(2016 Basic) HOW TO USE THIS MANUAL (2016 Supplement) HOW TO USE THIS MANUAL (2017 Supplement) HOW TO USE THIS MANUALHOW TO USE TROUBLESHOOTING/INSPECTION SERVICE POINTS
CONTENTS OF TROUBLESHOOTING DIAGNOSIS FUNCTION HOW TO USE THE INSPECTION PROCEDURES CONNECTOR MEASUREMENT SERVICE POINTS CONNECTOR INSPECTION SERVICE POINTS INSPECTION SERVICE POINTS FOR A BLOWN FUSE HOW TO COPE WITH INTERMITTENT MALFUNCTIONS HOW TO TREAT PAST TROUBLE (2016 Basic) RELAY INSPECTION
(2016 Supplement) RELAY INSPECTIONVEHICLE IDENTIFICATION (2016 Basic) MODELS (2016 Supplement) MODELS (2017 Supplement) MODELS (2016 Basic) VEHICLE IDENTIFICATION NUMBER (CHASSIS NUMBER) (2016 Supplement) VEHICLE IDENTIFICATION NUMBER (CHASSIS NUMBER) (2017 Supplement) VEHICLE IDENTIFICATION NUMBER (CHASSIS NUMBER) (2016 Basic) ENGINE MODEL STAMPING (2016 Supplement) ENGINE MODEL STAMPING (2016 Supplement) VEHICLE INFORMATION CODE PLATE (2016 Supplement) VEHICLE IDENTIFICATION NUMBER (VIN) PLATE (2017 Supplement) VEHICLE IDENTIFICATION NUMBER (VIN) PLATE (2016 Supplement) MANUFACTURER PLATE (2016 Supplement) CERTIFICATION LABEL (2016 Supplement) THEFT PROTECTION LABELGENERAL DATA AND SPECIFICATIONS (2016 Basic) GENERAL DATA AND SPECIFICATIONS (2016 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR GENERAL EXPORT> (2016 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR GCC> (2016 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR RUSSIA (EASTERN EUROPE COUNTRIES> (2016 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR AUSTRALIA AND NEW ZEALAND> (2017 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR THAILAND> (2017 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR GENERAL EXPORT> (2017 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR GCC> (2017 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR EASTERN EUROPE COUNTRIES (RUSSIA)> (2017 Supplement) GENERAL DATA AND SPECIFICATIONS<VEHICLES FOR AUSTRALIA AND NEW ZEALAND>PRECAUTIONS BEFORE SERVICE ABOUT THE DESCRIPTION OF THE IGNITION SWITCH POWER SUPPLY MODE BY THE ENGINE SWITCH OPERATION ENGINE SWITCH INDICATOR CAUTIONS FOR AIR CONDITIONER STARTING SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SERVICING ELECTRICAL SYSTEM IN ORDER TO PREVENT VEHICLES FROM FIRE (2016 Basic) HOW TO SHIFT LOCK FORCED RELEASE<A/T> (2016 Supplement) HOW TO SHIFT LOCK FORCED RELEASE<5A/T> MULTI USE TESTER (M.U.T.-III) SUB ASSEMBLY HOW TO PERFORM CHASSIS NUMBER (Chassis No.) WRITING PRE-INSPECTION CONDITION ENGINE OILS INITIALISATION PROCEDURE FOR LEARNING VALUE IN MPI ENGINE<Petrol> LEARNING PROCEDURE FOR IDLING IN MPI ENGINE<Petrol> (2016 Basic) SERVICING COMMON RAIL ENGINE<Diesel> (2016 Supplement) SERVICING COMMON RAIL ENGINE<4D5, 4N1> (2016 Basic) WHAT THE COMMON RAIL ENGINE LEARNS<Diesel> (2016 Supplement) WHAT THE COMMON RAIL ENGINE LEARNS<4D5, 4N1> (2016 Basic) INJECTOR IDENTIFICATION CODE REGISTRATION PROCEDURE<Diesel> (2016 Supplement) INJECTOR IDENTIFICATION CODE REGISTRATION PROCEDURE<4D5, 4N1> (2016 Basic) SMALL INJECTION QUANTITY LEARNING PROCEDURE<Diesel> (2016 Supplement) SMALL INJECTION QUANTITY LEARNING PROCEDURE<4D5, 4N1> (2016 Basic) SUPPLY PUMP CORRECTION LEARNING PROCEDURE<Diesel> (2016 Supplement) SUPPLY PUMP CORRECTION LEARNING PROCEDURE<4D5, 4N1> (2016 Basic) INITIALISATION PROCEDURE FOR LEARNING VALUE IN COMMON RAIL ENGINE<Diesel> (2016 Supplement) INITIALISATION PROCEDURE FOR LEARNING VALUE IN COMMON RAIL ENGINE<4D5, 4N1> (2016 Basic) BATTERY CURRENT SENSOR CALIBRATION<4N1> (2016 Supplement) BATTERY CURRENT SENSOR CALIBRATION<4N1-EURO5> FORM-IN-PLACE GASKET (FIPG) HOW TO USE THE THROTTLE CONTROLLER VEHICLE WASHING BELT TENSION METER SET (2016 Supplement) INITIALISATION PROCEDURE FOR LEARNING VALUE IN DIESEL PARTICULATE FILTER (DPF) SYSTEM<4N1-EURO5> (2017 Supplement) PRECAUTIONS FOR INSTALLATION OF ON-VEHICLE RADIO TRANSMISSION EQUIPMENT SUPPLEMENTAL RESTRAINT SYSTEM (SRS) SRS SERVICE PRECAUTIONS SUPPORT LOCATIONS FOR LIFTING AND JACKING TREATMENT BEFORE/AFTER THE FORDING OF A STREAM CLIP TABLE TOWING AND HOISTINGHOW TO READ WIRING DIAGRAMS COMPOSITION AND CONTENTS OF WIRING DIAGRAMS HOW TO READ CONFIGURATION DIAGRAMS HOW TO READ CIRCUIT DIAGRAMS MARKINGS FOR CONNECTOR AND EARTHING WIRE COLOUR CODES (2016 Basic) ABBREVIATION SYMBOLS (2016 Supplement) ABBREVIATION SYMBOLS (2017 Supplement) ABBREVIATION SYMBOLSOUTLINE OF CHANGE GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS AND ADHESIVES SPECIAL TOOLSON-VEHICLE SERVICE DRIVE BELT TENSION CHECK AND ADJUSTMENT IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECK LASH ADJUSTER CHECKCRANKSHAFT PULLEYCAMSHAFT OIL SEALCAMSHAFTVALVE STEM SEALOIL PAN AND OIL STRAINERCRANKSHAFT OIL SEALCYLINDER HEAD GASKETTIMING BELTENGINE ASSEMBLY GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSCOOLING FAN AND PULLEYCRANKSHAFT PULLEYIGNITION COILCAMSHAFT POSITION SENSORALTERNATORTIMING BELTFLYWHEELTHROTTLE BODYINJECTORINLET MANIFOLDEXHAUST MANIFOLDWATER HOSE AND PIPEDETONATION SENSORROCKER ARMS AND CAMSHAFTCYLINDER HEAD AND VALVESOIL PANFRONT CASE AND OIL PUMPPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS AND ADHESIVES SPECIAL TOOLSON-VEHICLE SERVICE ALTERNATOR AND OTHERS BELT TENSION CHECK AND ADJUSTMENT ALTERNATOR DRIVE BELT AUTO-TENSIONER CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT ROCKER ARM PISTON OPERATION CHECK IGNITION TIMING CHECK IDLE SPEED CHECK IDLE MIXTURE CHECK COMPRESSION PRESSURE CHECK MANIFOLD VACUUM CHECK LASH ADJUSTER CHECK<Exhaust valve>CRANKSHAFT PULLEYCAMSHAFTCAMSHAFT OIL SEALOIL FEEDER CONTROL VALVEROCKER COVER AND ROCKER ARMSVALVE STEM SEALOIL PAN AND OIL SCREENCRANKSHAFT FRONT OIL SEALCRANKSHAFT REAR OIL SEALCYLINDER HEAD GASKETTIMING BELTENGINE ASSEMBLY (2016 Basic) GENERAL SPECIFICATIONS (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS REWORK DIMENSIONS (2016 Basic) TORQUE SPECIFICATIONS (2016 Supplement) TORQUE SPECIFICATIONS SEALANTS (2016 Basic) SPECIAL TOOLS (2016 Supplement) SPECIAL TOOLSALTERNATORDRIVE PLATETHROTTLE BODY AND EGR SYSTEMINLET UPPER MANIFOLD AND INLET MIDDLE MANIFOLDWATER HOSE AND PIPETIMING BELTINLET MANIFOLDEXHAUST MANIFOLD (2016 Basic) EXHAUST MANIFOLD REMOVAL AND INSTALLATION (2016 Supplement) EXHAUST MANIFOLD REMOVAL AND INSTALLATIONROCKER COVER AND CAMSHAFTCYLINDER HEAD AND VALVESOIL PAN AND OIL PUMPPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCKBRACKET (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Basic) SEALANTS AND ADHESIVES (2016 Supplement) SEALANTS AND ADHESIVES (2016 Basic) SPECIAL TOOLS (2016 Supplement) SPECIAL TOOLSON-VEHICLE SERVICE ALTERNATOR DRIVE BELT TENSION CHECK AND ADJUSTMENT (2016 Basic) POWER STEERING OIL PUMP AND A/C COMPRESSOR DRIVE BELT TENSION CHECK AND ADJUSTMENT (2016 Supplement) POWER STEERING OIL PUMP AND A/C COMPRESSOR DRIVE BELT TENSION CHECK AND ADJUSTMENT AUTO-TENSIONER CHECK VALVE CLEARANCE CHECK AND ADJUSTMENT ROCKER ARM PISTON OPERATION CHECK IDLE SPEED CHECK COMPRESSION PRESSURE CHECKCRANKSHAFT PULLEYVACUUM PUMPROCKER COVER ASSEMBLY (2016 Basic) ROCKER COVER ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) ROCKER COVER ASSEMBLY REMOVAL AND INSTALLATIONCAMSHAFTROCKER ARM AND SHAFT ASSEMBLYVALVE STEM SEALOIL FEEDER CONTROL VALVEOIL PAN AND OIL SCREENCRANKSHAFT FRONT OIL SEALCRANKSHAFT REAR OIL SEAL (2016 Basic) CRANKSHAFT REAR OIL SEAL REMOVAL AND INSTALLATION (2016 Supplement) CRANKSHAFT REAR OIL SEAL REMOVAL AND INSTALLATION<M/T>CYLINDER HEAD GASKETTIMING CHAIN CASE ASSEMBLYTIMING CHAINTIMING GEAR AND BALANCER UNITENGINE ASSEMBLY GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS REWORK DIMENSIONS TORQUE SPECIFICATIONS SEALANTS SPECIAL TOOLSSOLENOID VALVE AND VACUUM HOSECOOLING FAN AND PULLEYCRANKSHAFT PULLEYCAMSHAFT POSITION SENSOR AND CRANK ANGLE SENSORGLOW PLUGALTERNATORENGINE OIL PRESSURE SWITCHOIL FILTEROIL COOLERVACUUM PUMPCOMMON RAIL AND SUPPLY PUMPTHROTTLE BODYEGR SYSTEMINLET MANIFOLDTURBOCHARGER ASSEMBLYEXHAUST MANIFOLDWATER HOSE AND PIPEROCKER COVERROCKER ARMS AND CAMSHAFTOIL PANTIMING CHAIN CASETIMING CHAINTIMING GEAR AND BALANCER UNITOIL FEEDER CONTROL VALVECYLINDER HEAD AND VALVESPISTON AND CONNECTING RODCRANKSHAFT AND CYLINDER BLOCK (2016 Supplement) GENERAL INFORMATION (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) SEALANTS AND ADHESIVES (2016 Supplement) SPECIAL TOOLSON-VEHICLE SERVICE (2016 Supplement) ALTERNATOR AND POWER STEERING OIL PUMP DRIVE BELT TENSION CHECK AND ADJUSTMENT (2016 Supplement) A/C COMPRESSOR DRIVE BELT TENSION CHECK AND ADJUSTMENT (2016 Supplement) A/C COMPRESSOR DRIVE BELT CHECK (2016 Supplement) AUTO-TENSIONER CHECK (2016 Supplement) VALVE CLEARANCE CHECK AND ADJUSTMENT (2016 Supplement) IDLE SPEED CHECK (2016 Supplement) COMPRESSION PRESSURE CHECK (2016 Supplement) TIMING BELT B TENSION ADJUSTMENTCRANKSHAFT PULLEYVACUUM PUMPCAMSHAFT AND VALVE STEM SEALOIL PAN AND OIL STRAINER (2016 Supplement) OIL PAN AND OIL STRAINER REMOVAL AND INSTALLATION (2016 Supplement) OIL PAN AND OIL STRAINER INSPECTIONCRANKSHAFT OIL SEAL (2016 Supplement) CRANKSHAFT OIL SEAL REMOVAL AND INSTALLATION<M/T> (2016 Supplement) CRANKSHAFT OIL SEAL REMOVAL AND INSTALLATION<A/T>CYLINDER HEAD GASKETTIMING BELTENGINE ASSEMBLY (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) REWORK DIMENSIONS (2016 Supplement) TORQUE SPECIFICATIONS (2016 Supplement) SEALANTS (2016 Supplement) SPECIAL TOOLSSOLENOID VALVE AND VACUUM HOSEALTERNATORINLET MANIFOLDEXHAUST MANIFOLD AND TURBOCHARGERTIMING BELTCOMMON RAIL AND SUPPLY PUMPROCKER COVER AND INJECTORWATER HOSE AND PIPEROCKER ARMS AND CAMSHAFT (2016 Supplement) ROCKER ARMS AND CAMSHAFT REMOVAL AND INSTALLATION (2016 Supplement) ROCKER ARMS AND CAMSHAFT INSPECTIONCYLINDER HEAD AND VALVES (2016 Supplement) CYLINDER HEAD AND VALVES REMOVAL AND INSTALLATION (2016 Supplement) CYLINDER HEAD AND VALVES INSPECTIONOIL PAN AND OIL PUMP (2016 Supplement) OIL PAN AND OIL PUMP REMOVAL AND INSTALLATION (2016 Supplement) OIL PAN AND OIL PUMP INSPECTIONPISTON AND CONNECTING ROD (2016 Supplement) PISTON AND CONNECTING ROD REMOVAL AND INSTALLATION (2016 Supplement) PISTON AND CONNECTING ROD INSPECTIONCRANKSHAFT AND CYLINDER BLOCK (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS (2016 Basic) SEALANTS OR ADHESIVES (2016 Supplement) SEALANTS OR ADHESIVES (2016 Basic) LUBRICANTS (2016 Supplement) LUBRICANTS (2016 Basic) SPECIAL TOOLS (2016 Supplement) SPECIAL TOOLSON-VEHICLE SERVICE (2016 Basic) ENGINE OIL CHECK (2016 Supplement) ENGINE OIL CHECK<4N1, 4D5> (2016 Basic) ENGINE OIL CHANGE (2016 Supplement) ENGINE OIL CHANGE<4N1, 4D5> (2016 Basic) ENGINE OIL FILTER REPLACEMENT (2016 Supplement) ENGINE OIL FILTER REPLACEMENT<4D5> OIL PRESSURE CHECKENGINE OIL PRESSURE SWITCH (2016 Basic) ENGINE OIL PRESSURE SWITCH REMOVAL AND INSTALLATION<4N1> (2016 Supplement) ENGINE OIL PRESSURE SWITCH REMOVAL AND INSTALLATION<4D5>ENGINE OIL COOLER (2016 Basic) ENGINE OIL COOLER REMOVAL AND INSTALLATION<4N1> (2016 Supplement) ENGINE OIL COOLER REMOVAL AND INSTALLATION<4D5>OIL FILTER BRACKET<4N1> GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0031 OXYGEN SENSOR (FRONT) HEATER CIRCUIT LOW INPUT CODE NO. P0032 OXYGEN SENSOR (FRONT) HEATER CIRCUIT HIGH INPUT CODE NO. P0037 OXYGEN SENSOR (REAR) HEATER CIRCUIT LOW INPUT CODE NO. P0038 OXYGEN SENSOR (REAR) HEATER CIRCUIT HIGH INPUT CODE NO. P0068 TRUSTFUL CHECK AIR FLOW SENSOR CODE NO. P0102 AIR FLOW SENSOR CIRCUIT LOW INPUT CODE NO. P0103 AIR FLOW SENSOR CIRCUIT HIGH INPUT CODE NO. P0107 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P0108 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0112 INTAKE AIR TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0113 INTAKE AIR TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0117 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0118 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0121 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P0131 OXYGEN SENSOR (FRONT) CIRCUIT LOW VOLTAGE CODE NO. P0132 OXYGEN SENSOR (FRONT) CIRCUIT HIGH VOLTAGE CODE NO. P0133 OXYGEN SENSOR (FRONT) CIRCUIT SLOW RESPONSE CODE NO. P0134 OXYGEN SENSOR (FRONT) CIRCUIT NO ACTIVITY DETECTED CODE NO. P0137 OXYGEN SENSOR (REAR) CIRCUIT LOW VOLTAGE CODE NO. P0138 OXYGEN SENSOR (REAR) CIRCUIT HIGH VOLTAGE CODE NO. P0171 ABNORMAL FUEL SYSTEM (LEAN) CODE NO. P0172 ABNORMAL FUEL SYSTEM (RICH) CODE NO. P0221 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0261 NO.1 INJECTOR CIRCUIT LOW INPUT CODE NO. P0262 NO.1 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0264 NO.2 INJECTOR CIRCUIT LOW INPUT CODE NO. P0265 NO.2 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0267 NO.3 INJECTOR CIRCUIT LOW INPUT CODE NO. P0268 NO.3 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0270 NO.4 INJECTOR CIRCUIT LOW INPUT CODE NO. P0271 NO.4 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0327 DETONATION SENSOR CIRCUIT LOW INPUT CODE NO. P0328 DETONATION SENSOR CIRCUIT HIGH INPUT CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0421 CATALYST MALFUNCTION CODE NO. P0458 PURGE CONTROL SOLENOID VALVE CIRCUIT LOW INPUT CODE NO. P0459 PURGE CONTROL SOLENOID VALVE CIRCUIT HIGH INPUT CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM CODE NO. P0513 IMMOBILIZER SYSTEM CODE NO. P0537 FIN THERMO SENSOR CIRCUIT LOW INPUT CODE NO. P0538 FIN THERMO SENSOR CIRCUIT HIGH INPUT CODE NO. P0602 VARIANT CODING SYSTEM CODE NO. P0604 RAM ERROR CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P060B A/D CONVERTER CODE NO. P060D TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P061A TORQUE MONITORING CODE NO. P061F FAIL-SAFE CONTROL SYSTEM CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P062F EEPROM MALFUNCTION CODE NO. P0630 CHASSIS NUMBER NOT PROGRAMMED CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0642 THROTTLE POSITION SENSOR POWER SUPPLY CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1238 AIR FLOW SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1242 FAIL-SAFE CONTROL MONITORING CODE NO. P1243 INQUIRY/RESPONSE ERROR CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2101 THROTTLE VALVE CONTROL SERVO MAGNETO MALFUNCTION CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2228 BAROMETRIC PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P2229 BAROMETRIC PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P2252 OXYGEN SENSOR OFFSET CIRCUIT LOW VOLTAGE CODE NO. P2253 OXYGEN SENSOR OFFSET CIRCUIT HIGH VOLTAGE CODE NO. U0121 ABS-ECU TIME-OUT CODE NO. U0141 ETACS-ECU TIME-OUT CODE NO. U0155 COMBINATION METER TIME-OUT CODE NO. U0167 KOS-ECU COMMUNICATION ERROR<Vehicles with KOS> SYMPTOM CHARTSYMPTOM PROCEDURES THE COMMUNICATION BETWEEN M.U.T.