALLATION AIR DUCT REMOVAL AND INSTALLATION PAD REMOVAL AND INSTALLATION BUS BAR REMOVAL AND INSTALLATION EIGHT-CELL MODULE REMOVAL AND INSTALLATION JFB COVER REMOVAL AND INSTALLATION FOUR-CELL MODULE REMOVAL AND INSTALLATION ELECTRIC CURRENT SENSOR REMOVAL AND INSTALLATION JFB REMOVAL AND INSTALLATION RESISTOR REMOVAL AND INSTALLATION CONTACTOR REMOVAL AND INSTALLATION COOLING FAN REMOVAL AND INSTALLATION TRACTION BATTERY MODULE REPLACEMENTINSPECTION PRECAUTIONS ON HOW TO USE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET SERVICE SPECIFICATIONS SPECIAL TOOLS DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P1C00: DCDC INPUT VOLTAGE ABNORMAL CODE NO. P1C02: DCDC OUTPUT VOLTAGE ABNORMAL, P1C22: DCDC OUTPUT VOLTAGE ABNORMAL(2) CODE NO. P1C04: DCDC OUTPUT VOLTAGE REDUCTION CODE NO. P1C06: DCDC IGCT VOLTAGE ABNORMAL CODE NO. P1C08: DCDC RECTIFIER TEMPERATURE, P1C09: DCDC INSIDE TEMPERATURE CODE NO. P1C11: DCDC ROM/RAM FAIL CODE NO. P1C12: DCDC EEPROM FAIL CODE NO. P1C13: DCDC A/D CONVERTER CODE NO. P1C15: DCDC OUTPUT CURRENT SENSOR FAIL CODE NO. P1C16: LOCAL CAN COMMUNICATION FAIL CODE NO. P1C19: DCDC LOW TEMPERATURE CODE NO. P1C21: DCDC INPUT VOLTAGE ABNORMAL(2) CODE NO. P1C23: BATTERY SENSING VOLTAGE ABNORMAL CODE NO. P1D00: AC INPUT VOLTAGE (LOW), P1D01: AC INPUT VOLTAGE (HIGH), P1D02: AC INPUT VOLTAGE (OVER) CODE NO. P1D03: AC INPUT CURRENT (HIGH) CODE NO. P1D06: OUTPUT VOLTAGE (HIGH) CODE NO. P1D07: OUTPUT VOLTAGE (OVER) CODE NO. P1D08: LOAD CONNECTION ABNORMAL CODE NO. P1D09: OUTPUT CURRENT (HIGH), P1D10: OUTPUT CURRENT (CONTROL FAIL) CODE NO. P1D11: OUTPUT CURRENT (OVER) CODE NO. P1D13: IGCG VOLTAGE ABNORMAL CODE NO. P1D14: VOLTAGE COMMAND ABNORMAL CODE NO. P1D15: CURRENT COMMAND ABNORMAL CODE NO. P1D16: PILOT SIGNAL (CHARGE NOT ALLOWED), P1D17: PILOT SIGNAL (COMMUNICATION), P1D18: PILOT SIGNAL FREQUENCY ABNORMAL, P1D43: PILOT SIGNAL VOLTAGE CODE NO. P1D23: POWER CIRCUIT (PRE-CHARGE FAIL) CODE NO. P1D25: INVERTER OUTPUT CURRENT CODE NO. P1D26: INTERNAL TEMPERATURE, P1D27: PFC TEMPERATURE, P1D40: RECTIFIER COIL TEMPERATURE, P1D41: INPUT DIODE TEMPERATURE CODE NO. P1D31: ROM/RAM FAIL CODE NO. P1D32: EEPROM FAIL CODE NO. P1D33: AD CONVERTER ABNORMAL CODE NO. P1D34: INPUT CURRENT SENSOR FAIL, P1D35: OUTPUT CURRENT SENSOR FAIL CODE NO. P1D37: AC POWER SUPPLY/AC INPUT FUSE 1, P1D44: POWER SUPPLY EQUIPMENT ABNORMAL CODE NO. P1D42: TEMPERATURE SENSOR CODE NO. P1D45: FAILURE DETECTION CIRCUIT CODE NO. U1100: EV ECU CAN TIMEOUT (1) SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATIONS CANNOT BE DONE BETWEEN M.U.T.