-III AND ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (STARTER NOT OPERATIVE) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), IMPROPER STARTING (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT), THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING DEVIATION RUN ON (DIESELING) ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION OF CO/HC DURING IDLING. BATTERY RUN DOWN OVERHEATING ENGINE-ECU POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM FUEL PUMP SYSTEM IGNITION CIRCUIT SYSTEM A/C SWITCH SYSTEM A/C COMPRESSOR RELAY SYSTEM POWER STEERING FLUID PRESSURE SWITCH SYSTEM. FAN CONTROL RELAY SYSTEM ENGINE OIL PRESSURE SWITCH SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ECU TERMINALS INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK OXYGEN SENSOR CHECK INJECTOR CHECK THROTTLE VALVE CONTROL SERVO CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW (2016 Basic) DIAGNOSIS FUNCTION (2016 Supplement) DIAGNOSIS FUNCTION (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P001A OIL FEEDER CONTROL VALVE SYSTEM (2016 Basic) CODE NO. P0031 RIGHT BANK OXYGEN SENSOR (FRONT) HEATER CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0031 OXYGEN SENSOR (FRONT) HEATER CIRCUIT LOW INPUT (2016 Basic) CODE NO. P0032 RIGHT BANK OXYGEN SENSOR (FRONT) HEATER CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0032 OXYGEN SENSOR (FRONT) HEATER CIRCUIT HIGH INPUT CODE NO. P0037 RIGHT BANK OXYGEN SENSOR (REAR) HEATER CIRCUIT LOW INPUT CODE NO. P0038 RIGHT BANK OXYGEN SENSOR (REAR) HEATER CIRCUIT HIGH INPUT CODE NO. P0051 LEFT BANK OXYGEN SENSOR (FRONT) HEATER CIRCUIT LOW INPUT CODE NO. P0052 LEFT BANK OXYGEN SENSOR (FRONT) HEATER CIRCUIT HIGH INPUT CODE NO. P0057 LEFT BANK OXYGEN SENSOR (REAR) HEATER CIRCUIT LOW INPUT CODE NO. P0058 LEFT BANK OXYGEN SENSOR (REAR) HEATER CIRCUIT HIGH INPUT CODE NO. P0068 TRUSTFUL CHECK AIR FLOW SENSOR CODE NO. P0102 AIR FLOW SENSOR CIRCUIT LOW INPUT CODE NO. P0103 AIR FLOW SENSOR CIRCUIT HIGH INPUT CODE NO. P0107 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P0108 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0112 INTAKE AIR TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0113 INTAKE AIR TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0117 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0118 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0121 TRUSTFUL CHECK THROTTLE POSITION SENSOR (MAIN) CODE NO. P0122 THROTTLE POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT (2016 Basic) CODE NO. P0131 RIGHT BANK OXYGEN SENSOR (FRONT) CIRCUIT LOW VOLTAGE (2016 Supplement) CODE NO. P0131 OXYGEN SENSOR (FRONT) CIRCUIT LOW VOLTAGE (2016 Basic) CODE NO. P0132 RIGHT BANK OXYGEN SENSOR (FRONT) CIRCUIT HIGH VOLTAGE (2016 Supplement) CODE NO. P0132 OXYGEN SENSOR (FRONT) CIRCUIT HIGH VOLTAGE CODE NO. P0133 RIGHT BANK OXYGEN SENSOR (FRONT) CIRCUIT SLOW RESPONSE CODE NO. P0134 RIGHT BANK OXYGEN SENSOR (FRONT) CIRCUIT NO ACTIVITY DETECTED CODE NO. P0137 RIGHT BANK OXYGEN SENSOR (REAR) CIRCUIT LOW VOLTAGE CODE NO. P0138 RIGHT BANK OXYGEN SENSOR (REAR) CIRCUIT HIGH VOLTAGE CODE NO. P0151 LEFT BANK OXYGEN SENSOR (FRONT) CIRCUIT LOW VOLTAGE CODE NO. P0152 LEFT BANK OXYGEN SENSOR (FRONT) CIRCUIT HIGH VOLTAGE CODE NO. P0153 LEFT BANK OXYGEN SENSOR (FRONT) CIRCUIT SLOW RESPONSE CODE NO. P0154 LEFT BANK OXYGEN SENSOR (FRONT) CIRCUIT NO ACTIVITY DETECTED CODE NO. P0157 LEFT BANK OXYGEN SENSOR (REAR) CIRCUIT LOW VOLTAGE CODE NO. P0158 LEFT BANK OXYGEN SENSOR (REAR) CIRCUIT HIGH VOLTAGE CODE NO. P0171 RIGHT BANK ABNORMAL FUEL SYSTEM (LEAN) CODE NO. P0172 RIGHT BANK ABNORMAL FUEL SYSTEM (RICH) CODE NO. P0174 LEFT BANK ABNORMAL FUEL SYSTEM (LEAN) CODE NO. P0175 LEFT BANK ABNORMAL FUEL SYSTEM (RICH) CODE NO. P0221 TRUSTFUL CHECK THROTTLE POSITION SENSOR (SUB) CODE NO. P0222 THROTTLE POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P0223 THROTTLE POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P0261 NO.1 INJECTOR CIRCUIT LOW INPUT CODE NO. P0262 NO.1 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0264 NO.2 INJECTOR CIRCUIT LOW INPUT CODE NO. P0265 NO.2 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0267 NO.3 INJECTOR CIRCUIT LOW INPUT CODE NO. P0268 NO.3 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0270 NO.4 INJECTOR CIRCUIT LOW INPUT CODE NO. P0271 NO.4 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0273 NO.5 INJECTOR CIRCUIT LOW INPUT CODE NO. P0274 NO.5 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0276 NO.6 INJECTOR CIRCUIT LOW INPUT CODE NO. P0277 NO.6 INJECTOR CIRCUIT HIGH INPUT CODE NO. P0300 RANDOM/MULTIPLE CYLINDER MISFIRE DETECTED CODE NO. P0301 NO.1 CYLINDER MISFIRE DETECTED CODE NO. P0302 NO.2 CYLINDER MISFIRE DETECTED CODE NO. P0303 NO.3 CYLINDER MISFIRE DETECTED CODE NO. P0304 NO.4 CYLINDER MISFIRE DETECTED CODE NO. P0305 NO.5 CYLINDER MISFIRE DETECTED CODE NO. P0306 NO.6 CYLINDER MISFIRE DETECTED CODE NO. P0327 DETONATION SENSOR CIRCUIT LOW INPUT CODE NO. P0328 DETONATION SENSOR CIRCUIT HIGH INPUT CODE NO. P0332 DETONATION SENSOR CIRCUIT LOW INPUT CODE NO. P0333 DETONATION SENSOR CIRCUIT HIGH INPUT CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0421 WARM UP CATALYST MALFUNCTION (RIGHT BANK) CODE NO. P0431 WARM UP CATALYST MALFUNCTION (LEFT BANK) CODE NO. P0458 PURGE CONTROL SOLENOID VALVE CIRCUIT LOW INPUT CODE NO. P0459 PURGE CONTROL SOLENOID VALVE CIRCUIT HIGH INPUT CODE NO. P0489 EXHAUST GAS RECIRCULATION VALVE (STEPPER MOTOR) CIRCUIT MALFUNCTION (GROUND SHORT) CODE NO. P0490 EXHAUST GAS RECIRCULATION VALVE (STEPPER MOTOR) CIRCUIT MALFUNCTION (BATTERY SHORT) CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0515 BATTERY TEMPERATURE SENSOR SYSTEM CODE NO. P0537 FIN THERMO SENSOR CIRCUIT LOW INPUT CODE NO. P0538 FIN THERMO SENSOR CIRCUIT HIGH INPUT CODE NO. P0602 VARIANT CODING SYSTEM CODE NO. P0604 RAM ERROR CODE NO. P0606 ENGINE-ECU MAIN PROCESSOR MALFUNCTION CODE NO. P060B A/D CONVERTER CODE NO. P060D TRUSTFUL CHECK ACCELERATOR PEDAL POSITION SENSOR CODE NO. P061A TORQUE MONITORING CODE NO. P061C TRUSTFUL CHECK ENGINE SPEED CODE NO. P061F FAIL-SAFE CONTROL SYSTEM CODE NO. P0620 ALTERNATOR CONTROL CIRCUIT CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P062F EEPROM MALFUNCTION CODE NO. P0630 VEHICLE IDENTIFICATION NUMBER (VIN) MALFUNCTION CODE NO. P0638 THROTTLE VALVE CONTROL SERVO CIRCUIT RANGE/PERFORMANCE PROBLEM CODE NO. P0642 THROTTLE POSITION SENSOR POWER SUPPLY CODE NO. P0657 THROTTLE VALVE CONTROL SERVO RELAY CIRCUIT MALFUNCTION CODE NO. P1231 TRUSTFUL CHECK ACTIVE STABILITY CONTROL (ASC) CODE NO. P1238 AIR FLOW SENSOR TRUSTFUL FOR TORQUE MONITORING CODE NO. P1240 TRUSTFUL CHECK IGNITION ANGLE CODE NO. P1242 FAIL-SAFE CONTROL MONITORING CODE NO. P1243 INQUIRY/RESPONSE ERROR CODE NO. P1247 TRUSTFUL CHECK A/T CODE NO. P1537 LIN COMMUNICATION ERROR (SENDING MESSAGE TO CURRENT BATTERY CURRENT SENSOR) CODE NO. P1538 LIN COMMUNICATION ERROR (RECEIVING MESSAGE FROM BATTERY CURRENT SENSOR) CODE NO. P1590 COMMUNICATION ERROR IN TORQUE REDUCTION REQUEST CODE NO. P1603 BATTERY BACKUP CIRCUIT MALFUNCTION CODE NO. P1608 BATTERY CURRENT SENSOR SYSTEM CODE NO. P1611 BATTERY VOLTAGE SENSOR CIRCUIT CODE NO. P2100 THROTTLE VALVE CONTROL SERVO CIRCUIT (OPEN) CODE NO. P2101 THROTTLE VALVE CONTROL SERVO MAGNETO MALFUNCTION CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2135 THROTTLE POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM CODE NO. P2228 BAROMETRIC PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P2229 BAROMETRIC PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P2252 OXYGEN SENSOR OFFSET CIRCUIT LOW VOLTAGE CODE NO. P2253 OXYGEN SENSOR OFFSET CIRCUIT HIGH VOLTAGE CODE NO. P2530 IGNITION SWITCH-IG1 CIRCUIT CODE NO. U0101 A/T-ECU TIME-OUT (2016 Basic) CODE NO. U0121 ASC-ECU TIME-OUT (2016 Supplement) CODE NO. U0121 ASC-ECU TIME-OUT CODE NO. U0141 ETACS-ECU TIME-OUT CODE NO. U0155 COMBINATION METER TIME-OUT CODE NO. U0164 A/C-ECU TIME-OUT CODE NO. U0167 IMMOBILIZER COMMUNICATION ERROR CODE NO. U0168 KOS-ECU TIME-OUT CODE NO. U0415 ASC-ECU CAN DATA ABNORMALITY CODE NO. U1005 CORNER SENSOR-ECU TIME-OUT (2016 Supplement) CODE NO. P0350 IGNITION COIL PRIMARY CIRCUIT MALFUNCTION<EURO2> (2016 Supplement) CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM<4WD> (2016 Supplement) CODE NO. U0114 4WD-ECU TIME-OUT<4WD> SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE. THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION. THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT. STARTING IMPOSSIBLE (STARTER NOT OPERATIVE) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) STARTING IMPOSSIBLE (INITIAL COMBUSTION BUT NO COMPLETE COMBUSTION), STARTING IMPOSSIBLE (LONG TIME TO START) UNSTABLE IDLING (ROUGH IDLING, HUNTING), IMPROPER IDLING SPEED (TOO HIGH OR TOO LOW), ENGINE STALLS DURING IDLING (DIE OUT) THE ENGINE STALLS WHEN STARTING THE CAR. (PASS OUT), THE ENGINE STALLS WHEN DECELERATING. ENGINE DOES NOT REVOLVE UP. HESITATION, SAG, POOR ACCELERATION, STUMBLE OR SURGE THE FEELING OF IMPACT OR VIBRATION WHEN ACCELERATING. THE FEELING OF IMPACT OR VIBRATION WHEN DECELERATING. KNOCKING IGNITION TIMING DEVIATION RUN ON (DIESELING) ODOUR, WHITE SMOKE, BLACK SMOKE AND HIGH-CONCENTRATION OF CO/HC DURING IDLING. BATTERY RUN DOWN OVERHEATING ENGINE-ECU POWER SUPPLY, ENGINE CONTROL RELAY, IGNITION SWITCH-IG1 SYSTEM FUEL PUMP SYSTEM A/C COMPRESSOR RELAY SYSTEM IGNITION CIRCUIT SYSTEM OIL PRESSURE SWITCH SYSTEM A/C SWITCH SYSTEM POWER STEERING FLUID PRESSURE SWITCH SYSTEM. FAN CONTROL RELAY SYSTEM DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT THE ENGINE-ECU INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE THROTTLE BODY (THROTTLE VALVE AREA) CLEANING FUEL PRESSURE TEST FUEL PUMP CONNECTOR DISCONNECTION (HOW TO REDUCE PRESSURIZED FUEL PRESSURE) FUEL PUMP OPERATION CHECK (2016 Basic) COMPONENT LOCATION (2016 Supplement) COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK FUEL PUMP RELAY CONTINUITY CHECK THROTTLE VALVE CONTROL SERVO RELAY CONTINUITY CHECK INTAKE AIR TEMPERATURE SENSOR CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK (2016 Basic) OXYGEN SENSOR CHECK (2016 Supplement) OXYGEN SENSOR CHECK INJECTOR CHECK OIL FEEDER CONTROL VALVE CHECK THROTTLE VALVE CONTROL SERVO CHECKINJECTORTHROTTLE BODY ASSEMBLYENGINE-ECU (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS SEALANTS OR ADHESIVES SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW (2016 Basic) DIAGNOSIS FUNCTION (2016 Supplement) DIAGNOSIS FUNCTION (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0016 CRANKSHAFT/CAMSHAFT POSITION SENSOR PHASE PROBLEM CODE NO. P0047 VARIABLE GEOMETRY SOLENOID VALVE LOW CODE NO. P0048 VARIABLE GEOMETRY SOLENOID VALVE HIGH CODE NO. P0072 INTAKE AIR TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0073 INTAKE AIR TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0088 COMMON RAIL HIGH PRESSURE MALFUNCTION CODE NO. P0089 SUCTION CONTROL VALVE STUCK CODE NO. P0093 FUEL LEAK PROBLEM CODE NO. P0101 AIR FLOW SENSOR PERFORMANCE CODE NO. P0102 AIR FLOW SENSOR CIRCUIT LOW INPUT CODE NO. P0103 AIR FLOW SENSOR CIRCUIT HIGH INPUT CODE NO. P0106 MANIFOLD ABSOLUTE PRESSURE SENSOR RANGE/PERFORMANCE PROBLEM CODE NO. P0107 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P0108 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0112 EGR GAS TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0113 EGR GAS TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0117 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0118 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0122 THROTTLE POSITION SENSOR CIRCUIT LOW INPUT CODE NO. P0123 THROTTLE POSITION SENSOR CIRCUIT HIGH INPUT CODE NO. P0182 FUEL TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0183 FUEL TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0191 RAIL PRESSURE SENSOR RANGE/PERFORMANCE PROBLEM CODE NO. P0192 RAIL PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P0193 RAIL PRESSURE SENSOR CIRCUIT HIGH INPUT (2016 Basic) CODE NO. P0201 NO.1 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0201 NO.1 INJECTOR CIRCUIT MALFUNCTION<EURO5> (2016 Basic) CODE NO. P0202 NO.2 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0202 NO.2 INJECTOR CIRCUIT MALFUNCTION<EURO5> (2016 Basic) CODE NO. P0203 NO.3 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0203 NO.3 INJECTOR CIRCUIT MALFUNCTION<EURO5> (2016 Basic) CODE NO. P0204 NO.4 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0204 NO.4 INJECTOR CIRCUIT MALFUNCTION<EURO5> CODE NO. P0217 ENGINE COOLANT OVER TEMPERATURE CODE NO. P0219 ENGINE OVERSPEED CONDITION CODE NO. P0299 TURBOCHARGER UNDER BOOST CODE NO. P0301 NO. 1 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) CODE NO. P0302 NO. 2 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) CODE NO. P0303 NO. 3 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) CODE NO. P0304 NO. 4 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM CODE NO. P0336 CRANK ANGLE SENSOR RANGE/PERFORMANCE PROBLEM CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM CODE NO. P0341 CAMSHAFT POSITION SENSOR RANGE/PERFORMANCE PROBLEM CODE NO. P0381 GLOW PLUG OPEN/SHORT MALFUNCTION CODE NO. P0403 EGR VALVE DC MOTOR MALFUNCTION CODE NO. P0405 EGR VALVE POSITION SENSOR CIRCUIT LOW INPUT CODE NO. P0406 EGR VALVE POSITION SENSOR CIRCUIT HIGH INPUT CODE NO. P0502 VEHICLE SPEED SENSOR LOW INPUT CODE NO. P0513 IMMOBILIZER MALFUNCTION CODE NO. P0515 BATTERY TEMPERATURE SENSOR SYSTEM CODE NO. P0537 A/C EVAPORATOR TEMPERATURE SENSOR CIRCUIT LOW INPUT CODE NO. P0538 A/C EVAPORATOR TEMPERATURE SENSOR CIRCUIT HIGH INPUT CODE NO. P0551 POWER STEERING FLUID PRESSURE SWITCH SYSTEM CODE NO. P0602 VARIANT CODING SYSTEM CODE NO. P0603 EEP ROM MALFUNCTION CODE NO. P0604 RANDOM ACCESS MEMORY (RAM) MALFUNCTION CODE NO. P0605 READ ONLY MEMORY (FLASH ROM) MALFUNCTION CODE NO. P0606 ENGINE-ECU (MAIN CPU) MALFUNCTION CODE NO. P0607 ENGINE-ECU (SUB CPU) MALFUNCTION CODE NO. P0620 ALTERNATOR CONTROL CIRCUIT CODE NO. P0622 ALTERNATOR FR TERMINAL SYSTEM CODE NO. P0628 SUCTION CONTROL VALVE OPEN CODE NO. P0629 SUCTION CONTROL VALVE BATTERY SHORT CODE NO. P0630 CHASSIS NUMBER NOT PROGRAMMED CODE NO. P0638 THROTTLE VALVE CONTROL SERVO STUCK CODE NO. P0642 ANALOG SENSOR REFERENCE VOLTAGE NO.1 TOO LOW CODE NO. P0643 ANALOG SENSOR REFERENCE VOLTAGE NO.1 TOO HIGH CODE NO. P064C GLOW CONTROL UNIT MALFUNCTION CODE NO. P0652 ANALOG SENSOR REFERENCE VOLTAGE NO.2 TOO LOW CODE NO. P0653 ANALOG SENSOR REFERENCE VOLTAGE NO.2 TOO HIGH CODE NO. P0683 GLOW CONTROL UNIT COMMUNICATION ABNORMALITY CODE NO. P1020 OIL FEEDER CONTROL VALVE SYSTEM CODE NO. P1203 CAPACITOR INSUFFICIENT CHARGING CODE NO. P1204 CAPACITOR EXCESSIVE CHARGING (2016 Basic) CODE NO. P1272 PRESSURE LIMITER MALFUNCTION (2016 Supplement) CODE NO. P1272 PRESSURE LIMITER MALFUNCTION<EURO5> (2016 Basic) CODE NO. P1273 SUPPLY PUMP INSUFFICIENT FLOW (2016 Supplement) CODE NO. P1273 SUPPLY PUMP INSUFFICIENT FLOW<EURO5> CODE NO. P1274 SUPPLY PUMP PROTECTION CODE NO. P1275 SUPPLY PUMP EXCHANGE CODE NO. P1298 VARIABLE GEOMETRY TURBOCHARGER CONTROL SYSTEM MALFUNCTION (HIGH PRESSURE) CODE NO. P1299 VARIABLE GEOMETRY TURBOCHARGER CONTROL SYSTEM MALFUNCTION (LOW PRESSURE) CODE NO. P1608 BATTERY CURRENT SENSOR SYSTEM CODE NO. P1625 INJECTION QUANTITY COMPENSATION VALUE ERROR CODE NO. P1626 INJECTION QUANTITY COMPENSATION VALUE ERROR NOT CODING CODE NO. P2118 THROTTLE VALVE CONTROL DC MOTOR CURRENT MALFUNCTION CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT CODE NO. P2124 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT INTERMITTENT CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM (2016 Basic) CODE NO. P2146 INJECTOR COMMON 1 (CYLINDER NO.1 AND NO.4) CIRCUIT OPEN (2016 Supplement) CODE NO. P2146 INJECTOR COMMON 1 (CYLINDER NO.1 AND NO.4) CIRCUIT OPEN<EURO5> (2016 Basic) CODE NO. P2147 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT EARTH SHORT (2016 Supplement) CODE NO. P2147 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT EARTH SHORT<EURO5> (2016 Basic) CODE NO. P2148 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT BATTERY SHORT (2016 Supplement) CODE NO. P2148 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT BATTERY SHORT<EURO5> (2016 Basic) CODE NO. P2149 INJECTOR COMMON 2 (CYLINDER NO.2 AND NO.3) CIRCUIT OPEN (2016 Supplement) CODE NO. P2149 INJECTOR COMMON 2 (CYLINDER NO.2 AND NO.3) CIRCUIT OPEN<EURO5> CODE NO. P2228 BAROMETRIC PRESSURE SENSOR CIRCUIT LOW INPUT CODE NO. P2229 BAROMETRIC PRESSURE SENSOR CIRCUIT HIGH INPUT CODE NO. P2413 EGR SYSTEM PERFORMANCE CODE NO. P2426 EXHAUST GAS RECIRCULATION COOLING VALVE CONTROL CIRCUIT (LOW) CODE NO. P2427 EXHAUST GAS RECIRCULATION COOLING VALVE CONTROL CIRCUIT (HIGH) CODE NO. U0114 AWC TIME-OUT CODE NO. U1005 CORNER SENSOR-ECU TIME-OUT CODE NO. U1073 BUS OFF CODE NO. U1101 A/T-ECU TIME-OUT CODE NO. U1102 ASTC-ECU TIME-OUT CODE NO. U1108 COMBINATION METER TIME-OUT CODE NO. U1117 ETACS-ECU (IMMOBILIZER-ECU) TIME-OUT (2016 Supplement) CODE NO. P0003 SUCTION CONTROL VALVE OPEN<EURO5> (2016 Supplement) CODE NO. P0004 SUCTION CONTROL VALVE BATTERY SHORT<EURO5> (2016 Supplement) CODE NO. P0401 EGR FLOW INSUFFICIENT<EURO5> (2016 Supplement) CODE NO. P0402 EGR FLOW EXCESSIVE<EURO5> (2016 Supplement) CODE NO. P0420 CATALYST MALFUNCTION<EURO5> (2016 Supplement) CODE NO. P0427 NO. 2 EXHAUST GAS TEMPERATURE SENSOR (CATALYST TEMPERATURE) CIRCUIT LOW INPUT<EURO5> (2016 Supplement) CODE NO. P0428 NO. 2 EXHAUST GAS TEMPERATURE SENSOR (CATALYST TEMPERATURE) CIRCUIT HIGH INPUT<EURO5> (2016 Supplement) CODE NO. P0489 EGR VALVE POSITION SENSOR CIRCUIT LOW INPUT<EURO5> (2016 Supplement) CODE NO. P0490 EGR VALVE POSITION SENSOR CIRCUIT HIGH INPUT<EURO5> (2016 Supplement) CODE NO. P0500 VEHICLE SPEED SIGNAL SYSTEM<EURO5> (2016 Supplement) CODE NO. P0545 NO. 1 EXHAUST GAS TEMPERATURE SENSOR CIRCUIT LOW INPUT<EURO5> (2016 Supplement) CODE NO. P0546 NO. 1 EXHAUST GAS TEMPERATURE SENSOR CIRCUIT HIGH INPUT<EURO5> (2016 Supplement) CODE NO. P062F EEPROM MALFUNCTION<EURO5> (2016 Supplement) CODE NO. P0712 TRANSMISSION FLUID TEMPERATURE SENSOR LOW<M/T> (2016 Supplement) CODE NO. P0713 TRANSMISSION FLUID TEMPERATURE SENSOR HIGH<M/T> (2016 Supplement) CODE NO. P1276 FUEL FILTER EXCHANGE<Except AUSTRALIA and NEW ZEALAND> (2016 Supplement) CODE NO. P1277 FUEL FILTER FREEZE<Except AUSTRALIA and NEW ZEALAND> (2016 Supplement) CODE NO. P1427 NO. 3 EXHAUST GAS TEMPERATURE SENSOR (DPF TEMPERATURE) CIRCUIT LOW INPUT<EURO5> (2016 Supplement) CODE NO. P1428 NO. 3 EXHAUST GAS TEMPERATURE SENSOR (DPF TEMPERATURE) CIRCUIT HIGH INPUT<EURO5> (2016 Supplement) CODE NO. P1497 DPF SYSTEM MALFUNCTION<EURO5> (2016 Supplement) CODE NO. P1498 EXCESSIVE PM ACCUMULATED IN DPF<EURO5> (2016 Supplement) CODE NO. P1499 ABNORMALLY HIGH DPF TEMPERATURE<EURO5> (2016 Supplement) CODE NO. P2150 INJECTOR COMMON 2(CYLINDER NO. 2 AND NO. 3) CIRCUIT EARTH SHORT<EURO5> (2016 Supplement) CODE NO. P2151 INJECTOR COMMON 2(CYLINDER NO. 2 AND NO. 3) CIRCUIT BATTERY SHORT<EURO5> (2016 Supplement) CODE NO. P244A DIESEL PARTICULATE FILTER DIFFERENTIAL PRESSURE TOO LOW<EURO5> (2016 Supplement) CODE NO. P2453 EXHAUST DIFFERENTIAL PRESSURE SENSOR PERFORMANCE<EURO5> (2016 Supplement) CODE NO. P2454 EXHAUST DIFFERENTIAL PRESSURE SENSOR CIRCUIT LOW INPUT<EURO5> (2016 Supplement) CODE NO. P2455 EXHAUST DIFFERENTIAL PRESSURE SENSOR CIRCUIT HIGH INPUT<EURO5> (2016 Supplement) CODE NO. P2463 NO CHANCE OF FORCIBLE REGENERATION OF DPF<EURO5> (2016 Supplement) CODE NO. P252F ENGINE OIL LEVEL MALFUNCTION<EURO5> (2016 Basic) SYMPTOM CHART (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT (2016 Basic) THE STARTER IS IMPOSSIBLE TO OPERATE (2016 Supplement) THE STARTER IS IMPOSSIBLE TO OPERATE<M/T> (2016 Basic) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) (2016 Supplement) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION)<EURO5> (2016 Basic) IMPROPER STARTING (LONG TIME TO START) (2016 Supplement) IMPROPER STARTING (LONG TIME TO START)<EURO5> (2016 Basic) IMPROPER IDLING (2016 Supplement) IMPROPER IDLING<EURO5> (2016 Basic) THE ENGINE STALLS WHEN DECELERATING (2016 Supplement) THE ENGINE STALLS WHEN DECELERATING<EURO5> (2016 Basic) POOR ACCELERATION (2016 Supplement) POOR ACCELERATION<EURO5> (2016 Basic) A LARGE AMOUNT OF FUEL CONSUMPTION (2016 Supplement) A LARGE AMOUNT OF FUEL CONSUMPTION<EURO5> (2016 Basic) KNOCKING, ABNORMAL NOISE (2016 Supplement) KNOCKING, ABNORMAL NOISE<EURO5> WHITE SMOKE (2016 Basic) BLACK SMOKE, STATE OF EXHAUST GAS PURIFICATION DETERIORATED (2016 Supplement) BLACK SMOKE, STATE OF EXHAUST GAS PURIFICATION DETERIORATED<EURO5> BATTERY RUNDOWN OVERHEATING (2016 Basic) ENGINE-ECU POWER SUPPLY SYSTEM (2016 Supplement) ENGINE-ECU POWER SUPPLY SYSTEM ENGINE-ECU BATTERY BACK-UP SYSTEM A/C COMPRESSOR RELAY SYSTEM CONDENSER FAN RELAY SYSTEM ENGINE OIL PRESSURE SWITCH SYSTEM WATER LEVEL SWITCH SYSTEM (2016 Basic) A/C SWITCH SYSTEM (2016 Supplement) A/C SWITCH SYSTEM<Cooler, Manual A/C> POWER STEERING FLUID PRESSURE SWITCH SYSTEM (2016 Supplement) BLOWER SWITCH SYSTEM<Cooler, Manual A/C> (2016 Supplement) PTC HEATER RELAY SYSTEM<Vehicles with PTC heater> (2016 Supplement) THE DPF REGENERATION INTERVAL IS SHORT (2016 Basic) DATA LIST REFERENCE TABLE (2016 Supplement) DATA LIST REFERENCE TABLE (2016 Basic) ACTUATOR TEST REFERENCE TABLE (2016 Supplement) ACTUATOR TEST REFERENCE TABLE (2016 Basic) CHECK AT THE ENGINE-ECU TERMINALS (2016 Supplement) CHECK AT THE ENGINE-ECU TERMINALS INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE EVACUATION OF WATER FROM FUEL FILTER FUEL LINE AIR-BLEEDING FUEL FILTER CARTRIDGE REPLACEMENT FUEL LINE LEAK CHECK (2016 Basic) COMPONENT LOCATION (2016 Supplement) COMPONENT LOCATION ENGINE CONTROL RELAY CONTINUITY CHECK ENGINE COOLANT TEMPERATURE SENSOR CHECK INJECTOR CHECK INTAKE AIR TEMPERATURE SENSOR NO.1 CHECK SUCTION CONTROL VALVE CHECK FUEL TEMPERATURE SENSOR CHECK COMMON RAIL CHECK THROTTLE VALVE CONTROL SERVO CHECK OIL FEEDER CONTROL VALVE CHECKFUEL INJECTORCOMMON RAILFUEL INJECTION PUMPSUCTION CONTROL VALVETHROTTLE BODY ASSEMBLYCAMSHAFT POSITION SENSOR AND CRANK ANGLE SENSORENGINE-ECU (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SPECIAL TOOL(S)ON-VEHICLE SERVICE FUEL TANK INSPECTION FUEL DRAINING FUEL GAUGE UNIT CHECK FUEL PUMP (MODULE) REPLACEMENT<4G6, 6B3> FUEL GAUGE UNIT REPLACEMENT<4N1> (2016 Supplement) FUEL FILTER INSPECTION<4N1, 4D5>FUEL TANK FUEL TANK REMOVAL AND INSTALLATION FUEL TANK DISASSEMBLY AND REASSEMBLY FUEL PUMP (MODULE) DISASSEMBLY AND REASSEMBLY<4G6, 6B3> (2016 Basic) FUEL GAUGE UNIT DISASSEMBLY AND REASSEMBLY<4N1> (2016 Supplement) FUEL GAUGE UNIT DISASSEMBLY AND REASSEMBLY<4N1>FUEL FILLER NECKFUEL FILTER<4N1> (2016 Basic) FUEL FILTER REMOVAL AND INSTALLATION (2016 Supplement) FUEL FILTER REMOVAL AND INSTALLATION FUEL FILTER INSPECTIONFUEL COOLER<4N1> (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) SEALANTS OR ADHESIVES (2016 Supplement) SPECIAL TOOLSTROUBLESHOOTING (2016 Supplement) DIAGNOSIS TROUBLESHOOTING FLOW (2016 Supplement) DIAGNOSIS FUNCTION (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES (2016 Supplement) CODE NO. P0016 CRANKSHAFT/CAMSHAFT POSITION SENSOR PHASE PROBLEM (2016 Supplement) CODE NO. P0088 COMMON RAIL HIGH PRESSURE MALFUNCTION (2016 Supplement) CODE NO. P0089 SUCTION CONTROL VALVE STUCK (2016 Supplement) CODE NO. P0093 FUEL LEAK PROBLEM (2016 Supplement) CODE NO. P0106 MANIFOLD ABSOLUTE PRESSURE SENSOR RANGE/PERFORMANCE PROBLEM (2016 Supplement) CODE NO. P0107 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0108 MANIFOLD ABSOLUTE PRESSURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0112 NO.2 INTAKE AIR TEMPERATURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0113 NO.2 INTAKE AIR TEMPERATURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0117 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0118 ENGINE COOLANT TEMPERATURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0122 THROTTLE POSITION SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0123 THROTTLE POSITION SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0182 FUEL TEMPERATURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0183 FUEL TEMPERATURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0191 RAIL PRESSURE SENSOR RANGE/PERFORMANCE PROBLEM (2016 Supplement) CODE NO. P0192 RAIL PRESSURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0193 RAIL PRESSURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0201 NO.1 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0202 NO.2 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0203 NO.3 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0204 NO.4 INJECTOR CIRCUIT MALFUNCTION (2016 Supplement) CODE NO. P0217 ENGINE COOLANT OVER TEMPERATURE (2016 Supplement) CODE NO. P0219 ENGINE OVERSPEED CONDITION (2016 Supplement) CODE NO. P0234 TURBOCHARGER OVERBOOST CONDITION (2016 Supplement) CODE NO. P0299 TURBOCHARGER UNDER BOOST (2016 Supplement) CODE NO. P0301 NO. 1 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) (2016 Supplement) CODE NO. P0302 NO. 2 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) (2016 Supplement) CODE NO. P0303 NO. 3 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) (2016 Supplement) CODE NO. P0304 NO. 4 CYLINDER INJECTOR MALFUNCTION (NO INJECTION) (2016 Supplement) CODE NO. P0335 CRANK ANGLE SENSOR SYSTEM (2016 Supplement) CODE NO. P0336 CRANK ANGLE SENSOR RANGE/PERFORMANCE PROBLEM (2016 Supplement) CODE NO. P0340 CAMSHAFT POSITION SENSOR SYSTEM (2016 Supplement) CODE NO. P0341 CAMSHAFT POSITION SENSOR RANGE/PERFORMANCE PROBLEM (2016 Supplement) CODE NO. P0403 EGR VALVE DC MOTOR MALFUNCTION (2016 Supplement) CODE NO. P0405 EGR VALVE POSITION SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0406 EGR VALVE POSITION SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0502 VEHICLE SPEED SENSOR LOW INPUT<M/T> (2016 Supplement) CODE NO. P0502 VEHICLE SPEED SENSOR LOW INPUT<A/T> (2016 Supplement) CODE NO. P0513 IMMOBILIZER MALFUNCTION (2016 Supplement) CODE NO. P0537 A/C EVAPORATOR TEMPERATURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P0538 A/C EVAPORATOR TEMPERATURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P0551 POWER STEERING FLUID PRESSURE SWITCH SYSTEM (2016 Supplement) CODE NO. P0562 BATTERY VOLTAGE TOO LOW (2016 Supplement) CODE NO. P0602 VARIANT CODING SYSTEM (2016 Supplement) CODE NO. P0603 EEP ROM MALFUNCTION (2016 Supplement) CODE NO. P0604 RANDOM ACCESS MEMORY (RAM) MALFUNCTION (2016 Supplement) CODE NO. P0605 READ ONLY MEMORY (FLASH ROM) MALFUNCTION (2016 Supplement) CODE NO. P0606 ENGINE-ECU (MAIN CPU) MALFUNCTION (2016 Supplement) CODE NO. P0607 ENGINE-ECU (SUB CPU) MALFUNCTION (2016 Supplement) CODE NO. P0628 SUCTION CONTROL VALVE OPEN (2016 Supplement) CODE NO. P0629 SUCTION CONTROL VALVE BATTERY SHORT (2016 Supplement) CODE NO. P0630 CHASSIS NUMBER NOT PROGRAMMED (2016 Supplement) CODE NO. P0638 THROTTLE VALVE CONTROL SERVO STUCK (2016 Supplement) CODE NO. P0642 ANALOG SENSOR REFERENCE VOLTAGE NO.1 TOO LOW (2016 Supplement) CODE NO. P0643 ANALOG SENSOR REFERENCE VOLTAGE NO.1 TOO HIGH (2016 Supplement) CODE NO. P0652 ANALOG SENSOR REFERENCE VOLTAGE NO.2 TOO LOW (2016 Supplement) CODE NO. P0653 ANALOG SENSOR REFERENCE VOLTAGE NO.2 TOO HIGH (2016 Supplement) CODE NO. P1203 CAPACITOR INSUFFICIENT CHARGING (2016 Supplement) CODE NO. P1204 CAPACITOR EXCESSIVE CHARGING (2016 Supplement) CODE NO. P1272 PRESSURE LIMITER MALFUNCTION (2016 Supplement) CODE NO. P1273 SUPPLY PUMP INSUFFICIENT FLOW (2016 Supplement) CODE NO. P1274 SUPPLY PUMP PROTECTION (2016 Supplement) CODE NO. P1275 SUPPLY PUMP EXCHANGE (2016 Supplement) CODE NO. P1276 FUEL FILTER EXCHANGE (2016 Supplement) CODE NO. P1277 FUEL FILTER FREEZE (2016 Supplement) CODE NO. P1625 INJECTION QUANTITY COMPENSATION VALUE ERROR (2016 Supplement) CODE NO. P1626 INJECTION QUANTITY COMPENSATION VALUE ERROR NOT CODING (2016 Supplement) CODE NO. P2118 THROTTLE VALVE CONTROL DC MOTOR CURRENT MALFUNCTION (2016 Supplement) CODE NO. P2122 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P2123 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P2124 ACCELERATOR PEDAL POSITION SENSOR (MAIN) CIRCUIT HIGH INPUT INTERMITTENT (2016 Supplement) CODE NO. P2127 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P2128 ACCELERATOR PEDAL POSITION SENSOR (SUB) CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P2138 ACCELERATOR PEDAL POSITION SENSOR (MAIN AND SUB) RANGE/PERFORMANCE PROBLEM (2016 Supplement) CODE NO. P2146 INJECTOR COMMON 1 (CYLINDER NO.1 AND NO.4) CIRCUIT OPEN (2016 Supplement) CODE NO. P2147 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT EARTH SHORT (2016 Supplement) CODE NO. P2148 INJECTOR COMMON 1 (CYLINDER NO. 1 AND NO. 4) CIRCUIT BATTERY SHORT (2016 Supplement) CODE NO. P2149 INJECTOR COMMON 2 (CYLINDER NO.2 AND NO.3) CIRCUIT OPEN (2016 Supplement) CODE NO. P2150 INJECTOR COMMON 2(CYLINDER NO. 2 AND NO. 3) CIRCUIT EARTH SHORT (2016 Supplement) CODE NO. P2151 INJECTOR COMMON 2(CYLINDER NO. 2 AND NO. 3) CIRCUIT BATTERY SHORT (2016 Supplement) CODE NO. P2228 BAROMETRIC PRESSURE SENSOR CIRCUIT LOW INPUT (2016 Supplement) CODE NO. P2229 BAROMETRIC PRESSURE SENSOR CIRCUIT HIGH INPUT (2016 Supplement) CODE NO. P2413 EGR SYSTEM PERFORMANCE (2016 Supplement) CODE NO. P252F ENGINE OIL LEVEL MALFUNCTION (2016 Supplement) CODE NO. U0114 AWC TIME-OUT (2016 Supplement) CODE NO. U1073 BUS OFF (2016 Supplement) CODE NO. U1101 A/T-ECU TIME-OUT<A/T> (2016 Supplement) CODE NO. U1102 ASTC-ECU TIME-OUT<Vehicles with ASTC> (2016 Supplement) CODE NO. U1108 COMBINATION METER TIME-OUT (2016 Supplement) CODE NO. U1117 ETACS-ECU (IMMOBILIZER-ECU) TIME-OUT (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2016 Supplement) COMMUNICATION WITH ENGINE-ECU IS NOT POSSIBLE (2016 Supplement) THE ENGINE WARNING LAMP DOES NOT ILLUMINATE RIGHT AFTER THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION (2016 Supplement) THE ENGINE WARNING LAMP REMAINS ILLUMINATING AND NEVER GOES OUT (2016 Supplement) THE STARTER IS IMPOSSIBLE TO OPERATE<M/T> (2016 Supplement) THE STARTER IS IMPOSSIBLE TO OPERATE<A/T> (2016 Supplement) STARTING IMPOSSIBLE (STARTER OPERATIVE BUT NO INITIAL COMBUSTION) (2016 Supplement) IMPROPER STARTING (LONG TIME TO START) (2016 Supplement) IMPROPER IDLING (2016 Supplement) THE ENGINE STALLS WHEN DECELERATING (2016 Supplement) POOR ACCELERATION (2016 Supplement) A LARGE AMOUNT OF FUEL CONSUMPTION (2016 Supplement) KNOCKING, ABNORMAL NOISE (2016 Supplement) WHITE SMOKE (2016 Supplement) BLACK SMOKE, STATE OF EXHAUST GAS PURIFICATION DETERIORATED (2016 Supplement) BATTERY RUNDOWN (2016 Supplement) OVERHEATING (2016 Supplement) ENGINE-ECU POWER SUPPLY SYSTEM (2016 Supplement) ENGINE-ECU BATTERY BACK-UP SYSTEM (2016 Supplement) A/C COMPRESSOR RELAY SYSTEM (2016 Supplement) CONDENSER FAN RELAY SYSTEM<A/C condenser fan> (2016 Supplement) ENGINE OIL PRESSURE SWITCH SYSTEM (2016 Supplement) WATER LEVEL SWITCH SYSTEM (2016 Supplement) GLOW SYSTEM (2016 Supplement) A/C SWITCH SYSTEM<Cooler, Manual A/C> (2016 Supplement) A/C SWITCH SYSTEM<Automatic A/C> (2016 Supplement) BLOWER SWITCH SYSTEM<Cooler, Manual A/C> (2016 Supplement) POWER STEERING FLUID PRESSURE SWITCH SYSTEM (2016 Supplement) DATA LIST REFERENCE TABLE (2016 Supplement) ACTUATOR TEST REFERENCE TABLE (2016 Supplement) CHECK AT THE ENGINE-ECU TERMINALS (2016 Supplement) INSPECTION PROCEDURE USING AN OSCILLOSCOPEON-VEHICLE SERVICE (2016 Supplement) EVACUATION OF WATER FROM FUEL FILTER (2016 Supplement) FUEL LINE AIR-BLEEDING (2016 Supplement) FUEL FILTER CARTRIDGE REPLACEMENT (2016 Supplement) FUEL LINE LEAK CHECK (2016 Supplement) COMPONENT LOCATION (2016 Supplement) ENGINE CONTROL RELAY CONTINUITY CHECK (2016 Supplement) ENGINE COOLANT TEMPERATURE SENSOR CHECK (2016 Supplement) INJECTOR CHECK (2016 Supplement) INTAKE AIR TEMPERATURE SENSOR NO.2 CHECK (2016 Supplement) SUCTION CONTROL VALVE CHECK (2016 Supplement) FUEL TEMPERATURE SENSOR CHECK (2016 Supplement) COMMON RAIL CHECK (2016 Supplement) THROTTLE VALVE CONTROL SERVO CHECKFUEL INJECTORCOMMON RAIL AND SUPPLY PUMPSUCTION CONTROL VALVETHROTTLE BODY ASSEMBLYCAMSHAFT POSITION SENSOR AND CRANK ANGLE SENSORENGINE-ECU (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S) (2016 Basic) LUBRICANT(S) (2016 Supplement) LUBRICANT(S) (2016 Basic) SEALANT(S) OR ADHESIVE(S) (2016 Supplement) SEALANT(S) OR ADHESIVE(S) (2016 Basic) SPECIAL TOOL(S) (2016 Supplement) SPECIAL TOOL(S)ON-VEHICLE SERVICE ENGINE COOLANT LEAK CHECK (2016 Basic) RADIATOR CAP OPENING PRESSURE CHECK (2016 Supplement) RADIATOR CAP OPENING PRESSURE CHECK<6B3, 4D5> (2016 Basic) ENGINE COOLANT CHANGE (2016 Supplement) ENGINE COOLANT CHANGE<4D5> (2016 Basic) ENGINE COOLANT CHECK (2016 Supplement) ENGINE COOLANT CHECK<4D5> WATER PUMP COOLANT LEAK CHECKRADIATOR FAN (2016 Basic) RADIATOR FAN REMOVAL AND INSTALLATION<4G6> (2016 Basic) RADIATOR FAN REMOVAL AND INSTALLATION<6B3> (2016 Basic) RADIATOR FAN REMOVAL AND INSTALLATION<4N1> (2016 Supplement) RADIATOR FAN REMOVAL AND INSTALLATION<4D5> RADIATOR FAN INSPECTIONTHERMOSTAT (2016 Basic) THERMOSTAT REMOVAL AND INSTALLATION<4G6> (2016 Basic) THERMOSTAT REMOVAL AND INSTALLATION<6B3> (2016 Basic) THERMOSTAT REMOVAL AND INSTALLATION<4N1> (2016 Supplement) THERMOSTAT REMOVAL AND INSTALLATION<4D5> (2016 Basic) THERMOSTAT INSPECTION (2016 Supplement) THERMOSTAT INSPECTION<4D5>WATER PUMP (2016 Basic) WATER PUMP REMOVAL AND INSTALLATION<4G6> (2016 Basic) WATER PUMP REMOVAL AND INSTALLATION<6B3> (2016 Basic) WATER PUMP REMOVAL AND INSTALLATION<4N1> (2016 Supplement) WATER PUMP REMOVAL AND INSTALLATION<4D5>WATER HOSE AND WATER PIPE (2016 Basic) WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<4G6> (2016 Basic) WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<6B3> (2016 Basic) WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<4N1> (2016 Supplement) WATER HOSE AND WATER PIPE REMOVAL AND INSTALLATION<4D5> WATER HOSE AND WATER PIPE INSPECTIONRADIATOR (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) (2016 Basic) SPECIAL TOOL(S) (2016 Supplement) SPECIAL TOOL(S)ON-VEHICLE SERVICE (2016 Basic) TURBOCHARGER BOOST PRESSURE CHECK<4N1> (2016 Supplement) TURBOCHARGER BOOST PRESSURE CHECK<4D5> VARIABLE GEOMETRY ACTUATOR CHECK<4N1> VARIABLE GEOMETRY SOLENOID VALVE CHECK<4N1> (2016 Supplement) TURBOCHARGER WASTE GATE ACTUATOR CHECK<4D5>AIR CLEANER (2016 Basic) AIR CLEANER REMOVAL AND INSTALLATION (2016 Supplement) AIR CLEANER REMOVAL AND INSTALLATION<4D5>INTERCOOLER (2016 Basic) INTERCOOLER REMOVAL AND INSTALLATION<4N1> (2016 Supplement) INTERCOOLER REMOVAL AND INSTALLATION<4N1, 4D5>INLET UPPER MANIFOLD<6B3>INLET MANIFOLD (2016 Basic) INLET MANIFOLD REMOVAL AND INSTALLATION<4G6> (2016 Basic) INLET MANIFOLD REMOVAL AND INSTALLATION<6B3> (2016 Basic) INLET MANIFOLD REMOVAL AND INSTALLATION<4N1> (2016 Supplement) INLET MANIFOLD REMOVAL AND INSTALLATION<4D5> (2016 Basic) INLET MANIFOLD INSPECTION (2016 Supplement) INLET MANIFOLD INSPECTION<4D5>TURBOCHARGER ASSEMBLY<4N1>EXHAUST MANIFOLD (2016 Basic) EXHAUST MANIFOLD REMOVAL AND INSTALLATION<4G6> (2016 Basic) EXHAUST MANIFOLD REMOVAL AND INSTALLATION<6B3> (2016 Basic) EXHAUST MANIFOLD REMOVAL AND INSTALLATION<4N1> (2016 Supplement) EXHAUST MANIFOLD REMOVAL AND INSTALLATION<6B3> EXHAUST MANIFOLD INSPECTIONEXHAUST PIPE AND MAIN MUFFLER (2016 Basic) EXHAUST PIPE AND MAIN MUFFLER REMOVAL AND INSTALLATION (2016 Supplement) EXHAUST PIPE AND MAIN MUFFLER REMOVAL AND INSTALLATION<6B3, 4N1, 4D5>EXHAUST MANIFOLD AND TURBOCHARGERCHARGING SYSTEM (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE ALTERNATOR OUTPUT LINE VOLTAGE DROP TEST OUTPUT CURRENT TEST REGULATED VOLTAGE TEST WAVE PATTERN CHECK USING AN OSCILLOSCOPEALTERNATOR ASSEMBLYSTARTING SYSTEM (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S)ON-VEHICLE SERVICESTARTER MOTOR ASSEMBLY