-III AND ON BOARD CHARGER CHARGE WARNING LAMP OF AUXILIARY BATTERY LIT IN READY STATUS ALTHOUGH REGULAR CHARGING IS POSSIBLE, POWER INDICATOR AND CHARGING INDICATOR ARE NOT LIT POWER INDICATOR IS NOT LIT (REGULAR CHARGING IS IMPOSSIBLE) ALTHOUGH POWER INDICATOR IS LIT, CHARGING INDICATOR IS NOT LIT (REGULAR CHARGING IS IMPOSSIBLE) ALTHOUGH POWER INDICATOR AND CHARGING INDICATOR ARE LIT, REGULAR CHARGING IS IMPOSSIBLE FAULT INDICATOR (RED LAMP) IS LIT FAULT INDICATOR (RED LAMP) BLINKS POWER INDICATOR AND FAULT INDICATOR FLASH WHEN MANUAL STOP IS PRESSED, THE REGULAR CHARGING DOES NOT TERMINATE STOP INDICATOR IS LIT, AND REGULAR CHARGING IS IMPOSSIBLE THE STOP INDICATOR DOES NOT ILLUMINATE WHEN MANUAL STOP IS PRESSED POWER SUPPLY SYSTEM OF ON BOARD CHARGER CHARGING DOES NOT START, OR THE CHARGING INDICATOR IS NOT ILLUMINATED WHEN THE CHARGER IS CONNECTED TO DOMESTIC POWER SUPPLY. CHARGING TIME IS LONGER THAN USUAL, OR CHARGING DOES NOT STOP. DOMESTIC CIRCUIT BREAKER INTERRUPTS THE POWER SUPPLY. ELECTRIC SHOCK DATA LIST REFERENCE TABLEON-VEHICLE SERVICEON BOARD CHARGER (OBC) /DC-DC CONVERTEREV CHARGING CABLE (REGULAR CHARGER)INLET CAPCHARGING CABLE PRECAUTIONS ON HOW TO USE THE HIGH-VOLTAGE VEHICLE SERVICE PLUG REMOVAL STEPS CHECK SHEET SYMPTOM CHARTSYMPTOM PROCEDURES NON-REMOVAL QUICK CHARGING GUN Quick charging is impossible, or the external power supply equipment (MiEV power BOX) cannot be used.ON-VEHICLE SERVICEEV CHARGING CABLE (QUICK CHARGER)INLET CAP GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)SERVICE PRECAUTIONSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHART<A/C CONTROLLER ASSEMBLY (A/C-ECU)>DIAGNOSIS CODE PROCEDURES<A/C CONTROLLER ASSEMBLY (A/C-ECU)> B1001 INTERIOR TEMPERATURE SENSOR SYSTEM B1011 AMBIENT TEMPERATURE SENSOR SYSTEM B1016 HEATER WATER TEMPERATURE SYSTEM B1021 AIR THERMO SENSOR SYSTEM B1041 POTENTIOMETER SYSTEM FOR THE FRONT AIR MIX DAMPER B1045 MOTOR DRIVE SYSTEM FOR THE FRONT AIR MIX DAMPER B1061 POTENTIOMETER SYSTEM FOR AIR OUTLET CHANGEOVER DAMPER B1065 MOTOR DRIVE SYSTEM FOR AIR OUTLET SWITCHING DAMPER B1083 EEPROM ERROR DIAGNOSIS CODE CHART<A/C CONTROL UNIT>DIAGNOSIS CODE PROCEDURES<A/C CONTROL UNIT> B1081 CONTROL PANEL COMM.ERROR B1083 EEPROM ERROR B1101 ELC. COMPRESSOR (ETERNITY) B1102 ELC. COMPRESSOR (CURRENT) B1103 ELC. COMPRESSOR (POWER) B1104 ELC. COMPRESSOR (HEART) B1105 ELC. COMPRESSOR (COMMUNICATION) B1106 ELC. COMPRESSOR INPUT VOLT.