(2016 Basic) STARTER MOTOR ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) STARTER MOTOR ASSEMBLY REMOVAL AND INSTALLATION<4D5> (2016 Basic) STARTER MOTOR ASSEMBLY INSPECTION (2016 Supplement) STARTER MOTOR ASSEMBLY INSPECTION<4D5> STARTER MOTOR ASSEMBLY DISASSEMBLY AND REASSEMBLY<4G6> STARTER MOTOR ASSEMBLY INSPECTION (DISASSEMBLY AND ASSEMBLY)<4G6>IGNITION SYSTEM<4G6, 6B3> GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE IGNITION COIL CHECK SPARK PLUG CHECK, CLEANING AND REPLACEMENT CAMSHAFT POSITION SENSOR CHECK CRANK ANGLE SENSOR CHECK DETONATION SENSOR CHECKIGNITION COILCAMSHAFT POSITION SENSOR CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<4G6> CAMSHAFT POSITION SENSOR REMOVAL AND INSTALLATION<6B3>CRANK ANGLE SENSORDETONATION SENSORGLOW SYSTEM (2016 Basic) GENERAL INFORMATION<4N1> (2016 Supplement) GENERAL INFORMATION<4N1, 4D5> (2016 Basic) SERVICE SPECIFICATION(S)<4N1> (2016 Supplement) SERVICE SPECIFICATION(S)<4N1, 4D5> (2016 Supplement) SPECIAL TOOL(S)<4N1, 4D5>ON-VEHICLE SERVICE (2016 Basic) GLOW PLUG CHECK<4N1> (2016 Supplement) GLOW PLUG CHECK<4D5> (2016 Basic) CHECK THE ENGINE ECU TERMINALS<4N1> (2016 Supplement) CHECK THE ENGINE ECU TERMINALS<4D5> (2016 Supplement) SELF-REGULATING GLOW SYSTEM CHECK<4D5> (2016 Supplement) GLOW PLUG RELAY CHECK<4D5>GLOW PLUG (2016 Basic) GLOW PLUG REMOVAL AND INSTALLATION<4N1> (2016 Supplement) GLOW PLUG REMOVAL AND INSTALLATION<4D5>GLOW CONTROL UNIT (2016 Basic) GLOW CONTROL UNIT REMOVAL AND INSTALLATION<4N1> (2016 Supplement) GLOW CONTROL UNIT REMOVAL AND INSTALLATION<4N1>GLOW PLUG RELAY<4D5>ENGINE CONTROLCRUISE CONTROL<PETROL ENGINE> (2016 Basic) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION<6B3> (2016 Basic) SPECIAL TOOL(S) (2017 Supplement) SPECIAL TOOL(S)<6B3>TROUBLESHOOTING (2016 Basic) DIAGNOSIS CODE CHART (2017 Supplement) DIAGNOSIS CODE CHART<6B3>DIAGNOSIS CODE PROCEDURES CODE NO. P1564: Cruise Control Switch System CODE NO. P1571: Stop Lamp Switch system CODE NO. P1574: Engine-ECU and its related components (2017 Supplement) CODE NO. P1565: ACC TARGET TORQUE<Vehicles with ACC/FCM (6B3)> (2017 Supplement) CODE NO. P1566: ENGINE-ACC CONTROL STATE MISMATCH<Vehicles with ACC/FCM (6B3)> SYMPTOM CHARTSYMPTOM PROCEDURES WHEN BRAKE PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED WHEN SELECTOR LEVER IS MOVED TO "N" POSITION, CRUISE CONTROL IS NOT CANCELLED WHEN "CANCEL" SWITCH IS TURNED ON, CRUISE CONTROL IS NOT CANCELLED CRUISE CONTROL CANNOT BE SET. HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED CRUISE CONTROL INDICATOR LIGHT INSIDE COMBINATION METER DOES NOT ILLUMINATE (HOWEVER, CRUISE CONTROL IS NORMAL). When the cruise control switch is operated, the system is not turned on. DATA LIST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICECRUISE CONTROL SWITCHCRUISE CONTROL<DIESEL ENGINE> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION<4N1> (2016 Basic) SPECIAL TOOL(S) (2017 Supplement) SPECIAL TOOL(S)<4N1>TROUBLESHOOTING (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHART (2017 Supplement) DIAGNOSIS CODE CHART<4N1>DIAGNOSIS CODE PROCEDURES (2016 Basic) CODE NO. P1564: Cruise control switch stuck on error (2016 Supplement) CODE NO. P1564: Cruise control switch stuck on error (2016 Basic) CODE NO. P1571: Brake lamp switch system (2016 Supplement) CODE NO. P1571: Brake lamp switch system (2017 Supplement) CODE NO. P1565: ACC TARGET TORQUE<Vehicles with ACC/FCM (4N1)> (2017 Supplement) CODE NO. P1566: ENGINE-ACC CONTROL STATE MISMATCH<Vehicles with ACC/FCM (4N1)> (2016 Basic) SYMPTOM CHART (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2016 Basic) WHEN BRAKE PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED (2016 Supplement) WHEN BRAKE PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED (2016 Basic) WHEN SELECTOR LEVER IS MOVED TO "N" POSITION, CRUISE CONTROL IS NOT CANCELLED (2016 Supplement) WHEN SELECTOR LEVER IS MOVED TO "N" POSITION, CRUISE CONTROL IS NOT CANCELLED (2016 Basic) WHEN "CANCEL" SWITCH IS TURNED ON, CRUISE CONTROL IS NOT CANCELLED (2016 Supplement) WHEN "CANCEL" SWITCH IS TURNED ON, CRUISE CONTROL IS NOT CANCELLED (2016 Basic) CRUISE CONTROL CANNOT BE SET. (2016 Supplement) CRUISE CONTROL CANNOT BE SET. (2016 Basic) HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED (2016 Supplement) HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED<4N1> (2016 Supplement) HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED<4D5-M/T> (2016 Supplement) HUNTING (REPEATED ACCELERATION AND DECELERATION) OCCURS AT THE SET VEHICLE SPEED<4D5-A/T> (2016 Basic) CRUISE CONTROL INDICATOR LIGHT INSIDE COMBINATION METER DOES NOT ILLUMINATE (HOWEVER, CRUISE CONTROL IS NORMAL). (2016 Supplement) CRUISE CONTROL INDICATOR LIGHT INSIDE COMBINATION METER DOES NOT ILLUMINATE (HOWEVER, CRUISE CONTROL IS NORMAL). (2016 Basic) When the cruise control switch is operated, the system is not turned on. (2016 Supplement) When the cruise control switch is operated, the system is not turned on. (2016 Supplement) WHEN CLUTCH PEDAL IS DEPRESSED, CRUISE CONTROL IS NOT CANCELLED<M/T> (2016 Supplement) SPEED LIMITER DISPLAY SCREEN INSIDE COMBINATION METER DOES NOT DISPLAY (HOWEVER, CRUISE CONTROL SYSTEM IS NORMAL).<Vehicles with speed limiter> (2016 Supplement) WHEN THE SPEED LIMITER SWITCH IS OPERATED, THE SYSTEM IS NOT TURNED ON.<Vehicles with speed limiter> (2016 Supplement) WHEN KICKDOWN IS DEPRESSED, SPEED LIMITER IS NOT CANCELLED<Vehicles with speed limiter> (2016 Basic) DATA LIST REFERENCE TABLE (2016 Supplement) DATA LIST REFERENCE TABLE (2016 Basic) CHECK AT ECU TERMINAL (2016 Supplement) CHECK AT ECU TERMINALON-VEHICLE SERVICE (2016 Basic) CRUISE CONTROL SWITCH CHECK (2016 Supplement) CRUISE CONTROL SWITCH CHECK (2016 Basic) CRUISE CONTROL SYSTEM COMPONENT CHECK (2016 Supplement) CRUISE CONTROL SYSTEM COMPONENT CHECKCRUISE CONTROL SWITCHEMISSION CONTROL <MPI> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION EMISSION CONTROL DEVICE REFERENCE TABLE SERVICE SPECIFICATION(S)VACUUM HOSECRANKCASE EMISSION CONTROL SYSTEM GENERAL INFORMATION (CRANKCASE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (CRANKCASE EMISSION CONTROL SYSTEM) POSITIVE CRANKCASE VENTILATION SYSTEM CHECK POSITIVE CRANKCASE VENTILATION (PCV) VALVE CHECKEVAPORATIVE EMISSION CONTROL SYSTEM GENERAL INFORMATION (EVAPORATIVE EMISSION CONTROL SYSTEM) COMPONENT LOCATION (EVAPORATIVE EMISSION CONTROL SYSTEM) PURGE CONTROL SYSTEM CHECK PURGE CONTROL SOLENOID VALVE CHECK CANISTER REMOVAL AND INSTALLATIONEXHAUST GAS RECIRCULATION (EGR) VALVE<6B3> GENERAL INFORMATION (EGR SYSTEM) COMPONENT LOCATION (EGR SYSTEM) EGR VALVE (STEPPER MOTOR) CHECK EXHAUST GAS RECIRCULATION (EGR) VALVE REMOVAL AND INSTALLATIONCATALYTIC CONVERTEREMISSION CONTROL <DIESEL> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S) (2016 Supplement) SPECIAL TOOL(S)VACUUM HOSEEXHAUST GAS RECIRCULATION (EGR) SYSTEM (2016 Basic) GENERAL INFORMATION (EGR SYSTEM) (2016 Supplement) GENERAL INFORMATION (EGR SYSTEM)<4D5> (2016 Basic) COMPONENT LOCATION (EGR SYSTEM) (2016 Supplement) COMPONENT LOCATION (EGR SYSTEM)<4D5> (2016 Basic) EGR VALVE (DC MOTOR) CHECK (2016 Supplement) EGR VALVE (DC MOTOR) CHECK<4D5> EGR GAS TEMPERATURE SENSOR CHECK EGR COOLER BYPASS CONTROL SYSTEM CHECK EGR COOLER BYPASS CONTROL SOLENOID VALVE CHECKEGR VALVE AND EGR COOLER (2016 Basic) EGR VALVE AND EGR COOLER REMOVAL AND INSTALLATION (2016 Supplement) EGR VALVE AND EGR COOLER REMOVAL AND INSTALLATION<4D5>CATALYTIC CONVERTER (2016 Basic) CATALYTIC CONVERTER REMOVAL AND INSTALLATION<4N1> (2016 Supplement) CATALYTIC CONVERTER REMOVAL AND INSTALLATION<4D5, Except EURO2> (2016 Supplement) CATALYTIC CONVERTER REMOVAL AND INSTALLATION<4N1-EURO5, Except EURO2>DIESEL PARTICULATE FILTER (DPF) SYSTEM<4N1-EURO5> (2016 Supplement) GENERAL INFORMATION (DPF SYSTEM) (2016 Supplement) COMPONENT LOCATION (DPF SYSTEM) (2016 Supplement) FORCIBLE DPF REGENERATION (2016 Supplement) NO. 1 EXHAUST GAS TEMPERATURE SENSOR CHECK (2016 Supplement) NO. 2 EXHAUST GAS TEMPERATURE SENSOR CHECK (2016 Supplement) NO. 3 EXHAUST GAS TEMPERATURE SENSOR CHECKDIESEL PARTICULATE FILTER (DPF)<4N1-EURO5>DIESEL PARTICULATE FILTER (DPF) SYSTEM SENSORS<4N1-EURO5>ADAPTIVE CRUISE CONTROL SYSTEM (ACC) (2017 Supplement) GENERAL INFORMATION (2017 Supplement) SPECIAL TOOL(S)TROUBLESHOOTING (2017 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES (2017 Supplement) CODE NO. C1394: INCOMPLETED LEARN NEUTRAL (SAS) (2017 Supplement) CODE NO. C1707: IMPLAUSIBLE CODING DATA (2017 Supplement) CODE NO. C1750: ACC/FCM-ECU VOLTAGE OUT OF RANGE (2017 Supplement) CODE NO. C1751: ACC/FCM-ECU FAILURE (2017 Supplement) CODE NO. C1752: ACC/FCM RADAR TEMPERATURE OUT OF RANGE (2017 Supplement) CODE NO. C1753: ACC/FCM RADAR BLOCKAGE DETECTED (2017 Supplement) CODE NO. C1754: ACC/FCM RADAR CALIBRATION NOT COMPLETED (2017 Supplement) CODE NO. C1772: ALIGNMENT SENSOR TOO FAR RIGHT (2017 Supplement) CODE NO. C1773: ALIGNMENT SENSOR TOO FAR LEFT (2017 Supplement) CODE NO. C1774: ALIGNMENT SENSOR TOO LOW (2017 Supplement) CODE NO. C1775: ALIGNMENT SENSOR TOO HIGH (2017 Supplement) CODE NO. C1776: RECEIVED ACC FAILURE FROM ENGINE-ECU (2017 Supplement) CODE NO. C1777: RECEIVED ACC FAILURE FROM ASC ECU (2017 Supplement) CODE NO. C1778: VEHICLE SPEED SIGNAL FAILURE (2017 Supplement) CODE NO. C1781: SAS FAILURE (2017 Supplement) CODE NO. C1782: SAS SIGNAL FAILURE (2017 Supplement) CODE NO. C1783: ACC DISTANCE SWITCH FIXED ON (2017 Supplement) CODE NO. C1785: FAULT DETECTION SIGNAL FAILURE (2017 Supplement) CODE NO. C1787: APS SIGNAL (2017 Supplement) CODE NO. C1791: VEHICLE SPEED SIGNAL SNA DETECTED (2017 Supplement) CODE NO. C1792: BRAKE M/C PRS. SIGNAL (INVALID) (2017 Supplement) CODE NO. C1794: LONGITUDINAL G SIGNAL (INVALID) (2017 Supplement) CODE NO. C1795: YAW RATE SIGNAL (INVALID) (2017 Supplement) CODE NO. C1796: APS SIGNAL (INVALID) (2017 Supplement) CODE NO. C1808: NOISE ERROR (2017 Supplement) CODE NO. C2256: BRAKE SWITCH SIGNAL FAIL (2017 Supplement) CODE NO. C2257: ASC SIGNAL FAILURE 1 (2017 Supplement) CODE NO. C2262: SAS OFFSET THRESHOLD EXCEED (2017 Supplement) CODE NO. C2263: YAW RATE OFFSET THRESHOLD EXCEED (2017 Supplement) CODE NO. C2264: ESTIMATED TYRE SIZE EXCEED (2017 Supplement) CODE NO. C2265: UNAVAILABLE REFERENCE VELOCITY (2017 Supplement) CODE NO. C2266: UNAVAILABLE OF YAW RATE QUALITY (2017 Supplement) CODE NO. C2267: WHEEL SPEED SIGNAL FAIL (2017 Supplement) CODE NO. C2268: DISTANCE TRAVELLED SIGNAL FAIL (2017 Supplement) CODE NO. C2270: CURRENT GEAR SIGNAL FAIL (2017 Supplement) CODE NO. C2271: SAS SIGNAL FAIL (2017 Supplement) CODE NO. C2272: DELTA SAS SIGNAL FAIL (2017 Supplement) CODE NO. C2273: T/F STATE SIGNAL (2017 Supplement) CODE NO. C2275: REAR DIFF. LOCK STATE SIGNAL (2017 Supplement) CODE NO. C2277: ENGINE STATUS SIGNAL (2017 Supplement) CODE NO. U0100: ENGINE CAN TIMEOUT (2017 Supplement) CODE NO. U0101: T/M CAN TIMEOUT (2017 Supplement) CODE NO. U0114: TRANSFER-ECU CAN TIMEOUT (2017 Supplement) CODE NO. U0121: ABS/ASC CAN TIMEOUT (2017 Supplement) CODE NO. U0126: SAS CAN TIMEOUT (2017 Supplement) CODE NO. U0141: ETACS CAN TIMEOUT (2017 Supplement) CODE NO. U0146: GATEWAY CAN TIMEOUT (2017 Supplement) CODE NO. U0155: METER CAN TIMEOUT (2017 Supplement) CODE NO. U0317: EPB CAN TIMEOUT (2017 Supplement) CODE NO. U1195: CODING NOT COMPLETED (2017 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2017 Supplement) THE SCAN TOOL CANNOT COMMUNICATE WITH ACC/FCM-ECU (2017 Supplement) CRUISE CONTROL CANNOT BE SET. (2017 Supplement) THE CRUISE CONTROL IS CANCELLED ALTHOUGH THE SWITCH IS NOT OPERATED DURING THE ACC OPERATION. (2017 Supplement) WHEN THE ACC DISTANCE SWITCH IS OPERATED, THE DISTANCE FROM VEHICLE TRAVELLING IN FRONT CANNOT BE CHANGED. (2017 Supplement) DATA LIST REFERENCE TABLE (2017 Supplement) SPECIAL FUNCTION (2017 Supplement) CHECK AT ECU TERMINALON-VEHICLE SERVICE (2017 Supplement) CRUISE CONTROL SWITCH CHECK (2017 Supplement) ACC SYSTEM COMPONENT CHECK (2017 Supplement) ACC/FCM-ECU (RADAR) CALIBRATIONCRUISE CONTROL SWITCHACC/FCM-ECU (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S) (2016 Basic) LUBRICANT(S) (2016 Supplement) LUBRICANT(S)ON-VEHICLE SERVICE (2016 Basic) CLUTCH PEDAL CHECK AND ADJUSTMENT (2016 Supplement) CLUTCH PEDAL CHECK AND ADJUSTMENT<L.H. drive vehicles> (2016 Basic) CLUTCH BLEEDING (2016 Supplement) CLUTCH BLEEDING<R5MB1, V5MB1, R6M5A, V6M5A> (2016 Basic) CLUTCH PEDAL SWITCH CHECK AND ADJUSTMENT (2016 Supplement) CLUTCH PEDAL SWITCH CHECK AND ADJUSTMENT<4N1, 4D5>CLUTCH PEDAL (2016 Basic) CLUTCH PEDAL REMOVAL AND INSTALLATION (2016 Supplement) CLUTCH PEDAL REMOVAL AND INSTALLATION<4N1, 4D5> (2016 Basic) CLUTCH PEDAL INSPECTION (2016 Supplement) CLUTCH PEDAL INSPECTION<4N1, 4D5>CLUTCH MASTER CYLINDER (2016 Basic) CLUTCH MASTER CYLINDER ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) CLUTCH MASTER CYLINDER ASSEMBLY REMOVAL AND INSTALLATION<4N1, 4D5> CLUTCH MASTER CYLINDER ASSEMBLY DISASSEMBLY AND REASSEMBLY CLUTCH MASTER CYLINDER ASSEMBLY INSPECTIONCLUTCH RELEASE CYLINDER (2016 Supplement) GENERAL INFORMATION (2016 Basic) GENERAL SPECIFICATIONS (2016 Supplement) GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS (2016 Basic) TORQUE SPECIFICATIONS (2016 Supplement) TORQUE SPECIFICATIONS (2016 Basic) LUBRICANTS (2016 Supplement) LUBRICANTSCLUTCH (2016 Basic) CLUTCH REMOVAL AND INSTALLATION (2016 Supplement) CLUTCH REMOVAL AND INSTALLATION CLUTCH INSPECTIONCLUTCH RELEASE CYLINDER (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) LUBRICANT(S) (2016 Supplement) LUBRICANT(S) (2016 Basic) SEALANT AND ADHESIVE (2016 Supplement) SEALANT AND ADHESIVE (2016 Supplement) SPECIAL TOOL(S)TROUBLESHOOTING<V6M5A>ON-VEHICLE SERVICE (2016 Basic) TRANSMISSION OIL LEVEL CHECK (2016 Supplement) TRANSMISSION OIL LEVEL CHECK (2016 Basic) TRANSMISSION OIL CHANGE (2016 Supplement) TRANSMISSION OIL CHANGE (2016 Supplement) TRANSFER OIL LEVEL CHECK (2016 Supplement) TRANSFER OIL CHANGE (2016 Supplement) CENTRE DIFFERENTIAL LOCK DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) 2WD/4WD DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) CENTRE DIFFERENTIAL LOCK OPERATION DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) 