(LOW) B1107 ELC. COMPRESSOR INPUT VOLT. (High) B1108 ELECTRIC WATER HEATER FAIL 1 B1109 ELECTRIC WATER HEATER FAIL 2 B1110 ELECTRIC WATER HEATER FAIL 3 B1111 ELC.WATER HEATER INLET SNS.LOW B1112 ELC.WATER HEATER INLET SNS.HIGH B1113 ELC.WATER HEATER OUTLET SNS.LOW B1114 ELC.WATER HEATER OUTLET SNS.HIGH B1115 ELECTRIC WATER PUMP MALFUNCTION B1116 ELECTRIC WATER PUMP HARNESS B1117 ELC.COMPRESSOR (CONTROL) B1118 ELC.COMPRESSOR (TEMP.SENSOR) B1121 IN/OUT SELECT DAMPER CIRCUIT HI B1122 IN/OUT SELECT DAMPER CIRCUIT LO B1123 IN/OUT SELECT DAMPER MALFUNCTION U1073 BUS-OFF U1100 EV-ECU CAN TIMEOUT U1102 ASC/TCL/ABS TIMEOUT/NOT EQUIPPED U1108 METER CAN TIMEOUT/NOT EQUIPPED U1109 ETACS CAN TIMEOUT/NOT EQUIPPED U111C BMU CAN TIMEOUT U1190 NO RECEIVE FAULT DETECT SIGNAL SYMPTOM CHARTSYMPTOM PROCEDURES COOL AIR DOES NOT COME POOR HEATER PERFORMANCE BLOWER MOTOR DOES NOT OPERATE BLOWER AIR AMOUNT CANNOT BE CHANGED. INSIDE/OUTSIDE AIR CHANGEOVER IS NOT POSSIBLE. MAX SWITCH OPERATION IS NOT ACCEPTED A/C-ECU POWER SUPPLY SYSTEM COMMUNICATION WITH THE M.U.T.-III IS NOT POSSIBLE<A/C-ECU> COMMUNICATION WITH THE M.U.T.-III IS NOT POSSIBLE<A/C control unit> Blower motor power supply system DATA LIST REFERENCE TABLE<A/C CONTROLLER ASSEMBLY (A/C-ECU)> DATA LIST REFERENCE TABLE<A/C CONTROL UNIT> ACTUATOR TEST REFERENCE TABLE<A/C CONTROLLER ASSEMBLY (A/C-ECU)> ACTUATOR TEST REFERENCE TABLE<A/C CONTROL UNIT> CHECK AT ECU TERMINAL<A/C CONTROLLER ASSEMBLY (A/C-ECU)> CHECK AT ECU TERMINAL<A/C CONTROL UNIT>ON-VEHICLE SERVICE REFRIGERANT LEVEL CHECK, DRAINING AND CHARGING PERFORMANCE TEST <VEHICLES USING R-134a REFRIGERANT> DIAGNOSIS BY REFRIGERANT PRESSURE SIMPLE INSPECTION OF THE A/C PRESSURE SENSOR CHECK THE WATER HEATER FLUID CHECK THE CONCENTRATION OF THE WATER HEATER FLUID DRAIN AND FILL UP THE WATER HEATER FLUID. LEAKAGE CHECK FOR WATER HEATER FLUID CHECK THE CONCENTRATION OF THE WATER HEATER FLUID POWER RELAY CHECK CLEAN AIR FILTER REPLACEMENT PROCEDUREHEATER CONTROL UNITHEATER UNIT AND BLOWER ASSEMBLY HEATER UNIT AND BLOWER ASSEMBLY REMOVAL AND INSTALLATION HEATER UNIT AND BLOWER ASSEMBLY DISASSEMBLY AND REASSEMBLY INSPECTIONMODE SELECTION DAMPER CONTROL MOTOR, AIR MIXING DAMPER CONTROL MOTOR, OUTSIDE/INSIDE AIR SELECTION DAMPER CONTROL MOTOR, POWER TRANSISTOR AND BLOWER MOTOR MODE SELECTION DAMPER CONTROL MOTOR, AIR MIXING DAMPER CONTROL MOTOR, OUTSIDE/INSIDE AIR