4WD OPERATION DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) HIGH/LOW DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) 4LLc DETECTION SWITCH CONTINUITY CHECK<V5MB1> (2016 Supplement) TRANSFER ACTUATOR CHECK<V6M5A>TRANSMISSION CONTROL (2016 Basic) TRANSMISSION CONTROL REMOVAL AND INSTALLATION (2016 Supplement) TRANSMISSION CONTROL REMOVAL AND INSTALLATION<R5MB1, V5MB1> (2016 Supplement) TRANSMISSION CONTROL REMOVAL AND INSTALLATION<R6M5A, V6M5A>TRANSMISSION ASSEMBLY (2016 Basic) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<2WD> (2016 Supplement) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<4WD>TRANSFER<V6M5A>TRANSFER-ECU<V6M5A>DRIVE MODE-SELECTOR<V6M5A> (2016 Supplement) DRIVE MODE-SELECTOR REMOVAL AND INSTALLATION (2016 Supplement) DRIVE MODE-SELECTOR INSPECTION4WD INDICATOR-ECU<V5MB1> GENERAL INFORMATION GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT TORQUE SPECIFICATION LUBRICANTS SEALANT(S) AND ADHESIVE(S) SPECIAL TOOLSTRANSMISSIONEXTENSION HOUSINGSPEEDOMETER GEARMAIN SHAFTCOUNTERSHAFT (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT (2016 Supplement) TORQUE SPECIFICATIONS (2016 Supplement) SEALANT(S) AND ADHESIVE(S) (2016 Supplement) SPECIAL TOOLSTRANSMISSIONINPUT SHAFTOUTPUT SHAFTCOUNTERSHAFTREVERSE IDLER GEAR (2016 Supplement) REVERSE IDLER GEAR DISASSEMBLY AND REASSEMBLY (2016 Supplement) REVERSE IDLER GEAR INSPECTIONEXTENSION HOUSING (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT (2016 Supplement) TORQUE SPECIFICATIONS (2016 Supplement) SEALANT(S) AND ADHESIVE(S) (2016 Supplement) LUBRICANTS (2016 Supplement) SPECIAL TOOLSTRANSMISSIONTRANSMISSIONTRANSMISSION CASE<M/T CASE REAR AND EXTENSION HOUSING>3RD AND 4TH GEARSHIFT RAIL AND SHAFT ASSEMBLYOUTPUT SHAFTINPUT SHAFTCOUNTERSHAFT (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT (2016 Supplement) TORQUE SPECIFICATIONS (2016 Supplement) SEALANT(S) AND ADHESIVE(S) (2016 Supplement) LUBRICANTS (2016 Supplement) SPECIAL TOOLSTRANSMISSIONINPUT SHAFTOUTPUT SHAFTCOUNTER SHAFTREVERSE IDLER GEAR (2016 Supplement) REVERSE IDLER GEAR DISASSEMBLY AND REASSEMBLY (2016 Supplement) REVERSE IDLER GEAR INSPECTIONTRANSFER (2016 Supplement) TRANSFER DISASSEMBLY AND REASSEMBLY (2016 Supplement) ADJUSTMENT OF TRANSFER (2016 Supplement) TRANSFER INSPECTIONTRANSFER CASE PLATETRANSFER INPUT GEARCOUNTERSHAFT2-4WD SYNCHRONIZERCENTRE DIFFERENTIAL CASEH-L SHIFT FORKREAR OUTPUT SHAFTTRANSFER DRIVE SHAFTFRONT OUTPUT SHAFTSPEEDOMETER GEAR (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS<Transmission> (2016 Supplement) SERVICE SPECIFICATIONS<Transfer> (2016 Supplement) SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT<Transmission> (2016 Supplement) SNAP RING, SPACER AND THRUST PLATE FOR ADJUSTMENT<Transfer> (2016 Supplement) TORQUE SPECIFICATIONS<Transmission> (2016 Supplement) TORQUE SPECIFICATIONS<Transfer> (2016 Supplement) SEALANT(S) AND ADHESIVE(S) (2016 Supplement) LUBRICANTS (2016 Supplement) SPECIAL TOOLS<Transmission> (2016 Supplement) SPECIAL TOOLS<Transfer>TRANSMISSIONTRANSMISSIONTRANSMISSION CASE<M/T CASE REAR AND ADAPTER CASE>3RD AND 4TH GEARSHIFT RAIL AND SHAFT ASSEMBLYOUTPUT SHAFTINPUT SHAFTCOUNTERSHAFTTRANSFERTRANSFER INPUT GEARFRONT OUTPUT SHAFTREAR OUTPUT SHAFT (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION SPECIFICATIONS LUBRICANT(S) (2016 Basic) SPECIAL TOOL(S) (2017 Supplement) SPECIAL TOOL(S) (2016 Supplement) SHIFT PATTERN (2016 Supplement) DAMPER CLUTCH CONTROLTROUBLESHOOTING <A/T> DIAGNOSIS TROUBLESHOOTING FLOW (2016 Basic) DIAGNOSIS FUNCTION (2017 Supplement) DIAGNOSIS FUNCTION HOW TO INITIALISE A/T LEARNING VALUE A/T INITIAL LEARNING PROCEDURE (2016 Basic) ROAD TEST (2017 Supplement) ROAD TEST SHIFT PATTERN DAMPER CLUTCH CONTROL (2016 Basic) DIAGNOSIS CODE CHART (2017 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. P0603 ECU SYSTEM (EEPROM ERROR) CODE NO. P0604 ECU SYSTEM (RAM ERROR) CODE NO. P0605 ECU SYSTEM (ROM ERROR) CODE NO. P0613 ECU SYSTEM (PROCESSOR ERROR) CODE NO. P0707 INHIBITOR SWITCH SYSTEM CODE NO. P0708 INHIBITOR SWITCH SYSTEM CODE NO. P0711 FLUID TEMPERATURE SENSOR 1 SYSTEM CODE NO. P0712 FLUID TEMPERATURE SENSOR 1 SYSTEM CODE NO. P0713 FLUID TEMPERATURE SENSOR 1 SYSTEM CODE NO. P0717 INPUT SHAFT SPEED SENSOR SYSTEM (NO SIGNAL), P07BF INPUT SHAFT SPEED SENSOR SYSTEM (LOW CURRENT), P07C0 INPUT SHAFT SPEED SENSOR SYSTEM (HIGH CURRENT) CODE NO. P0722 OUTPUT SHAFT SPEED SENSOR SYSTEM (NO SIGNAL), P077C OUTPUT SHAFT SPEED SENSOR SYSTEM (LOW CURRENT), P077D OUTPUT SHAFT SPEED SENSOR SYSTEM (HIGH CURRENT) CODE NO. P0729, P0731, P0732, P0733, P0734, P0735, P076F, P07D9: 6TH, 1ST, 2ND, 3RD, 4TH, 5TH, 7TH, 8TH GEAR INCORRECT RATIO CODE NO. P073E NEUTRAL CONDITION (R RANGE) CODE NO. P0741 LOCK-UP CONTROL SOLENOID SYSTEM (STUCK OFF), P0742 LOCK-UP CONTROL SOLENOID SYSTEM (STUCK ON) CODE NO. P0780 SHIFT ERROR CODE NO. P07E5 NEUTRAL CONDITION, P2711 NEUTRAL CONDITION (D RANGE) CODE NO. P0812 REVERSE INPUT CIRCUIT CODE NO. P0815 MALFUNCTION OF PADDLE SHIFT UP SWITCH CODE NO. P0816 MALFUNCTION OF PADDLE SHIFT DOWN SWITCH CODE NO. P0828 SPORT MODE UP/DOWN SWITCH CODE NO. P0882 IG VOLTAGE SYSTEM CODE NO. P0883 POWER SUPPLY SYSTEM (SHORT CIRCUIT) CODE NO. P0958 SPORT MODE SWITCH SYSTEM CODE NO. P0961 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0962 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0963 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM CODE NO. P0965 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM CODE NO. P0966 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM CODE NO. P0967 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM CODE NO. P0969 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM CODE NO. P0970 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM CODE NO. P0971 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM CODE NO. P0973 SHIFT SOLENOID NO.1 SYSTEM CODE NO. P0974 SHIFT SOLENOID NO.1 SYSTEM CODE NO. P0976 SHIFT SOLENOID NO.2 SYSTEM CODE NO. P0977 SHIFT SOLENOID NO.2 SYSTEM CODE NO. P1711 WRONG GEAR SELECT, P1712 HIGH BRAKING TORQUE, P1713 RANGE INFORMATION WRONG DISPLAY CODE NO. P1752 CLUTCH CONTROL FUNCTIONAL FAULT CODE NO. P1779 1ST ENGINE BRAKE DETECTION CODE NO. P1799 BRAKE PRESSURE SENSOR INFORMATION CODE NO. P2719 C3 PRESSURE CONTROL SOLENOID SYSTEM (MALFUNCTION), P2720 C3 PRESSURE CONTROL SOLENOID SYSTEM (LOW CURRENT), P2721 C3 PRESSURE CONTROL SOLENOID SYSTEM (HIGH CURRENT) CODE NO. P2728 C4 PRESSURE CONTROL SOLENOID SYSTEM (MALFUNCTION), P2729 C4 PRESSURE CONTROL SOLENOID SYSTEM (LOW CURRENT), P2730 C4 PRESSURE CONTROL SOLENOID SYSTEM (HIGH CURRENT) CODE NO. P2737 B1 PRESSURE CONTROL SOLENOID SYSTEM (MALFUNCTION), P2738 B1 PRESSURE CONTROL SOLENOID SYSTEM (LOW CURRENT), P2739 B1 PRESSURE CONTROL SOLENOID SYSTEM (HIGH CURRENT) CODE NO. P2742 FLUID TEMPERATURE SENSOR 2 SYSTEM CODE NO. P2743 FLUID TEMPERATURE SENSOR 2 SYSTEM CODE NO. P2762 LOCK-UP CONTROL SOLENOID SYSTEM CODE NO. P2763 LOCK-UP CONTROL SOLENOID SYSTEM CODE NO. P2764 LOCK-UP CONTROL SOLENOID SYSTEM CODE NO. P2771 4LLC SWITCH CIRCUIT<4WD> CODE NO. U0001 MALFUNCTION OF CAN COMMUNICATION CIRCUIT (BUS OFF) CODE NO. U0100 CAN TIME-OUT ERROR (ENGINE) CODE NO. U0114 CAN TIME-OUT ERROR (TRANSFER-ECU)<4WD> CODE NO. U0121 CAN TIME-OUT ERROR (ABS/ASTC)<Vehicles with ABS/ASTC> CODE NO. U0141 CAN TIME-OUT ERROR (ETACS) CODE NO. U0155 CAN TIME-OUT ERROR (COMBINATION METER) CODE NO. U0164 CAN TIME-OUT ERROR (A/C-ECU) CODE NO. U1195 CODING NOT COMPLETED CODE NO. U1197 CODING DATA UNAVAILABLE CODE NO. U1EE0 PART NUMBER ERROR CODE NO. U1EE1 CONTROL MODULE PROGRAMMING ERROR (2017 Supplement) CODE No. P0777: SL1 MAX Pressure Failure (2017 Supplement) CODE No. P0797: SL2 MAX Pressure Failure (2017 Supplement) CODE No. P2715: SL3 MAX Pressure Failure (2017 Supplement) CODE No. P2724: SL4 MAX Pressure Failure (2017 Supplement) CODE No. P2733: SL5 MAX Pressure Failure SYMPTOM CHARTSYMPTOM PROCEDURES ENGINE DOES NOT START DRIVEAWAY FAULT (FORWARD DRIVING FAULT "D") DRIVEAWAY FAULT (BACKWARD DRIVING FAULT "R") SLIPPAGE (FORWARD DRIVING SLIPPAGE "D") SLIPPAGE (BACKWARD DRIVING SLIPPAGE "R") GARAGE SHIFT TIME LAG ("N TO D") GARAGE SHIFT TIME LAG ("N TO R") ENGINE STALL ("N TO D", "N TO R") ENGINE STALL (AT DECELERATION) POOR ACCELERATION SHIFT CHANGE IMPOSSIBLE (1st to 2nd, 2nd to 1st) SHIFT CHANGE IMPOSSIBLE (2nd to 3rd, 3rd to 2nd) SHIFT CHANGE IMPOSSIBLE (3rd to 4th, 4th to 3rd) SHIFT CHANGE IMPOSSIBLE (4th to 5th, 5th to 4th) SHIFT CHANGE IMPOSSIBLE (5th to 6th, 6th to 5th) SHIFT CHANGE IMPOSSIBLE (6th to 7th, 7th to 6th) SHIFT CHANGE IMPOSSIBLE (7th to 8th, 8th to 7th) SHIFT CHANGE IMPOSSIBLE (LOCK-UP DOES NOT TURN ON, LOCK-UP DOES NOT TURN OFF) KICK-DOWN IS NOT PERFORMED SHIFT POINT FAULT SHIFT LEVER DETENT FEEL IS STRONG/WEAK SHOCK IS SIGNIFICANT ("N TO D") SHOCK IS SIGNIFICANT ("N TO R") SHOCK IS SIGNIFICANT (AT UPSHIFT) SHOCK IS SIGNIFICANT (AT COAST-DOWN) SHOCK IS SIGNIFICANT (AT KICK-DOWN) SHOCK IS SIGNIFICANT (AT ACCELERATOR ON/OFF (NO SHIFT CHANGE IS PERFORMED)) VIBRATION (AT DRIVEAWAY) VIBRATION (DURING DRIVING) OIL LEAK (BREATHER SECTION) OIL LEAK (MOUNTING SURFACES OF ENGINE AND T/M HOUSING) OIL LEAK (MOUNTING SURFACES OF T/M CASE AND ADAPTER) OIL LEAK (MANUAL SHAFT OIL SEAL) OIL LEAK (OIL COOLER PIPE) OIL LEAK (O-RING (T/M WIRE, ELBOW)) OIL LEAK (ADAPTER) OIL LEAK (T/M CASE AND OIL PAN) NOISE (DURING IDLE) NOISE (AT GARAGE SHIFT) NOISE (DURING DRIVING) NOISE (AT SHIFT CHANGE) NOISE (AT ACCELERATOR ON/OFF) OIL TEMPERATURE WARNING LAMP FLASHES OR DOES NOT GO OUT A/T-ECU POWER SUPPLY SYSTEM (2016 Basic) DATA LIST REFERENCE TABLE (2017 Supplement) DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE SPECIAL FUNCTION A/T-ECU TERMINAL VOLTAGE REFERENCE CHART OSCILLOSCOPE CHECK PROCEDURE PCM TERMINAL RESISTANCE AND CONTINUITY INSPECTION CHARTTROUBLESHOOTING <SS4II><4WD> DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES Code No. C1403 Mode switch failure Code No. C1422 Power supply low voltage Code No. C1430 Transfer position SW Code No. C1431 T/F actuator terminal high VOLT. Code No. C1436 F/W engage SW Code No. C1437 F/W actuator terminal high VOLT. Code No. C143A R/D lock ACT.terminal high VOLT. Code No. C143F Interlock system abnormality Code No. C1464 R/D lock SW Code No. C1469 R/D lock engage SW Code No. C1607 ECU failure Code No. U0100 Engine CAN timeout Code No. U0101 T/M CAN timeout Code No. U0121 ABS/ASC CAN timeout Code No. U0141 ETACS CAN timeout Code No. U0155 Meter CAN timeout Code No. U1120 Engine (CAN message) Code No. U1121 T/M (CAN message) Code No. U1122 ASC/TCL/ABS (CAN message) Code No. U1195 Coding not completed Code No. U1197 Coding data unavailable SYMPTOM CHARTSYMPTOM PROCEDURES COMMUNICATION BETWEEN M.U.T.-III AND TRANSFER-ECU CANNOT BE ESTABLISHED. TRANSFER-ECU POWER SUPPLY CIRCUIT MALFUNCTION DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE TRANSFER-ECU TERMINAL VOLTAGE REFERENCE CHARTON-VEHICLE SERVICEESSENTIAL SERVICE A/T FLUID CHECK A/T FLUID CHANGE INHIBITOR SWITCH CONTINUITY CHECK INHIBITOR SWITCH AND CONTROL CABLE ADJUSTMENT TRANSFER OIL CHECK<4WD> TRANSFER OIL CHANGE<4WD> (2016 Basic) A/T CONTROL COMPONENT LAYOUT (2016 Supplement) A/T CONTROL COMPONENT LAYOUTAUTOMATIC TRANSMISSION CONTROL COMPONENT CHECK A/T CONTROL RELAY CHECK INPUT SHAFT SPEED SENSOR CHECK OUTPUT SHAFT SPEED SENSOR CHECK SOLENOID VALVE CHECK A/T FLUID TEMPERATURE SENSOR CHECK TORQUE CONVERTER STALL CHECK TIME LAG TEST HYDRAULIC PRESSURE TESTS (2016 Basic) SELECTOR LEVER OPERATION CHECK (2016 Supplement) SELECTOR LEVER OPERATION CHECK SHIFT LOCK MECHANISM CHECK TRANSFER ACTUATOR CHECK<4WD>TRANSMISSION CONTROLTRANSFER ASSEMBLY<4WD>TRANSMISSION ASSEMBLY (2016 Basic) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<2WD> (2016 Basic) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<4WD> (2016 Supplement) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<4WD-6B3>A/T OIL COOLERA/T-ECUTRANSFER-ECU<4WD>DRIVE MODE-SELECTOR<4WD>PADDLE SHIFT SWITCH<Vehicles with paddle shift> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) GENERAL SPECIFICATIONS (2016 Supplement) GENERAL SPECIFICATIONS SERVICE SPECIFICATIONS<Transfer> SNAP RING, SPACER, THRUST WASHER, THRUST RACE AND PRESSURE PLATE FOR ADJUSTMENT<Transfer> TORQUE SPECIFICATIONS<Transmission> TORQUE SPECIFICATIONS<Transfer> SEALANTS LUBRICANTS SPECIAL TOOLS<Transmission> SPECIAL TOOLS<Transfer>CONVERTER HOUSINGTRANSMISSIONEXTENSION HOUSING<2WD>TRANSFER CASE ADAPTER<Super select 4WD-II>OIL PAN AND VALVE BODYTRANSFER<Super select 4WD-II>TRANSFER INPUT GEAR<Super select 4WD-II>FRONT OUTPUT SHAFT<Super select 4WD-II>REAR OUTPUT SHAFT<Super select 4WD-II> (2016 Supplement) GENERAL INFORMATION (2016 Supplement) SPECIFICATIONS (2016 Supplement) LUBRICANT(S) (2016 Supplement) SPECIAL TOOL(S)TROUBLESHOOTING <A/T> (2016 Supplement) DIAGNOSIS TROUBLESHOOTING FLOW (2016 Supplement) DIAGNOSIS FUNCTION (2016 Supplement) HOW TO INITIALISE A/T LEARNING VALUE (2016 Supplement) A/T INITIAL LEARNING PROCEDURE (2016 Supplement) ROAD TEST (2016 Supplement) SHIFT PATTERN (2016 Supplement) DAMPER CLUTCH CONTROL (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES (2016 Supplement) CODE NO. P0603 ECU SYSTEM (EEPROM ERROR) (2016 Supplement) CODE NO. P0604 ECU SYSTEM (RAM ERROR) (2016 Supplement) CODE NO. P0605 ECU SYSTEM (ROM ERROR) (2016 Supplement) CODE NO. P0707 INHIBITOR SWITCH SYSTEM (2016 Supplement) CODE NO. P0708 INHIBITOR SWITCH SYSTEM (2016 Supplement) CODE NO. P0711 FLUID TEMPERATURE SENSOR 1 SYSTEM (2016 Supplement) CODE NO. P0712 FLUID TEMPERATURE SENSOR 1 SYSTEM (2016 Supplement) CODE NO. P0713 FLUID TEMPERATURE SENSOR 1 SYSTEM (2016 Supplement) CODE NO. P0715 INPUT SHAFT SPEED SENSOR SYSTEM (2016 Supplement) CODE NO. P0720 OUTPUT SHAFT SPEED SENSOR SYSTEM (2016 Supplement) CODE NO. P0751 SOLENOID VALVE NO.1 SYSTEM (2016 Supplement) CODE NO. P0752 SOLENOID VALVE NO.1 SYSTEM (2016 Supplement) CODE NO. P0756 SOLENOID VALVE NO.2 SYSTEM (2016 Supplement) CODE NO. P0757 SOLENOID VALVE NO.2 SYSTEM (2016 Supplement) CODE NO. P0771 LINER SOLENOID No.1 SYSTEM OR SHIFT SOLENOID SR SYSTEM (2016 Supplement) CODE NO. P0772 SHIFT SOLENOID SR SYSTEM (2016 Supplement) CODE NO. P0777 CLUTCH CONTROL SOLENOID NO.1 SYSTEM (ON STICKING) (2016 Supplement) CODE NO. P0781 1-2 SHIFT VALVE SYSTEM (2016 Supplement) CODE NO. P0797 LINER SOLENOID No.2 (2016 Supplement) CODE NO. P0828 SPORT MODE UP/DOWN SWITCH (2016 Supplement) CODE NO. P0882 IG VOLTAGE SYSTEM (2016 Supplement) CODE NO. P0958 SPORT MODE SWITCH SYSTEM (2016 Supplement) CODE NO. P0961 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM (2016 Supplement) CODE NO. P0962 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM (2016 Supplement) CODE NO. P0963 LINE PRESSURE CONTROL SOLENOID VALVE SYSTEM (2016 Supplement) CODE NO. P0965 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM (2016 Supplement) CODE NO. P0966 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM (2016 Supplement) CODE NO. P0967 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 1 SYSTEM (2016 Supplement) CODE NO. P0969 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM (2016 Supplement) CODE NO. P0970 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM (2016 Supplement) CODE NO. P0971 CLUTCH ENGAGEMENT HYDRAULIC CONTROL SOLENOID NO. 2 SYSTEM (2016 Supplement) CODE NO. P0973 SHIFT SOLENOID NO.1 SYSTEM (2016 Supplement) CODE NO. P0974 SHIFT SOLENOID NO.1 SYSTEM (2016 Supplement) CODE NO. P0976 SHIFT SOLENOID NO.2 SYSTEM (2016 Supplement) CODE NO. P0977 SHIFT SOLENOID NO.2 SYSTEM (2016 Supplement) CODE NO. P0985 SOLENOID VALVE SR SYSTEM (2016 Supplement) CODE NO. P0986 SOLENOID VALVE SR SYSTEM (2016 Supplement) CODE NO. P2742 FLUID TEMPERATURE SENSOR 2 SYSTEM (2016 Supplement) CODE NO. P2743 FLUID TEMPERATURE SENSOR 2 SYSTEM (2016 Supplement) CODE NO. P2757 LOCK-UP CONTROL SOLENOID SYSTEM (2016 Supplement) CODE NO. P2758 LOCK-UP CONTROL SOLENOID SYSTEM (2016 Supplement) CODE NO. P2762 LOCK-UP CONTROL SOLENOID SYSTEM (2016 Supplement) CODE NO. P2763 LOCK-UP CONTROL SOLENOID SYSTEM (2016 Supplement) CODE NO. P2764 LOCK-UP CONTROL SOLENOID SYSTEM (2016 Supplement) CODE NO. P2771 4LLC SWITCH CIRCUIT<4WD> (2016 Supplement) CODE NO. P2773 TRANSFER L4<4WD> (2016 Supplement) CODE NO. P2774 TRANSFER L4<4WD> (2016 Supplement) CODE NO. U0001 MALFUNCTION OF CAN COMMUNICATION CIRCUIT (BUS OFF) (2016 Supplement) CODE NO. U0100 CAN TIME-OUT ERROR (ENGINE) (2016 Supplement) CODE NO. U0114 CAN TIME-OUT ERROR (TRANSFER-ECU)<4WD> (2016 Supplement) CODE NO. U0121 CAN TIME-OUT ERROR (ABS/ASTC)<Vehicles with ABS/ASTC> (2016 Supplement) CODE NO. U0141 CAN TIME-OUT ERROR (ETACS) (2016 Supplement) CODE NO. U0155 CAN TIME-OUT ERROR (COMBINATION METER) (2016 Supplement) CODE NO. U1195 CODING NOT COMPLETED (2016 Supplement) CODE NO. U1197 CODING DATA UNAVAILABLE (2016 Supplement) CODE NO. U1EE0 PART NUMBER ERROR (2016 Supplement) CODE NO. U1EE1 CONTROL MODULE PROGRAMMING ERROR (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2016 Supplement) ENGINE DOES NOT START (2016 Supplement) DRIVEAWAY FAULT (FORWARD DRIVING FAULT "D") (2016 Supplement) DRIVEAWAY FAULT (BACKWARD DRIVING FAULT "R") (2016 Supplement) SLIPPAGE (FORWARD DRIVING SLIPPAGE "D") (2016 Supplement) SLIPPAGE (BACKWARD DRIVING SLIPPAGE "R") (2016 Supplement) GARAGE SHIFT TIME LAG ("N TO D") (2016 Supplement) GARAGE SHIFT TIME LAG ("N TO R") (2016 Supplement) ENGINE STALL ("N TO D", "N TO R") (2016 Supplement) ENGINE STALL (AT DECELERATION) (2016 Supplement) POOR ACCELERATION (2016 Supplement) SHIFT CHANGE IMPOSSIBLE (1st to 2nd, 2nd to 1st) (2016 Supplement) SHIFT CHANGE IMPOSSIBLE (2nd to 3rd, 3rd to 2nd) (2016 Supplement) SHIFT CHANGE IMPOSSIBLE (3rd to 4th, 4th to 3rd) (2016 Supplement) SHIFT CHANGE IMPOSSIBLE (4th to 5th, 5th to 4th) (2016 Supplement) SHIFT CHANGE IMPOSSIBLE (LOCK-UP DOES NOT TURN ON, LOCK-UP DOES NOT TURN OFF) (2016 Supplement) KICK-DOWN IS NOT PERFORMED (2016 Supplement) SHIFT POINT FAULT (2016 Supplement) SHIFT LEVER DETENT FEEL IS STRONG/WEAK (2016 Supplement) SHOCK IS SIGNIFICANT ("N TO D") (2016 Supplement) SHOCK IS SIGNIFICANT ("N TO R") (2016 Supplement) SHOCK IS SIGNIFICANT (AT UPSHIFT) (2016 Supplement) SHOCK IS SIGNIFICANT (AT COAST-DOWN) (2016 Supplement) SHOCK IS SIGNIFICANT (AT KICK-DOWN) (2016 Supplement) SHOCK IS SIGNIFICANT (AT ACCELERATOR ON/OFF (NO SHIFT CHANGE IS PERFORMED)) (2016 Supplement) VIBRATION (AT DRIVEAWAY) (2016 Supplement) VIBRATION (DURING DRIVING) (2016 Supplement) OIL LEAK (BREATHER SECTION) (2016 Supplement) OIL LEAK (MOUNTING SURFACES OF ENGINE AND T/M HOUSING) (2016 Supplement) OIL LEAK (MOUNTING SURFACES OF T/M CASE AND ADAPTER) (2016 Supplement) OIL LEAK (MANUAL SHAFT OIL SEAL) (2016 Supplement) OIL LEAK (OIL COOLER PIPE) (2016 Supplement) OIL LEAK (O-RING (T/M WIRE, ELBOW)) (2016 Supplement) OIL LEAK (ADAPTER) (2016 Supplement) OIL LEAK (T/M CASE AND OIL PAN) (2016 Supplement) NOISE (DURING IDLE) (2016 Supplement) NOISE (AT GARAGE SHIFT) (2016 Supplement) NOISE (DURING DRIVING) (2016 Supplement) NOISE (AT SHIFT CHANGE) (2016 Supplement) NOISE (AT ACCELERATOR ON/OFF) (2016 Supplement) OIL TEMPERATURE WARNING LAMP FLASHES OR DOES NOT GO OUT (2016 Supplement) DATA LIST REFERENCE TABLE (2016 Supplement) ACTUATOR TEST REFERENCE TABLE (2016 Supplement) SPECIAL FUNCTION (2016 Supplement) A/T-ECU TERMINAL VOLTAGE REFERENCE CHART (2016 Supplement) OSCILLOSCOPE CHECK PROCEDURE (2016 Supplement) PCM TERMINAL RESISTANCE AND CONTINUITY INSPECTION CHARTTROUBLESHOOTING <SS4II><4WD>ON-VEHICLE SERVICEESSENTIAL SERVICE (2016 Supplement) A/T FLUID CHECK (2016 Supplement) A/T FLUID CHANGE (2016 Supplement) INHIBITOR SWITCH CONTINUITY CHECK (2016 Supplement) INHIBITOR SWITCH AND CONTROL CABLE ADJUSTMENT (2016 Supplement) TRANSFER OIL CHECK<4WD> (2016 Supplement) TRANSFER OIL CHANGE<4WD> (2016 Supplement) A/T CONTROL COMPONENT LAYOUTAUTOMATIC TRANSMISSION CONTROL COMPONENT CHECK (2016 Supplement) A/T CONTROL RELAY CHECK (2016 Supplement) INPUT SHAFT SPEED SENSOR CHECK (2016 Supplement) OUTPUT SHAFT SPEED SENSOR CHECK (2016 Supplement) SOLENOID VALVE CHECK (2016 Supplement) A/T FLUID TEMPERATURE SENSOR CHECK (2016 Supplement) TORQUE CONVERTER STALL CHECK (2016 Supplement) TIME LAG TEST (2016 Supplement) HYDRAULIC PRESSURE TESTS (2016 Supplement) MANUAL DRIVING TEST (2016 Supplement) SELECTOR LEVER OPERATION CHECK (2016 Supplement) SHIFT LOCK MECHANISM CHECK (2016 Supplement) TRANSFER ACTUATOR CHECK<4WD>TRANSMISSION CONTROL (2016 Supplement) TRANSMISSION CONTROL REMOVAL AND INSTALLATION (2016 Supplement) SELECTOR LEVER ASSEMBLY INSPECTIONTRANSFER ASSEMBLY<4WD>TRANSMISSION ASSEMBLY (2016 Supplement) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<2WD> (2016 Supplement) TRANSMISSION ASSEMBLY REMOVAL AND INSTALLATION<4WD>A/T OIL COOLERA/T-ECUTRANSFER-ECU<4WD>DRIVE MODE-SELECTOR<4WD> (2016 Supplement) GENERAL INFORMATION (2016 Supplement) GENERAL SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Supplement) TORQUE SPECIFICATIONS (2016 Supplement) VALVE BODY SPRING IDENTIFICATION (2016 Supplement) SNAP RING, SPACER, THRUST WASHER, THRUST RACE AND PRESSURE PLATE FOR ADJUSTMENT (2016 Supplement) SEALANTS (2016 Supplement) LUBRICANTS (2016 Supplement) SPECIAL TOOLSSENSORCONVERTER HOUSINGEXTENSION HOUSING<2WD>TRANSFER CASE ADAPTER<4WD>OIL PAN AND VALVE BODYOIL PUMP AND CENTRE PLANETARY GEAR ASSEMBLY (2016 Supplement) OIL PUMP AND CENTRE PLANETARY GEAR ASSEMBLY DISASSEMBLY AND REASSEMBLY (2016 Supplement) OIL PUMP AND CENTRE PLANETARY GEAR ASSEMBLY INSPECTIONBRAKE DISC AND INTERMEDIATE SHAFT (2016 Supplement) BRAKE DISC AND INTERMEDIATE SHAFT DISASSEMBLY AND REASSEMBLY (2016 Supplement) BRAKE DISC AND INTERMEDIATE SHAFT INSPECTIONRR PLANETARY GEAR ASSEMBLY (2016 Supplement) RR PLANETARY GEAR ASSEMBLY DISASSEMBLY AND REASSEMBLY (2016 Supplement) RR PLANETARY GEAR ASSEMBLY INSPECTIONOIL PUMPFORWARD, REVERSE AND DIRECT CLUTCH (2016 Supplement) FORWARD, REVERSE AND DIRECT CLUTCH DISASSEMBLY AND REASSEMBLY (2016 Supplement) FORWARD, REVERSE AND DIRECT CLUTCH INSPECTIONSECOND BRAKEPLANETARY GEAR (2016 Supplement) PLANETARY GEAR DISASSEMBLY AND REASSEMBLY (2016 Supplement) PLANETARY GEAR INSPECTIONLOW-REVERSE BRAKE (2016 Supplement) LOW-REVERSE BRAKE DISASSEMBLY AND REASSEMBLY (2016 Supplement) LOW-REVERSE BRAKE INSPECTIONVALVE BODYTRANSFER<4WD>TRANSFER INPUT GEAR<4WD>FRONT OUTPUT SHAFT<4WD>REAR OUTPUT SHAFT<4WD> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATION(S) (2016 Supplement) SERVICE SPECIFICATION(S) (2016 Basic) LUBRICANT(S) (2016 Supplement) LUBRICANT(S) SPECIAL TOOL(S)ON-VEHICLE SERVICEPROPELLER SHAFT (2016 Basic) PROPELLER SHAFT REMOVAL AND INSTALLATION (2016 Supplement) PROPELLER SHAFT REMOVAL AND INSTALLATION (2016 Basic) PROPELLER SHAFT INSPECTION (2016 Supplement) PROPELLER SHAFT INSPECTION (2016 Basic) PROPELLER SHAFT DISASSEMBLY AND REASSEMBLY<5M/T> (2016 Basic) PROPELLER SHAFT DISASSEMBLY AND REASSEMBLY<8A/T> (2016 Supplement) PROPELLER SHAFT DISASSEMBLY AND REASSEMBLY<5M/T> (2016 Supplement) PROPELLER SHAFT DISASSEMBLY AND REASSEMBLY<6M/T> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE FRONT AXLE TOTAL BACKLASH CHECK<4WD> FRONT AXLE GEAR OIL LEVEL CHECK<4WD> GEAR OIL CHANGE<4WD> WHEEL BEARING AXIAL PLAY CHECK HUB BOLT REPLACEMENT FREE WHEEL SOLENOID VALVE OPERATION CHECKFRONT AXLE HUB ASSEMBLY FRONT AXLE HUB ASSEMBLY REMOVAL AND INSTALLATION FRONT AXLE HUB ASSEMBLY INSPECTION FRONT AXLE HUB ASSEMBLY DISASSEMBLY AND REASSEMBLY FRONT AXLE HUB ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)DRIVESHAFT ASSEMBLY<4WD> DRIVESHAFT ASSEMBLY REMOVAL AND INSTALLATION DRIVESHAFT ASSEMBLY DISASSEMBLY AND REASSEMBLY DRIVESHAFT ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY) BJ BOOT REPLACEMENTINNER SHAFT ASSEMBLY<4WD>DIFFERENTIAL CARRIER AND FREE WHEELING CLUTCH<4WD> DIFFERENTIAL CARRIER AND FREE WHEELING CLUTCH REMOVAL AND INSTALLATION DIFFERENTIAL CARRIER AND FREE WHEELING CLUTCH INSPECTION FREE WHEELING CLUTCH ASSEMBLY DISASSEMBLY AND REASSEMBLYSOLENOID VALVE AND VACUUM HOSE<4WD> (2016 Basic) SOLENOID VALVE AND VACUUM HOSE REMOVAL AND INSTALLATION (2016 Supplement) SOLENOID VALVE AND VACUUM HOSE REMOVAL AND INSTALLATION<VEHICLES WITH FREE WHEEL CLUTCH> (2016 Supplement) SOLENOID VALVE AND VACUUM HOSE REMOVAL AND INSTALLATION<VEHICLES WITHOUT FREE WHEEL CLUTCH>FRONT DIFFERENTIAL MOUNT<4WD> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)ON-VEHICLE SERVICE REAR AXLE TOTAL BACKLASH CHECK GEAR OIL LEVEL CHECK GEAR OIL CHANGE AXLE SHAFT AXIAL PLAY CHECK AXLE SHAFT AXIAL PLAY ADJUSTMENT HUB BOLT REPLACEMENT REAR DIFFERENTIAL LOCK DETECTION SWITCH, REAR DIFFERENTIAL LOCK SOLENOID CHECKAXLE ASSEMBLYAXLE SHAFT ASSEMBLY AXLE SHAFT ASSEMBLY REMOVAL AND INSTALLATION AXLE SHAFT ASSEMBLY DISASSEMBLY AND REASSEMBLY AXLE SHAFT INSPECTION (DISASSEMBLY AND REASSEMBLY)DIFFERENTIAL CARRIER ASSEMBLYREAR DIFFERENTIAL LOCK SWITCH<VEHICLE WITH REAR DIFFERENTIAL LOCK> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION (2016 Basic) SPECIFICATIONS (2016 Supplement) SPECIFICATIONS SERVICE SPECIFICATION(S) (2017 Supplement) SPECIAL TOOL(S)TROUBLESHOOTINGTYRE PRESSURE MONITORING SYSTEM (TPMS) DIAGNOSIS (2017 Supplement) INTRODUCTION (2017 Supplement) DIAGNOSIS TROUBLESHOOTING FLOW (2017 Supplement) DIAGNOSTIC FUNCTION (2017 Supplement) TPMS WARNING LAMP CHECK (2017 Supplement) TPMS DIAGNOSIS CODE CHARTTPMS DIAGNOSIS CODE PROCEDURES (2017 Supplement) CODE No.C1564 VEHICLE SPEED DATA INVALID (2017 Supplement) CODE No.C1900 ID CODE FAILURE (2017 Supplement) CODE No.C1901 TPMS ABNORMALITY (VEHICLE SPEED SENSOR INPUT ABNORMALITY) (2017 Supplement) CODE No.C1902 RESET FAIL (WARNING THRESHOLD) (2017 Supplement) CODE No.C1910, C1920, C1930, C1940 TRANSMITTER BATT. VOLTAGE TYRE1, 2, 3, 4/ C1911, C1921, C1931, C1941 TYRE ID RECEPTION FAIL TYRE1, 2, 3, 4 (2017 Supplement) CODE No.C1912, C1922, C1932, C1942 TYRE AIR PRESSURE LOW TYRE1, 2, 3, 4 (2017 Supplement) CODE No.C1913, C1923, C1933, C1943 ACCELERATION SENSOR TYRE1, 2, 3, 4/ C1914, C1924, C1934, C1944 TYRE AIR PRESSURE SENSOR TYRE1, 2, 3, 4 (2017 Supplement) CODE No.C1915, C1925, C1935, C1945 TRANSMITTER OFF MODE TYRE1, 2, 3, 4 (2017 Supplement) TPMS SYMPTOM CHARTTPMS SYMPTOM PROCEDURES (2017 Supplement) TPMS SERVICE DATA LIST (2017 Supplement) CHECK AT TPMS RECEIVERON-VEHICLE SERVICE TYRE INFLATION PRESSURE CHECK TYRE WEAR CHECK WHEEL RUNOUT CHECK (2017 Supplement) TPMS TRANSMITTER CHECK OR REPLACETPMS SPECIAL FUNCTIONWHEEL AND TYRESPARE TYRE CARRIERTYRE PRESSURE MONITORING SYSTEM (TPMS) (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Supplement) SPECIAL TOOL(S)ENGINE MOUNTING (2016 Basic) ENGINE MOUNTING REMOVAL AND INSTALLATION (2016 Supplement) ENGINE MOUNTING REMOVAL AND INSTALLATION ENGINE MOUNTING INSPECTIONREAR ENGINE MOUNTING (2016 Basic) REAR ENGINE MOUNTING REMOVAL AND INSTALLATION (2016 Supplement) REAR ENGINE MOUNTING REMOVAL AND INSTALLATION REAR ENGINE MOUNTING INSPECTIONTRANSFER MOUNTING<4WD-M/T> (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS SPECIAL TOOL(S)ON-VEHICLE SERVICE FRONT WHEEL ALIGNMENT CHECK AND ADJUSTMENT<2WD (High rider), 4WD> LOWER ARM BALL JOINT AXIAL PLAY CHECK LOWER ARM BALL JOINT DUST COVER CHECKUPPER ARM ASSEMBLYSHOCK ABSORBER ASSEMBLY SHOCK ABSORBER ASSEMBLY REMOVAL AND INSTALLATION SHOCK ABSORBER ASSEMBLY INSPECTION SHOCK ABSORBER ASSEMBLY DISASSEMBLY AND REASSEMBLY SHOCK ABSORBER ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)LOWER ARMSTABILIZER BAR (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)ON-VEHICLE SERVICELOWER ARMSHOCK ABSORBER AND LATERAL RODCOIL SPRING AND AXLE BUMPER (2016 Basic) COIL SPRING AND AXLE BUMPER REMOVAL AND INSTALLATION (2016 Supplement) COIL SPRING AND AXLE BUMPER REMOVAL AND INSTALLATION<VEHICLES FOR AUSTRALIA AND NEW ZEALAND>STABILIZER BAR (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION (2016 Basic) SERVICE SPECIFICATIONS (2016 Supplement) SERVICE SPECIFICATIONS (2016 Basic) LUBRICANTS (2016 Supplement) LUBRICANTS SPECIAL TOOL(S)ON-VEHICLE SERVICE (2016 Basic) BRAKE PEDAL CHECK AND ADJUSTMENT (2016 Supplement) BRAKE PEDAL CHECK AND ADJUSTMENT (2016 Basic) STOP LAMP RELAY REPLACEMENT (2016 Supplement) STOP LAMP RELAY REPLACEMENT<L.H. DRIVE VEHICLES> (2016 Basic) BRAKE BOOSTER OPERATING CHECK (2016 Supplement) BRAKE BOOSTER OPERATING CHECK CHECK VALVE OPERATION CHECK (2016 Basic) BASIC BRAKE SYSTEM BLEEDING (2016 Supplement) BASIC BRAKE SYSTEM BLEEDING<L.H. DRIVE VEHICLES> BRAKE FLUID LEVEL SWITCH CHECK BRAKE PAD CHECK BRAKE PAD REPLACEMENT BRAKE DISC CHECK BRAKE DRAG FORCE CHECK BRAKE LINING THICKNESS CHECK BRAKE DRUM INSIDE DIAMETER CHECK BRAKE LINING AND BRAKE DRUM CONTACT CHECKBRAKE PEDAL (2016 Basic) BRAKE PEDAL REMOVAL AND INSTALLATION (2016 Supplement) BRAKE PEDAL REMOVAL AND INSTALLATION<L.H. DRIVE VEHICLES>INSPECTIONMASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY (2016 Basic) MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<4D5, 4N1> (2016 Supplement) MASTER CYLINDER ASSEMBLY AND BRAKE BOOSTER ASSEMBLY REMOVAL AND INSTALLATION<6B3> MASTER CYLINDER ASSEMBLY DISASSEMBLY AND REASSEMBLY MASTER CYLINDER ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)FRONT DISC BRAKE ASSEMBLY FRONT DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION (2016 Basic) FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY<16 INCH> (2016 Basic) FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY<17 INCH> (2016 Supplement) FRONT DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY<4D5> FRONT DISC BRAKE ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)REAR DISC BRAKE ASSEMBLY REAR DISC BRAKE ASSEMBLY REMOVAL AND INSTALLATION REAR DISC BRAKE ASSEMBLY INSPECTION REAR DISC BRAKE ASSEMBLY DISASSEMBLY AND REASSEMBLY REAR DISC BRAKE ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)REAR DRUM BRAKE (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATIONS SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS ABS WARNING LAMP INSPECTION (2016 Basic) DIAGNOSIS FUNCTION (2016 Supplement) DIAGNOSIS FUNCTION (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. C1200, C1205, C1210, C1215 ABS SENSOR (OPEN CIRCUIT OR SHORT CIRCUIT) CODE NO. C1202, C1207, C1212, C1217 WHEEL SPEED SENSOR SYSTEM MALFUNCTION (POWER CIRCUIT) CODE NO. C1011, C101C, C1027, C1032 ABNORMALITY IN WHEEL SPEED SENSOR SIGNAL (2016 Basic) CODE NO. C1014, C101F, C102A, C1035 MUTUAL MONITORING OF WHEEL SPEED SENSOR (2016 Supplement) CODE NO. C1014, C101F, C102A, C1035 MUTUAL MONITORING OF WHEEL SPEED SENSOR CODE NO. C1041, C1042, C1043 or C1044 (2016 Basic) CODE NO. C1046, C1047, C1048 or C1049 (2016 Supplement) CODE NO. C1046, C1047, C1048 or C1049 CODE NO. C1225 TYRE DIAMETER OUT OF SPECIFICATION CODE NO. C1226, C1231, C1236, C1241, C1246, C1251, C1256, C1261, C1278, C1279 CONTROL SOLENOID VALVE PRESSURE HOLDING SYSTEM CODE NO. C1266, C1273, C1274 MOTOR SYSTEM CODE NO. C1278, C1279 VALVE RELAY SYSTEM CODE NO. C1860 ABS-ECU POWER SUPPLY HIGH VOLTAGE CODE NO. C1861 ABS-ECU POWER SUPPLY LOW VOLTAGE CODE NO. C1340 STOP LAMP SWITCH OPEN CIRCUIT CODE NO. C1620 IMPROPERLY INSTALLED ABS-ECU CODE NO.C1707 IMPLAUSIBLE CODING DATA CODE NO. C2206 CODE NO. U1073 BUS OFF CODE NO. U1108 METER CAN TIMEOUT ERROR CODE NO. U1109 ETACS CAN TIMEOUT ERROR CODE NO. U1195 VARIANT CODING NOT COMPLETED (2016 Supplement) CODE NO. C1294 ABNORMAL REAR DIFFERENTIAL LOCK DETECTION CIRCUIT (2016 Supplement) CODE NO. C1381 G-SENSOR SYSTEM (2016 Supplement) CODE NO. C1392 INCOMP. LEARN NEUTRAL (LONGITUDINAL G) (2016 Supplement) CODE NO. U1118 4WD/Transfer ECU CAN timeout SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III cannot communicate with ABS-ECU BRAKE WARNING LAMP STAYS ON WITH THE PARKING BRAKE LEVER RELEASED. ABS WARNING LAMP DOES NOT ILLUMINATE WHEN IGNITION SWITCH IS TURNED TO THE ON POSITION (ENGINE STOPPED). ABS WARNING LAMP STAYS ON AFTER THE ENGINE IS STARTED. ABS-ECU POWER SUPPLY CIRCUIT SYSTEM BRAKES DO NOT FUNCTION NORMALLY. ABS OPERATES TOO FREQUENTLY. THE INITIAL CHECK SOUND OF HYDRAULIC UNIT LOUD ABS SYSTEM INOPERATIVE (2016 Basic) DATA LIST REFERENCE TABLE (2016 Supplement) DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE WHEEL SPEED SENSOR OUTPUT CURRENT MEASUREMENT HYDRAULIC UNIT CHECK REMEDY FOR A DISCHARGED BATTERY (2016 Supplement) CALIBRATIONHYDRAULIC UNITWHEEL SPEED SENSOR (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) (2016 