SELECTION DAMPER CONTROL MOTOR, POWER TRANSISTOR AND BLOWER MOTOR REMOVAL AND INSTALLATION INSPECTIONHEATERHEATER WATER PUMPHEATER HOSEAMBIENT AIR TEMPERATURE SENSORA/C CONTROL UNITCOMPRESSOR ASSEMBLYCONDENSER ASSEMBLYREFRIGERANT LINEDUCTSVENTILATORS RELAY SOLENOID AND SOLENOID VALVE SENSOR ECU FUSIBLE LINK AND FUSE INSPECTION CONNECTOR AND SPARE CONNECTOR EARTH CABLE EARTHOVERALL CONFIGURATION DIAGRAM OVERALL CONFIGURATION DIAGRAM<LOW VOLTAGE-12V (LHD)> OVERALL CONFIGURATION DIAGRAM<LOW VOLTAGE-12V (RHD)> OVERALL CONFIGURATION DIAGRAM<HIGH VOLTAGE>HOOD ROOMINSTRUMENT PANELFLOOR AND ROOF DOOR ELECTRIC MOTOR UNIT ROOM TAILGATE UNDER FLOOR AND ELECTRIC MOTOR UNIT ROOM<HIGH VOLTAGE (330V)> TRACTION BATTERY JUNCTION BLOCK (J/B)JOINT CONNECTOR (J/C)CENTRALIZED JUNCTION POWER DISTRIBUTION SYSTEM HIGH VOLTAGE POWER SUPPLY CONTROL SYSTEM QUICK CHARGING CONTROL SYSTEM REGULAR CHARGING CONTROL SYSTEM AUXILIARY BATTERY CHARGING CONTROL SYSTEM TRACTION BATTERY MANAGEMENT SYSTEM ELECTRIC MOTOR UNIT CONTROL SYSTEMTRACTION BATTERY COOLING SYSTEM ELECTRIC MOTOR UNIT COOLING SYSTEMHEADLAMP HEADLAMP<HALOGEN TYPE (LHD)> HEADLAMP<HALOGEN TYPE (RHD)> HEADLAMP<LED TYPE (LHD)> HEADLAMP<LED TYPE (RHD)>TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<LHD> TAIL LAMP, POSITION LAMP, LICENCE PLATE LAMP AND LIGHTING MONITOR BUZZER<RHD> HEADLAMP MANUAL LEVELLING SYSTEMHEADLAMP AUTOMATIC LEVELLING SYSTEMDAYTIME RUNNING LAMP (DRL)FRONT FOG LAMPREAR FOG LAMPROOM LAMPTURN-SIGNAL LAMP AND HAZARD WARNING LAMP BACK-UP LAMP STOP LAMP HORN METER AND GAUGE BRAKE WARNING LAMPPOWER WINDOWSCENTRAL DOOR LOCKING SYSTEMAIR CONDITIONERWINDSHIELD WIPER AND WASHERREAR WIPER AND WASHERREAR WINDOW DEFOGGER AND DOOR MIRROR HEATERELECTRIC RETRACTABLE REMOTE CONTROLLED MIRROR ELECTRIC RETRACTABLE REMOTE CONTROLLED MIRROR<LHD> ELECTRIC RETRACTABLE REMOTE CONTROLLED MIRROR<RHD> AUDIO SYSTEM SPARE CONNECTOR (FOR AUDIO) ACCESSORY SOCKET BRAKE VACUUM GENERATION SYSTEMANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC) ANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC)<LHD> ANTI-SKID BRAKING SYSTEM (ABS) AND ACTIVE STABILITY CONTROL SYSTEM (ASC)<RHD>SRS HIGH VOLTAGE SHUTDOWN SYSTEMELECTRIC POWER STEERING SYSTEM HEATED SEATIMMOBILIZER SYSTEMSEAT BELT WARNINGDOOR AJAR WARNING BUZZERELECTRIC MOTOR REMINDER BUZZERSELECT LEVER REMINDER BUZZERACOUSTIC VEHICLE ALERTING SYSTEM (AVAS)MiEV REMOTE SYSTEM CONTROLLER AREA NETWORK (CAN)TYRE PRESSURE MONITORING SYSTEM (TPMS)