Basic) SPECIAL TOOLS (2017 Supplement) SPECIAL TOOL(S)TROUBLESHOOTING<ASTC-ECU> DIAGNOSIS TROUBLESHOOTING FLOW NOTES WITH REGARD TO DIAGNOSIS BRAKE WARNING LAMP, ABS WARNING LAMP, ASTC INDICATOR LAMP, ASTC OFF INDICATOR LAMP INSPECTION (2016 Basic) DIAGNOSIS FUNCTION (2017 Supplement) DIAGNOSIS FUNCTION (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHART (2017 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE NO. C1011, C101C, C1027, C1032 ABNORMALITY IN WHEEL SPEED SENSOR SIGNAL CODE NO. C1014, C101F, C102A, C1035 MUTUAL MONITORING OF WHEEL SPEED SENSOR CODE NO. C1041, 1042, 1043, 1044 WHEEL SPEED SENSOR SIGNAL IMPLAUSIBLE IN CYCLES CODE NO. C1200, C1205, C1210, C1215 WHEEL SPEED SENSOR SYSTEM (OPEN CIRCUIT OR SHORT TO EARTH OR POWER SUPPLY) CODE NO. C1225 WHEEL SPEED SENSOR SYSTEM (SENSOR OUTPUT ERROR) CODE NO. C1226, C1231, C1236, C1241, C1246, C1251, C1256, C1261, C1300, C1305, C1310, C1315 CONTROL SOLENOID VALVE SYSTEM CODE NO. C1266, C1271, C1273, C1274 MOTOR SYSTEM CODE NO. C1276, C1278, C1279 VALVE RELAY SYSTEM CODE NO. C1294 ABNORMAL REAR DIFFERENTIAL LOCK DETECTION CIRCUIT CODE NO. C1295 TRANSFER POSITION ERROR CODE NO. C1340 STOP LAMP SWITCH SIGNAL ERROR CODE NO. C1346 ABNORMAL STOP LAMP CIRCUIT CODE NO. C1364 INTERNAL MALFUNCTION OF PRESSURE SENSOR CODE NO. C1366 LATERAL G-SENSOR SIGNAL ERROR CODE NO. C1392 INCOMP. LEARN NEUTRAL (LONGITUDINAL G) CODE NO. C1394 STEERING WHEEL SENSOR NEUTRAL POINT NOT LEARNED CODE NO. C1395 BRAKE FLUID FILLING NOT COMPLETED CODE NO. C1396 ENGINE TORQUE INTERVENTION REJECTED CODE NO. C1505 STEERING WHEEL SENSOR ERROR CODE NO. C1607 MALFUNCTION OF ASC-ECU CODE NO. C1608 EEPROM FAIL CODE NO. C1707 IMPLAUSIBLE CODING DATA CODE NO. C1860 ABNORMAL RISE OF ASC-ECU POWER SUPPLY VOLTAGE CODE NO. C1861 ABNORMAL DROP OF ASC-ECU POWER SUPPLY VOLTAGE CODE NO. C2206 RE-EXECUTION OF VARIANT CODING CODE NO. U0146 GATEWAY CAN timeout CODE NO. U0401 ENGINE CAN MESSAGE CODE NO. U0402 T/M CAN MESSAGE CODE NO. U0428 SAS CAN MESSAGE CODE NO. U1011 ACC/FCM Parity/Toggle bit error CODE NO. U1014 FCM (CAN message) CODE NO. U1073 BUS-OFF CODE NO. U1100 ENGINE-RELATED CAN TIME-OUT ERROR CODE NO. U1101 T/M CAN TIMEOUT CODE NO. U1104 STEERING WHEEL SENSOR CAN TIME-OUT ERROR CODE NO. U1108 METER CAN TIMEOUT/NOT EQUIPPED CODE NO. U1109 ETACS CAN TIMEOUT/NOT EQUIPPED CODE NO. U1118 4WD/Transfer ECU CAN timeout CODE NO. U1195 CODING NOT COMPLETED CODE NO. U1200, U1204 SAS ERROR CODE NO. U1211 ENGINE PARITY/TOGGLE BIT ERROR CODE NO. U15A0 ACC/FCM ECU CAN timeout (2016 Supplement) CODE NO. C1291: REVERSE SIGNAL (SEIZURE)<M/T> (2017 Supplement) CODE NO. C1804: ACC Deactivation Disagreement<Vehicles with ACC/FCM> SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III communication with ASTC system is impossible. ASTC INDICATOR LAMP FLASHES AT A RATE OF 2HZ WHEN THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION (ENGINE STOPPED), THE BRAKE WARNING LAMP DOES NOT ILLUMINATE. WHEN THE IGNITION SWITCH IS TURNED TO THE "ON" POSITION (ENGINE STOPPED), THE ABS WARNING LAMP DOES NOT ILLUMINATE. BRAKE WARNING LAMP DOES NOT ILLUMINATE WHEN THE IGNITION SWITCH IS TURNED TO ON POSITION (ENGINE STOPPED). ABS WARNING LAMP STAYS ON AFTER THE ENGINE IS STARTED. THE ASTC INDICATOR LAMP REMAINS ILLUMINATED AFTER THE ENGINE IS STARTED. THE ASTC OFF INDICATOR LAMP REMAINS ILLUMINATED AFTER THE ENGINE IS STARTED. WHEN THE TCL SWITCH IS PUSHED, TCL SYSTEM CANNOT BE DISABLED. ABNORMALITY IN BRAKE OPERATION ABNORMAL ACTIVE STABILITY CONTROL SYSTEM OPERATION TCL/ACTIVE STABILITY CONTROL SYSTEM-ECU POWER SUPPLY CIRCUIT SYSTEM ABS/STABILITY CONTROL/TCL OPERATES TOO FREQUENTLY. HSA DOES NOT WORK. HSA WORKS ON A FLAT ROAD. THE INITIAL CHECK SOUND OF HYDRAULIC UNIT LOUD Hill descent control does not work. Hill descent control is activated or deactivated by operating the hill descent control switch. Off-road mode does not work. Off-road mode is not switched by operating the off-road mode selector. ESS INOPERATIVE OR IMPROPER OPERATIVE DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALTROUBLESHOOTING<STEERING WHEEL SENSOR> DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES SYMPTOM CHARTSYMPTOM PROCEDURES SPECIAL FUNCTION TABLE CHECK AT ECU TERMINALTROUBLESHOOTING<FCM system in ACC/FCM-ECU> DIAGNOSIS TROUBLESHOOTING FLOW (2016 Basic) DIAGNOSIS FUNCTION (2017 Supplement) DIAGNOSIS FUNCTION (2016 Basic) DIAGNOSIS CODE CHART (2017 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES (2016 Basic) CODE NO. C1394 INCOMP.learn neutral(SAS) (2017 Supplement) CODE NO. C1394 INCOMP.learn neutral(SAS) (2016 Basic) CODE NO. C1707 Implausible coding data (2017 Supplement) CODE NO. C1707 Implausible coding data (2016 Basic) CODE NO. C1750 ACC/FCM voltage out of range (2017 Supplement) CODE NO. C1750 Voltage out of range (2016 Basic) CODE NO. C1751 ACC/FCM ECU failure (2017 Supplement) CODE NO. C1751 ECU failure (2016 Basic) CODE NO. C1752 ACC/FCM radar TEMP.out of range (2017 Supplement) CODE NO. C1752 Radar temperature out of range (2016 Basic) CODE NO. C1753 ACC/FCM radar blockage detected (2017 Supplement) CODE NO. C1753 Radar blockage detected (2016 Basic) CODE NO. C1754 ACC/FCM radar CAL. Not COMP (2017 Supplement) CODE NO. C1754 Radar calibration not completed (2016 Basic) CODE NO. C1772 Alignment sensor too far (Right) (2017 Supplement) CODE NO. C1772 Alignment sensor too far (Right) (2016 Basic) CODE NO. C1773 Alignment sensor too far (Left) (2017 Supplement) CODE NO. C1773 Alignment sensor too far (Left) (2016 Basic) CODE NO. C1774 Alignment sensor too far (Lower) (2017 Supplement) CODE NO. C1774 Alignment sensor too far (Lower) (2016 Basic) CODE NO. C1775 Alignment sensor too far (Upper) (2017 Supplement) CODE NO. C1775 Alignment sensor too far (Upper) (2016 Basic) CODE NO. C1777 ACC system fail detected (ASC) (2017 Supplement) CODE NO. C1777 System fail detected (ASC) (2016 Basic) CODE NO. C1781 SAS internal fail (2017 Supplement) CODE NO. C1781 SAS internal fail (2016 Basic) CODE NO. C1782 SAS signal fail (2017 Supplement) CODE NO. C1782 SAS signal fail (2016 Basic) CODE NO. C1784 FCM switch fixed ON (2017 Supplement) CODE NO. C1784 FCM switch fixed ON (2016 Basic) CODE NO. C1785 Fault detect signal fail (2017 Supplement) CODE NO. C1785 Fault detect signal fail (2016 Basic) CODE NO. C1787 APS signal (2017 Supplement) CODE NO. C1787 APS signal (2016 Basic) CODE NO. C1792 Brake M/C PRS. signal (invalid) (2017 Supplement) CODE NO. C1792 Brake M/C PRS. signal (invalid) (2016 Basic) CODE NO. C1794 Longitudinal G signal (invalid) (2017 Supplement) CODE NO. C1794 Longitudinal G signal (invalid) (2016 Basic) CODE NO. C1795 Yaw rate signal (invalid) (2017 Supplement) CODE NO. C1795 Yaw rate signal (invalid) (2016 Basic) CODE NO. C1796 APS signal (invalid) (2017 Supplement) CODE NO. C1796 APS signal (invalid) (2016 Basic) CODE NO. C1808 Noise error (2017 Supplement) CODE NO. C1808 Noise error (2016 Basic) CODE NO. C2256 Brake switch signal fail (2017 Supplement) CODE NO. C2256 Brake switch signal fail (2016 Basic) CODE NO. C2257 ASC signal failure 1 (2017 Supplement) CODE NO. C2257 ASC signal failure 1 (2016 Basic) CODE NO. C2262 SAS offset threshold exceed (2017 Supplement) CODE NO. C2262 SAS offset threshold exceed (2016 Basic) CODE NO. C2263 Yaw rate offset threshold exceed (2017 Supplement) CODE NO. C2263 Yaw rate offset threshold exceed (2016 Basic) CODE NO. C2264 Estimated tyre size exceed (2017 Supplement) CODE NO. C2264 Estimated tyre size exceed (2016 Basic) CODE NO. C2265 Unavailable reference velocity (2017 Supplement) CODE NO. C2265 Unavailable reference velocity (2016 Basic) CODE NO. C2266 Unavailable of Yaw rate quality (2017 Supplement) CODE NO. C2266 Unavailable of Yaw rate quality (2016 Basic) CODE NO. C2267 Wheel speed signal fail (2017 Supplement) CODE NO. C2267 Wheel speed signal fail (2016 Basic) CODE NO. C2268 Distance travelled signal fail (2017 Supplement) CODE NO. C2268 Distance travelled signal fail (2016 Basic) CODE NO. C2270 Current gear signal fail (2017 Supplement) CODE NO. C2270 Current gear signal fail (2016 Basic) CODE NO. C2271 SAS signal fail (2017 Supplement) CODE NO. C2271 SAS signal fail (2016 Basic) CODE NO. C2272 Delta SAS signal fail (2017 Supplement) CODE NO. C2272 Delta SAS signal fail (2016 Basic) CODE NO. C2273 T/F state signal (2017 Supplement) CODE NO. C2273 T/F state signal (2016 Basic) CODE NO. C2275 Rear diff. lock state signal (2017 Supplement) CODE NO. C2275 Rear diff. lock state signal (2016 Basic) CODE NO. C2277 Engine status signal (2017 Supplement) CODE NO. C2277 Engine status signal (2016 Basic) CODE NO. U0100 Engine CAN timeout (2017 Supplement) CODE NO. U0100 Engine CAN timeout (2016 Basic) CODE NO. U0101 T/M CAN timeout (2017 Supplement) CODE NO. U0101 T/M CAN timeout (2016 Basic) CODE NO. U0114 4WD/Transfer ECU CAN timeout (2017 Supplement) CODE NO. U0114 4WD/Transfer ECU CAN timeout (2016 Basic) CODE NO. U0121 ABS/ASC CAN timeout (2017 Supplement) CODE NO. U0121 ABS/ASC CAN timeout (2016 Basic) CODE NO. U0126 SAS CAN timeout (2017 Supplement) CODE NO. U0126 SAS CAN timeout (2016 Basic) CODE NO. U0141 ETACS CAN timeout (2017 Supplement) CODE NO. U0141 ETACS CAN timeout (2016 Basic) CODE NO. U0155 Meter CAN timeout (2017 Supplement) CODE NO. U0155 Meter CAN timeout (2016 Basic) CODE NO. U1195 Coding not completed (2017 Supplement) CODE NO. U1195 Coding not completed (2016 Basic) SYMPTOM CHART (2017 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2016 Basic) M.U.T.-III CANNOT COMMUNICATE WITH FCM-ECU (2017 Supplement) M.U.T.-III CANNOT COMMUNICATE WITH FCM-ECU (2016 Basic) THE FCM CANNOT BE TURNED ON OR OFF WHEN THE FCM ON/OFF SWITCH IS OPERATED. (2017 Supplement) THE FCM CANNOT BE TURNED ON OR OFF WHEN THE FCM ON/OFF SWITCH IS OPERATED. (2016 Basic) THE FCM IS CANCELLED IN CONJUNCTION WITH A WARNING MESSAGE WHILE THE FCM IS ACTIVATED. (2017 Supplement) THE FCM IS CANCELLED IN CONJUNCTION WITH A WARNING MESSAGE WHILE THE FCM IS ACTIVATED. (2016 Basic) DATA LIST REFERENCE TABLE (2017 Supplement) DATA LIST REFERENCE TABLE (2016 Basic) SPECIAL FUNCTION TABLE (2017 Supplement) SPECIAL FUNCTION TABLE (2016 Basic) CHECK AT ECU TERMINAL (2017 Supplement) CHECK AT ECU TERMINALON-VEHICLE SERVICE WHEEL SPEED SENSOR OUTPUT CURRENT MEASUREMENT HYDRAULIC UNIT CHECK REMEDY FOR A DISCHARGED BATTERY CALIBRATION (2016 Basic) FCM-ECU (RADAR) CALIBRATION (2017 Supplement) FCM-ECU (RADAR) CALIBRATIONASC OFF SWITCHHYDRAULIC UNITWHEEL SPEED SENSORSTEERING WHEEL SENSORHILL DESCENT CONTROL SWITCHOFF ROAD MODE SELECTORFCM-ECUFORWARD COLLISION MITIGATION SYSTEM (FCM) AND ULTRASONIC MISACCELERATION MITIGATION SYSTEM (UMS) ON/OFF SWITCH (2016 Basic) GENERAL INFORMATION (2016 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING<Electric parking brake> DIAGNOSIS TROUBLESHOOTING FLOW WARNING LAMP INSPECTION DIAGNOSIS FUNCTION DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES CODE No. C1271 MOTOR DRIVE CIRCUIT CODE No. C1471 STOP LAMP SWITCH CODE No. C1607 ECU FAILURE CODE No. C1861 POWER SUPPLY LOW VOLTAGE CODE No. C2250 ACTUATOR MALFUNCTION CODE No. C2251 TENSION SENSOR MALFUNCTION CODE No. C2252 +B VOLTAGE MALFUNCTION CODE No. C2253 EPB SW MALFUNCTION CODE No. C2254 IG SW MALFUNCTION CODE No. U0100 ENGINE CAN TIMEOUT CODE No. U0101 T/M CAN TIMEOUT CODE No. U0121 ABS/ASC CAN TIMEOUT CODE No. U0141 ETACS CAN TIMEOUT CODE No. U0155 METER CAN TIMEOUT CODE No. U0401 ENGINE (CAN MESSAGE) CODE No. U0402 T/M (CAN MESSAGE) CODE No. U0415 ABS/ASC (CAN MESSAGE) CODE No. U1073 BUS-OFF SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III CANNOT COMMUNICATE WITH THE ELECTRIC PARKING BRAKE SYSTEM (POWER SUPPLY CIRCUIT FOR THE ELECTRIC PARKING BRAKE ECU FAILS). THE ELECTRIC PARKING BRAKE WARNING LAMP ILLUMINATES WHEN THE IGNITION SWITCH IS TURNED ON. THE ELECTRIC PARKING BRAKE IS NOT RELEASED. THE ELECTRIC PARKING BRAKE IS NOT APPLIED (LOCKED). THE BRAKE SHOE DRAGS ON THE DRUM OR DISC AFTER THE ELECTRIC PARKING BRAKE IS RELEASED. THE PARKING BRAKING FORCE IS POOR AFTER THE ELECTRIC PARKING BRAKE IS APPLIED (LOCKED). DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE CHECK AT ECU TERMINALON-VEHICLE SERVICE (2016 Basic) PARKING BRAKE LEVER STROKE CHECK AND ADJUSTMENT<Lever type parking brake> (2016 Supplement) PARKING BRAKE LEVER STROKE CHECK AND ADJUSTMENT<Lever type parking brake> PARKING BRAKE ADJUSTMENT<Electric parking brake> PARKING BRAKE SWITCH CHECK<Lever type parking brake> (2016 Basic) PARKING BRAKE LINING SEATING PROCEDURE<Electric parking brake> (2016 Supplement) PARKING BRAKE LINING SEATING PROCEDURE<Lever type parking brake> HOW TO INITIALISE LEARNT VALUE FOR THE ELECTRIC PARKING BRAKE ACTUATOR HOW TO RELEASE THE ELECTRIC PARKING BRAKE MANUALLYPARKING BRAKE LEVER<Lever type parking brake>PARKING BRAKE CABLE (2016 Basic) PARKING BRAKE CABLE REMOVAL AND INSTALLATION<Lever type parking brake> (2016 Basic) PARKING BRAKE CABLE REMOVAL AND INSTALLATION<Electric parking brake> (2016 Supplement) PARKING BRAKE CABLE REMOVAL AND INSTALLATION<Lever type parking brake>PARKING BRAKE LINING AND DRUM<Vehicles with rear disc brake> (2016 Basic) PARKING BRAKE LINING AND DRUM REMOVAL AND INSTALLATION (2016 Supplement) PARKING BRAKE LINING AND DRUM REMOVAL AND INSTALLATION<Lever type parking brake> PARKING BRAKE LINING AND DRUM INSPECTIONELECTRIC PARKING BRAKE SWITCHELECTRIC PARKING BRAKE ECUELECTRIC PARKING BRAKE ACTUATOR (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SEALANT(S) AND ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING (2016 Supplement) SYMPTOM CHART<VEHICLES WITH HEATED STEERING WHEEL>SYMPTOM PROCEDURES<VEHICLES WITH HEATED STEERING WHEEL>ON-VEHICLE SERVICE STEERING WHEEL FREE PLAY CHECK STEERING ANGLE CHECK BALL JOINT DUST COVER INSPECTION TIE ROD END BALL JOINT STARTING TORQUE CHECK STATIONARY STEERING EFFORT CHECK STEERING WHEEL RETURN TO CENTRE CHECK DRIVE-BELT TENSION CHECK FLUID LEVEL CHECK FLUID CHANGE POWER STEERING SYSTEM AIR BLEEDING OIL PUMP PRESSURE TEST POWER STEERING FLUID PRESSURE SWITCH CHECK STEERING COLUMN SHAFT ASSEMBLY SHOCK ABSORBING MECHANISM CHECK (2016 Supplement) POWER RELAY CHECKSTEERING WHEEL (2016 Basic) STEERING WHEEL REMOVAL AND INSTALLATION (2016 Supplement) STEERING WHEEL REMOVAL AND INSTALLATION<VEHICLES WITH HEATED STEERING WHEEL>STEERING COLUMN SHAFT ASSEMBLY STEERING COLUMN SHAFT ASSEMBLY REMOVAL AND INSTALLATION STEERING COLUMN SHAFT ASSEMBLY DISASSEMBLY AND REASSEMBLYPOWER STEERING GEAR BOX AND LINKAGE (2016 Basic) POWER STEERING GEAR BOX AND LINKAGE REMOVAL AND INSTALLATION (2016 Supplement) POWER STEERING GEAR BOX AND LINKAGE REMOVAL AND INSTALLATION<L.H. DRIVE VEHICLES> INSPECTION (2016 Basic) POWER STEERING GEAR BOX AND LINKAGE DISASSEMBLY AND REASSEMBLY (2016 Supplement) POWER STEERING GEAR BOX AND LINKAGE DISASSEMBLY AND REASSEMBLY<L.H. DRIVE VEHICLES>POWER STEERING OIL PUMP ASSEMBLY (2016 Basic) POWER STEERING OIL PUMP ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) POWER STEERING OIL PUMP ASSEMBLY REMOVAL AND INSTALLATION<4D5> POWER STEERING OIL PUMP ASSEMBLY INSPECTION (2016 Basic) POWER STEERING OIL PUMP ASSEMBLY DISASSEMBLY AND REASSEMBLY (2016 Supplement) POWER STEERING OIL PUMP ASSEMBLY DISASSEMBLY AND REASSEMBLY<4D5> POWER STEERING OIL PUMP ASSEMBLY INSPECTION (DISASSEMBLY AND REASSEMBLY)POWER STEERING HOSES (2016 Basic) POWER STEERING HOSES REMOVAL AND INSTALLATION (2016 Supplement) POWER STEERING HOSES REMOVAL AND INSTALLATION<L.H. DRIVE VEHICLES> (2017 Supplement) POWER STEERING HOSES REMOVAL AND INSTALLATION<VEHICLES WITHOUT OIL COOLER TUBE (6B3-RHD)>HEATED STEERING WHEEL SWITCH<VEHICLES WITH HEATED STEERING WHEEL> (2016 Supplement) GENERAL INFORMATIONHOODON-VEHICLE SERVICE ADJUSTMENT OF CLEARANCE AROUND HOOD ADJUSTMENT OF ALIGNMENT OF HOOD STEPPED PORTION AND HOOD STRIKER ADJUSTMENT OF HOOD HEIGHTHOODFENDERFUEL FILLER LID (2016 Basic) FUEL FILLER LID REMOVAL AND INSTALLATION (2016 Supplement) FUEL FILLER LID REMOVAL AND INSTALLATION<LH DRIVE VEHICLES>SPLASH SHIELDWINDOW GLASS (2016 Basic) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION (2016 Basic) SEALANT(S) OR ADHESIVE(S) (2017 Supplement) SEALANT(S) OR ADHESIVE(S) (2016 Basic) LUBRICANT(S) (2017 Supplement) LUBRICANT(S) (2016 Basic) SPECIAL TOOL(S) (2017 Supplement) SPECIAL TOOL(S)WINDSHIELD (2016 Basic) WINDSHIELD REMOVAL AND INSTALLATION (2017 Supplement) WINDSHIELD REMOVAL AND INSTALLATIONQUARTER WINDOW GLASSTAILGATE WINDOW GLASSDOOR (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S)TROUBLESHOOTING (2016 Basic) SYMPTOM CHART<CENTRAL DOOR LOCKING SYSTEM> (2017 Supplement) SYMPTOM CHART<CENTRAL DOOR LOCKING SYSTEM>SYMPTOM PROCEDURES<CENTRAL DOOR LOCKING SYSTEM> CENTRAL DOOR LOCKING SYSTEM DOES NOT OPERATE SOME DOORS DO NOT LOCK OR UNLOCK SELECTOR "P" POSITION-LINKED DOOR UNLOCK FUNCTION DOES NOT OPERATE.<A/T> VEHICLE-SPEED SENSITIVE AUTOMATIC DOOR LOCK FUNCTION DOES NOT WORK NORMALLY. IGNITION "OFF"POSITION-LINKED DOOR UNLOCKING FUNCTION DOES NOT OPERATE.<Vehicles for General Export (without keyless opera> (2017 Supplement) CENTRAL DOOR LOCK SYSTEM DOES NOT OPERATE EVEN WHEN DOOR LOCK SWITCH OF POWER WINDOW MAIN SWITCH OPERATED. (2016 Basic) SYMPTOM CHART<POWER WINDOW> (2016 Supplement) SYMPTOM CHART<POWER WINDOW (Vehicles without (anti-trap) safety)>SYMPTOM PROCEDURES<POWER WINDOW> (2016 Basic) POWER WINDOWS DO NOT WORK AT ALL (2016 Supplement) POWER WINDOWS DO NOT WORK AT ALL<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Basic) POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW (2016 Supplement) POWER WINDOW MAIN SWITCH CANNOT OPERATE DRIVER''S WINDOW<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Basic) POWER WINDOW SUB SWITCH CANNOT OPERATE PASSENGER''S OR REAR WINDOWS. (2016 Supplement) POWER WINDOW SUB SWITCH CANNOT OPERATE PASSENGER''S OR REAR WINDOWS.<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Basic) POWER WINDOW MAIN SWITCH CANNOT OPERATE EITHER OF PASSENGER''S OR REAR POWER WINDOWS (2016 Supplement) POWER WINDOW MAIN SWITCH CANNOT OPERATE EITHER OF PASSENGER''S OR REAR POWER WINDOWS<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Basic) POWER WINDOW TIMER FUNCTION DOES NOT WORK NORMALLY (2016 Supplement) POWER WINDOW TIMER FUNCTION DOES NOT WORK NORMALLY<POWER WINDOW (Vehicles without (anti-trap) safety)> POWER WINDOW ANTI-TRAP FUNCTION DOES NOT WORK<DRIVER SIDE DOOR> WHEN THE GLASS IS RAISED, THEN IT LOWERS AUTOMATICALLY<DRIVER SIDE DOOR> POWER WINDOW MAIN SWITCH ONE-TOUCH FUNCTION DOES NOT WORK (2016 Supplement) Front right power window does not work<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Supplement) Front left power window does not work<POWER WINDOW (Vehicles without (anti-trap) safety)> (2016 Basic) CHECK AT ECU TERMINAL<POWER WINDOW> (2016 Supplement) CHECK AT ECU TERMINAL<POWER WINDOW> (2017 Supplement) CHECK AT ECU TERMINAL<POWER WINDOW>ON-VEHICLE SERVICE DOOR FIT ADJUSTMENT DOOR WINDOW GLASS ADJUSTMENT POWER WINDOW CHECK GLASS SLIDING MECHANISM CHECK AND ADJUSTMENT POWER WINDOW SAFETY MECHANISM CHECK POWER WINDOW TIMER FUNCTION CHECK POWER WINDOW OPERATING CURRENT CHECK POWER WINDOW RELAY CHECK POWER WINDOW INITIALIZED ADJUSTMENT CENTRAL DOOR LOCKING SYSTEM INSPECTION CHECK OF KEY LOCK PREVENTION FUNCTION SHIFT "P" INTERLINK DOOR UNLOCK FUNCTION CHECK<A/T> VEHICLE-SPEED SENSITIVE AUTOMATIC DOOR LOCK FUNCTION INSPECTION IGNITION "OFF" POSITION-LINKED DOOR UNLOCKING FUNCTION CHECK (2016 Basic) DOOR HANDLE AND LATCH INSPECTION (2016 Supplement) DOOR HANDLE AND LATCH INSPECTION DOOR OUTSIDE HANDLE PLAY CHECK DOOR INSIDE HANDLE PLAY ADJUSTMENT CUSTOMISATION FUNCTIONDOOR ASSEMBLYDOOR GLASS AND REGULATOR DOOR GLASS AND REGULATOR REMOVAL AND INSTALLATION (2016 Basic) DOOR GLASS AND REGULATOR INSPECTION (2016 Supplement) DOOR GLASS AND REGULATOR INSPECTIONDOOR HANDLE AND LATCH DOOR HANDLE AND LATCH REMOVAL AND INSTALLATION<DOUBLE CAB AND SINGLE CAB> (2016 Basic) INSPECTION (2017 Supplement) INSPECTIONWINDOW GLASS RUNCHANNEL AND DOOR OPENING WEATHERSTRIPTAILGATE SEALANT(S) OR ADHESIVE(S) SPECIAL TOOL(S) TROUBLESHOOTINGON-VEHICLE SERVICETAILGATETAILGATE HANDLE AND LATCHKEYLESS ENTRY SYSTEM<Vehicles without keyless operation system> SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING SYMPTOM CHARTSYMPTOM PROCEDURES KEYLESS ENTRY SYSTEM DOES NOT OPERATE THE DOME LAMP, THE HAZARD WARNING LAMPS AND THE HORN DO NOT OPERATE THROUGH THE ANSWERBACK FUNCTION. AFTER THE DOORS ARE UNLOCKED BY USING THE KEYLESS ENTRY SYSTEM, THE TIMER LOCK FUNCTION DOES NOT WORK. MULTIMODE KEYLESS ENTRY FUNCTION DOES NOT WORK AT ALL.ON-VEHICLE SERVICE KEYLESS ENTRY SYSTEM INSPECTION KEYLESS ENTRY SYSTEM TIMER LOCK FUNCTION INSPECTION MULTIMODE KEYLESS ENTRY FUNCTION CHECK METHOD OF REGISTERING A SECRET CODE CUSTOMISATION FUNCTIONTRANSMITTERBODY MOUNTINGLOOSE PANEL (2016 Basic) LOOSE PANEL REMOVAL AND INSTALLATION (2016 Supplement) LOOSE PANEL REMOVAL AND INSTALLATION HEADLAMP SUPPORT PANEL UPPER REMOVAL AND INSTALLATION (2016 Basic) SPECIAL TOOL(S) (2016 Supplement) SPECIAL TOOL(S) (2016 Basic) FRONT DECK PANEL REMOVAL AND INSTALLATION (2016 Supplement) FRONT DECK PANEL REMOVAL AND INSTALLATIONSUNROOF ASSEMBLY (2016 Supplement) SERVICE SPECIFICATION(S) (2016 Supplement) LUBRICANT(S)TROUBLESHOOTINGSYMPTOM PROCEDURES (2016 Supplement) SUNROOF DOES NOT OPERATE (2016 Supplement) ANY OF THE SUNROOF SWITCH POSITION IS DEFECTIVE (2016 Supplement) SUNROOF ANTI-TRAP FUNCTION DOES NOT WORK (2016 Supplement) CHECK AT ECU TERMINALON-VEHICLE SERVICE (2016 Supplement) WATER TEST (2016 Supplement) SUNROOF FIT ADJUSTMENT (2016 Supplement) SUNROOF SAFETY FUNCTION CHECK (2016 Supplement) SUNROOF OPERATION CHECK (2016 Supplement) ROOF LID GLASS OPERATION CURRENT CHECK (2016 Supplement) SUNROOF INITIALIZED ADJUSTMENTSUNROOF ASSEMBLY (2016 Supplement) GENERAL INFORMATION SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW DIAGNOSIS FUNCTION TROUBLESHOOTING PROCEDURE WHEN VEHICLE POWER DOES NOT TURN ON FORCED POWER SUPPLY OUTPUT PROCEDURE WARNING AND WARNING INDICATOR LIST (2016 Basic) DIAGNOSIS CODE CHART (2016 Supplement) DIAGNOSIS CODE CHARTDIAGNOSIS CODE PROCEDURES B1130 Power output status unmatched B1131 Starter output internal fail B1132 Starter output external fail B1133 IG1 output internal fail B1134 ECU power supply B1135 Push start switch B1136 Stop lamp switch (2016 Basic) B1137 P range detect SW (2016 Supplement) B1137 P range detect SW<Vehicles with 4D5> (2016 Basic) B1138 Vehicle speed data fail (2016 Supplement) B1138 Vehicle speed data fail<Vehicles with 4D5> B1141 ESL authenticate timeout B1142 ESL authenticate error B1143 ESL status unmatched B1144 ESL lock/unlock fail B1145 ESL power supply circuit B1146 ESL drive circuit B1147 ESL LIN communication fail B1148 ESL power control B1149 KOS power control monitor input B1150 OSS authenticate timeout(ESL) B1155 EEPROM fail(ESL) B1156 Power supply voltage fail B1157 OSS EEPROM fail B1160 Key code not programmed B1161 Chassis No. mismatch B1163 Coding data mismatch B1164 Chassis No. not programmed(ESL) B1166 Special mode B1168 ACC system fail B1169 IG2 system fail (2016 Basic) B1731 Engine ECU communication timeout (2016 Supplement) B1731 Engine ECU communication timeout<Vehicles with M/T or 4D5> B1A08 KOS Key 1 Malfunction B1A10 KOS Key 1 Low Battery B1A24 Key not Registered B1A25 Key Registered to Another Vehicle (2016 Basic) B1A28 Engine ECU authenticate error (2016 Supplement) B1A28 Engine ECU authenticate error<Vehicles with M/T or 4D5> B2352 Immobilizer Antenna Malfunction B2400 KOS Key Registration Fail B2401 KOS Key ID not registered B240A FR Antenna (Outdoor) Open Circuit B240B FL Antenna (Outdoor) Open Circuit B240C Tail Gate Antenna (Outdoor) Open Circuit B240D Front Antenna (Indoor) Open Circuit B240E RR Antenna (Indoor) Open Circuit (2016 Basic) U0100 Engine CAN timeout (2016 Supplement) U0100 Engine CAN timeout<Vehicles with 4D5> U0101 T/M CAN timeout U0141 ETACS-ECU CAN Timeout U0155 Meter CAN Timeout U0164 A/C CAN Timeout U1190 No receive fault detect signal U1195 Coding not completed DATA LIST REFERENCE TABLE ACTUATOR TEST REFERENCE TABLE SPECIAL FUNCTION TABLE (2016 Basic) SYMPTOM CHART (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES M.U.T.-III CANNOT COMMUNICATE WITH KOS-ECU. KEYLESS OPERATION KEY CANNOT BE REGISTERED WITH M.U.T.-III ABNORMALITY IN KOS-ECU POWER SUPPLY AND EARTH CIRCUITS KEYLESS OPERATION WARNING LAMP DOES NOT GO OUT. NO DOOR CAN BE OPERATED BY OPERATING A KEYLESS OPERATION SWITCH ON ANY DOOR, OR BY TOUCHING THE TOUCH SENSOR. (2016 Basic) DRIVER''S KEYLESS OPERATION SWITCH (LOCK) DOES NOT WORK. (2016 Supplement) DRIVER''S KEYLESS OPERATION SWITCH (LOCK) DOES NOT WORK.<LHD> TAILGATE LOCK RELEASE HANDLE DOES NOT WORK. TAILGATE KEYLESS OPERATION SWITCH DOES NOT WORK. TAILGATE OPENER DOES NOT WORK. KEYLESS ENTRY SYSTEM DOES NOT WORK AT ALL. KOS TIMER LOCK FUNCTION DOES NOT WORK. KEYLESS ENTRY HAZARD ANSWERBACK FUNCTION OR THE ROOM LAMP ANSWERBACK FUNCTION DOES NOT WORK NORMALLY. MULTIMODE KEYLESS ENTRY FUNCTION DOES NOT WORK AT ALL. OUTER BUZZER DOES NOT SOUND. Vehicle power does not turn ON. (not possible with both of power supply mode ACC and ON) (2016 Basic) Engine does not start (cranking is not performed). (2016 Supplement) Engine does not start (cranking is not performed).<Vehicles with M/T or 4D5> Vehicle power cannot be turned OFF when the shift position is in "P." (Power supply mode ON to ACC is possible) Electric steering lock does not become locked. (At power supply mode OFF) ACC POWER AUTO CUT FUNCTION DOES NOT WORK NORMALLY (2016 Basic) VEHICLE POWER CANNOT BE TURNED OFF. (2016 Supplement) VEHICLE POWER CANNOT BE TURNED OFF.<Vehicles with 4D5> TERMINAL VOLTAGE REFERENCE CHARTON-VEHICLE SERVICE ID CODES REGISTRATION PROCEDURE ANTENNA COMMUNICATION TEST KEYLESS ENTRY SYSTEM INSPECTION MULTIMODE KEYLESS ENTRY FUNCTION CHECK KEYLESS ENTRY SYSTEM TIMER LOCK FUNCTION INSPECTION (2016 Basic) CHECK OF ENGINE SWITCH OPERATION FUNCTION (2016 Supplement) CHECK OF ENGINE SWITCH OPERATION FUNCTION CHECK OF ENGINE SWITCH INDICATOR FUNCTION CHECK OF ENGINE SWITCH REMINDER BUZZER RELAY INSPECTION CUSTOMIZATION FUNCTIONKOS & OSS-ECU (2016 Basic) KOS-ECU REMOVAL AND INSTALLATION (2016 Supplement) KOS-ECU REMOVAL AND INSTALLATION<VEHICLES FOR LHD>OUTSIDE TRANSMISSION ANTENNA ASSEMBLY, INSIDE TRANSMISSION ANTENNA ASSEMBLYKEYLESS OPERATION KEYLOCK/UNLOCK SWITCH<Front door>KEY SLOT (2016 Basic) KEY SLOT REMOVAL AND INSTALLATION (2016 Supplement) KEY SLOT REMOVAL AND INSTALLATION<VEHICLES WITH FRONT FLOOR CONSOLE STANDARD TYPE> KEY SLOT INSPECTIONENGINE SWITCHELECTRIC STEERING LOCK (2016 Supplement) GENERAL INFORMATIONFRONT BUMPER ASSEMBLYREAR BUMPER ASSEMBLYRADIATOR GRILLEMOULDINGSGARNISHES (2017 Supplement) GENERAL INFORMATION SEALANT(S) OR ADHESIVE(S) LUBRICANT(S) (2016 Basic) GARNISH REMOVAL AND INSTALLATION (2017 Supplement) GARNISH REMOVAL AND INSTALLATIONDOOR SASH TAPESIDE AIR DAMMUD GUARDSIDE STEPUNDER COVER (2016 Basic) UNDER COVER REMOVAL AND INSTALLATION (2016 Supplement) UNDER COVER REMOVAL AND INSTALLATIONROOF RAILWINDSHIELD WIPER AND WASHER (2017 Supplement) GENERAL INFORMATION SERVICE SPECIFICATION(S) LUBRICANT(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART THE WINDSHIELD WIPERS DO NOT WORK AT ALL THE WINDSHIELD WIPERS DO NOT WORK WHEN THE WIPER SWITCH IS AT INT, WASHER OR MIST POSITION. THE WINDSHIELD WIPERS DO NOT STOP AT THE SPECIFIED PARK POSITION THE WINDSHIELD WIPERS DO NOT WORK NORMALLY THE INTERMITTENT WIPER INTERVAL CANNOT BE ADJUSTED BY OPERATING THE WINDSHIELD INTERMITTENT WIPER VOLUME CONTROL THE INTERMITTENT WIPER INTERVAL IS NOT CHANGED ACCORDING TO THE VEHICLES SPEED THE WINDSHIELD WASHER DOES NOT WORK THE RAINDROPS SENSING WIPER FUNCTION DOES NOT WORK AT ALL.<Vehicles with lighting control sensor> THE RAINDROPS SENSING WIPER FUNCTION WORKS EVEN THOUGH THESE IS NO RAIN FALL.<Vehicles with lighting control sensor> SOMETIMES THE RAIN SENSING WIPER FUNCTION WORKS EVEN THOUGH THERE IS NO RAINFALL.<Vehicles with lighting control sensor> DATA LIST REFERENCE TABLEON-VEHICLE SERVICE WINDSHIELD INTERMITTENT WIPER INSPECTION LIGHTING CONTROL SENSOR INSPECTION CUSTOMIZATION FUNCTION (2017 Supplement) WINDSHIELD WASHER TANK FLUID LEVEL SENSOR INSPECTIONWINDSHIELD WIPER (2016 Basic) WINDSHIELD WIPER REMOVAL AND INSTALLATION (2016 Supplement) WINDSHIELD WIPER REMOVAL AND INSTALLATION WINDSHIELD WIPER INSPECTIONWINDSHIELD WASHER (2016 Basic) WINDSHIELD WASHER REMOVAL AND INSTALLATION (2017 Supplement) WINDSHIELD WASHER REMOVAL AND INSTALLATION (2016 Basic) WINDSHIELD WASHER INSPECTION (2017 Supplement) WINDSHIELD WASHER INSPECTIONLIGHTING CONTROL SENSORREAR WIPER AND WASHER SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART THE REAR WIPER DOES NOT WORK AT ALL THE REAR WIPER DOES NOT STOP AT THE SPECIFIED PARK POSITION WHEN THE SELECTOR LEVER IS MOVED TO R POSITION DURING THE REAR WIPER OPERATION, THE REAR WIPER DOES NOT OPERATE AT THE CONTINUOUS MODE<A/T> THE REAR WASHER DOES NOT WORKON-VEHICLE SERVICEREAR WIPER AND WASHERHEADLAMP WASHERMARK (2017 Supplement) GENERAL INFORMATION (2016 Basic) LUBRICANT(S) (2017 Supplement) LUBRICANT(S) (2016 Basic) MARK REMOVAL AND INSTALLATION (2016 Supplement) MARK REMOVAL AND INSTALLATION (2017 Supplement) MARK REMOVAL AND INSTALLATIONOUTSIDE MIRROR SERVICE SPECIFICATION(S) SPECIAL TOOL(S)TROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW (2016 Basic) SYMPTOM CHART (2016 Supplement) SYMPTOM CHART ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR DOES NOT WORK AT ALL LEFT OR RIGHT SIDE ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR DOES NOT WORK ELECTRIC RETRACTABLE REMOTE CONTROLLED DOOR MIRROR TIMER FUNCTION DOES NOT WORK VEHICLE SPEED-DEPENDENT UNFOLDING FUNCTION DOES NOT WORK NORMALLY INSPECTION OF IGNITION SWITCH POSITION-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS INSPECTION OF KEYLESS ENTRY SYSTEM-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS (2016 Supplement) ALL HEATED DOOR MIRRORS DO NOT OPERATE (2016 Supplement) RIGHT OR LEFT HEATED DOOR MIRROR DOES NOT OPERATEON-VEHICLE SERVICE INSPECTION OF OUTSIDE MIRROR VEHICLE SPEED-DEPENDENT AUTOMATIC UNFOLDING FUNCTION INSPECTION OF IGNITION SWITCH POSITION-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS INSPECTION OF KEYLESS ENTRY SYSTEM-LINKED FOLDING AND UNFOLDING FUNCTION FOR OUTSIDE MIRRORS INSPECTION OF OUTSIDE MIRROR TIMER FUNCTION CUSTOMIZATION FUNCTIONOUTSIDE MIRRORTAILGATE SPOILER (2016 Supplement) GENERAL INFORMATION (2017 Supplement) GENERAL INFORMATION (2016 Basic) SPECIAL TOOLS (2017 Supplement) SPECIAL TOOLSTROUBLESHOOTING DIAGNOSIS TROUBLESHOOTING FLOW SYMPTOM CHART<INSIDE REAR VIEW MIRROR>SYMPTOM PROCEDURES<INSIDE REAR VIEW MIRROR>ON-VEHICLE SERVICEINSTRUMENT PANEL ASSEMBLYGLOVE BOXINSTRUMENT CENTRE PANEL (2016 Basic) INSTRUMENT CENTRE PANEL REMOVAL AND INSTALLATION (2016 Supplement) INSTRUMENT CENTRE PANEL REMOVAL AND INSTALLATIONINSTRUMENT LOWER PANELFLOOR CONSOLE ASSEMBLYFRONT FLOOR CONSOLE ASSEMBLY (2016 Basic) FRONT FLOOR CONSOLE ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) FRONT FLOOR CONSOLE ASSEMBLY REMOVAL AND INSTALLATIONREAR FLOOR CONSOLE ASSEMBLYTRIMSINTERIOR TRIMDOOR TRIM (2016 Basic) DOOR TRIM REMOVAL AND INSTALLATION (2016 Supplement) DOOR TRIM REMOVAL AND INSTALLATIONTAILGATE TRIMHEADLINING (2016 Basic) HEADLINING REMOVAL AND INSTALLATION (2016 Supplement) HEADLINING REMOVAL AND INSTALLATION (2017 Supplement) HEADLINING REMOVAL AND INSTALLATIONINSIDE REAR VIEW MIRRORFRONT SEAT ASSEMBLY (2016 Basic) FRONT SEAT ASSEMBLY REMOVAL AND INSTALLATION (2016 Supplement) FRONT SEAT ASSEMBLY REMOVAL AND INSTALLATION (2016 Basic) FRONT SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLY (2016 Supplement) FRONT SEAT ASSEMBLY DISASSEMBLY AND REASSEMBLY (2016 Basic) FRONT SEAT ASSEMBLY INSPECTION<Vehicles with power seat> (2016 Supplement) FRONT SEAT ASSEMBLY INSPECTIONSECOND SEAT ASSEMBLY (2016 Supplement) SPECIAL TOOL(S)TROUBLESHOOTING (2016 Supplement) SYMPTOM CHARTSYMPTOM PROCEDURES (2016 Supplement) POWER SUPPLY CIRCUIT (2016 Supplement) THE HEATED SEAT DOES NOT RESPOND WHEN THE HEATED SEAT SWITCH IS SWITCHED BETWEEN HI AND LO. (2016 Supplement) THE HEATED SEAT SWITCH INDICATOR DOES NOT ILLUMINATE AT ALL OR DOES NOT CORRESPOND TO THE HI/LO SWITCH POSITION. (2016 Supplement) CHECK AT ECU TERMINALSECOND SEAT ASSEMBLY